MATERIAL SAFETY DATA SHEET
Date Printed: 07/25/2008
Product Code(s): 4025
1. CHEMICAL PRODUCT AND COMPANY INFORMATION
Product Name: "Only 1" Weather strip Adhesive
Product Code(s): 4025
Distributor in New Zealand
Manufacturer/Supplier:
R A Johnstone & Co Ltd
TRANSTAR AUTOBODY TECHNOLOGIES
2040 Heiserman Dr. 739 Great South Road, Otahuhu
Brighton, MI, 48114, USA PO Box 97 948 SAMC. Manukau 2240
Auckland. New Zealand
24 Hour Emergency Phone(s):
Ph :+64 9 261 0333
800-424-9300 (CHEMTREC),
613-996-6666 (CANUTEC) Fax: + 64 9 261 0330
www.raj.co.nz
Business Phone: 810-220-3000
Emergency telephone in New Zealand (24 hours)
Product Use: Adhesive National Poison Center: 0800 POISON [764 766]
MSDS Prepared By: Transtar Autobody Technologies
COMPOSITION/INFORMATION ON INGREDIENTS
2.
Ingredient(s) CAS Number % by Weight
---------------------------------------------------------------------------
* Methylbenzene; Toluene 108-88-3 25- 40%
* Hexane 110-54-3 15- 25%
Styrene-Butadiene Copolymer 9003-55-8 15- 25%
See Section 15. Regulatory Information for code descriptions
Weight percent (%) of 0.0 means chemical is in trace amounts.
3. HAZARDS IDENTIFICATION
DANGER! FLAMMABLE. IRRITANT.
HMIS Hazard Ratings: Health =2*, Flammability =3, Chemical Reactivity =0
Note: HMIS ratings involve data and interpretations that may vary
from company to company. They are intended only for rapid, general
identification of the magnitude of the specific hazard. To deal
adequately with the safe handling of this material, all the
information contained in this MSDS must be considered.
====================================================================================
Safety Data Sheet - "Only 1" Weather strip Adhesive Page 1 of 6
Potential Health Effects
Eyes: Moderate irritation to the eyes. Exposure can cause redness and
itching.
Skin: Moderate irritation to the skin. May be absorbed through the skin
causing liver, kidney, central nervous system damage. Prolonged contact
with this product can cause reddening, swelling, rash scalling or
blistering.
Inhalation: Moderate irritation to the respiratory system. May be harmful
if inhaled. High concentrations may be fatal.
Ingestion: Moderate irritation to the digestive tract. May cause nausea.
The HSNO Approval Number for this Group Standard is HSR002662.
4. FIRST AID MEASURES
Seek professional medical attention for all over-exposures and/or
persistent problems.
Eyes Contact: Flush eyes with clean water for a minimum of 15 minutes.
Seek medical attention.
Skin Contact: Wash exposed area thoroughly with soap and water.
Inhalation: Remove person from area to fresh air. If breathing
difficulty persists, seek medical attention.
Ingestion: DO NOT INDUCE VOMITTING. Seek immediate medical attention.
5. FIRE FIGHTING MEASURES
Flammable Properties
Flash Point: -7 Deg F, -22 Deg CMethod: TCC
Upper Explosive Limit (UEL): 7.5
Lower Explosive Limit (LEL): 1.1
Autoignition Temperature: No data
Extinguishing Media: Foam, Alcohol Foam, CO2, Dry Chemical, Water Fog,
Other.
Special Firefighting Procedures: Full fire fighter equipment including
SCBA should be worn to avoid skin contact and inhalation of
concentrated vapors. Minimize skin exposure. Highly toxic fumes may
be generated by thermal decomposition.
Hazardous Combustion Products: Carbon monoxide, carbon dioxide, oxides
of nitrogen.
Unusual Fire and Explosion Hazards: Vapors can travel to a source of
ignition and flash back. Closed containers may explode when exposed
to extreme heat or burst when contaminated with water (CO2 gas
====================================================================================
Safety Data Sheet - "Only 1" Weather strip Adhesive Page 2 of 6
evolved). Hazards apply to empty containers. Combustion generates
toxic fumes.
6. ACCIDENTAL RELEASE MEASURES
For large spills or transportation accidents involving release of this
product, contact the Emergency Response Center: 800-424-9300.
Eliminate all sources of ignition, provide adequate ventilation, dike
spill area and add absorbent earth or sawdust to spilled liquid. Sweep
up and dispose of in appropriate containers in accordance with
Federal, State and/or Local regulations.
7. HANDLING AND STORAGE
Use non-sparking tools when handling this material. Use in cool,
well-ventilated areas. Keep containers closed when not in use. Keep
away from excessive heat and open flames. Follow all MSDS/label
precautions even after container is emptied because they may retain
product residues. Store in a cool area away from heat and flames. Do
not reuse container when empty.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Exposure Guidelines
Chemical Name/Exposure Limits CAS Number
---------------------------------------------------------------------------
* Methylbenzene; Toluene 108-88-3
OSHA PEL: 200 ppm, 300 ppm ceiling
ACGIH TLV: 50 ppm (skin)
IDLH: 500 ppm
* Hexane 110-54-3
OSHA PEL: 500 ppm, ACGIH TLV: 50 ppm,skin
IDLH 1100 ppm (10% LEL)
Styrene-Butadiene Copolymer 9003-55-8
OSHA PEL: NA, ACGIH TLV: NA, OTHER: NA
Engineering Controls: General mechanical ventilation or local exhaust
should be utilized to keep vapor concentrations below exposure limits
(PEL & TLV). Ventilation equipment must be explosion proof.
Respiratory Protection: Utilize engineering controls to reduce
emission levels below the time weighted exposure limits (ACGIH TLV &
OSHA PEL). Wear an approved respirator if exposure limits are above
the exposure limits listed above.
Eye Protection: Use safety glasses or splash goggles.
Skin Protection: Use chemical resistant gloves.
Safe Work Practices: Eye washes and safety showers in the workplace
are recommended. Avoid contact with skin and eyes. Avoid breathing
vapors. Wash hands thoroughly after using and before eating, drinking
or smoking. Employee education and training in the safe use and
handling of this product is required under the OSHA Hazard
Communication Standard 29CFR1200. Smoking in area where this material
====================================================================================
Safety Data Sheet - "Only 1" Weather strip Adhesive Page 3 of 6
is used should be strictly prohibited. Always use protective clothing
and equipment. Remove all contaminated clothing and wash thoroughly
when finished working. Keep food and drink away from material and
from area where material is being used.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical Form: Homogeneous mixture
Physical State: Viscous liquid
Color: Cloudy, colorless
Odor: Organic solvent
Odor Threshold: No Data
Specific Gravity (water=1) 0.87
Vapor Pressure: No data
Vapor Density: Heavier than air
Material VOC: 3.58 lb/gl 429 g/l
Coating VOC: 3.58 lb/gl 429 g/l
Evaporation Rate: Slower than Butyl Acetate
Boiling Point: 69 Deg C
Melting Point: No data
Freezing Point: No data
Viscosity at Ambient Temperature: No data
Solubility in Water: Insoluble
Octanol/Water Partition Coefficient: No data
pH: No data
10. STABILITY AND REACTIVITY
Stability: Stable
Incompatibility: Strong acids, strong bases and strong oxidizing
agents.
Hazardous Polymerization: Will not occur.
11. TOXICOLOGICAL INFORMATION
Effects of Exposure:
ACUTE:
INHALATION - Dizziness, breathing difficulty, headaches, & loss of
coordination.
EYE CONTACT - Moderate irritation, tearing, redness, and blurred
vision.
SKIN CONTACT - Moderate irritant. Can dry and defat skin causing
cracks, irritation, and dermatitis.
INGESTION - Can cause gastrointestinal irritation, vomiting, nausea, &
diarrhea.
CHRONIC:
May affect liver, kidney and central nervous system with repeated
exposure.
Acute Toxicity Data: No data.
Carcinogenicity: NTP -No, IARC -No, OSHA -No
This product has not been tested for carcinogenic effects. Some
chemicals in this product may be identified by NTP, IARC and/or OSHA
as carcinogenic, indicated above as "Yes". No further information
====================================================================================
Safety Data Sheet - "Only 1" Weather strip Adhesive Page 4 of 6
available.
Teratology: No data.
Reproduction: No data.
Mutagenicity: No data.
12. ECOLOGICAL INFORMATION
No data.
13. DISPOSAL CONSIDERATIONS
Subject to hazardous waste generation, treatment, storage and
disposal. Product should be disposed of in accordance with all
governmental regulations. Subject to hazardous waste generation,
treatment, storage and disposal under RCRA, 40CFR261. Product should
be disposed of in accordance with all Federal, State and local
regulations.
14. TRANSPORT INFORMATION
The following transportation information is provided based on Transtar
Autobody Technologies interpretation of shipping regulations. Each
shipper is responsible for identifying, naming, marking and labeling
prior to offering for transport.
USA (DOT) Status: Consumer Commodity ORM-D For inner packagings not
exceeding 5 L each packaged in a strong outer box: CONSUMER COMMODITY
ORM-D
Water (IMDG) Status: UN1133, Adhesive, 3, PGII
Air (ICAO,IATA) Status: UN1133, Adhesive, 3, PGII
Canada (TDG) Status: Consumer Commodity ORM-D For inner packagings not
exceeding 5 L each packaged in a strong outer box: CONSUMER COMMODITY
15. REGULATORY INFORMATION
The information listed in this section is not all inclusive of all
regulations for this product or the chemical components of this
product.
US Federal Regulations
TSCA Status: All known major components of this product are listed on
the TSCA Inventory and/or are otherwise in compliance with TSCA.
SARA 302 (EHS) Status: No EHS chemicals present.
SARA 311/312 Status: Immediate Health Hazard, Delayed Health Hazard,
Fire Hazard.
SARA 313 Status: * Indicates toxic chemical(s) subject to the
reporting requirements of section 313 of Title III and of 40 CFR 372.
====================================================================================
Safety Data Sheet - "Only 1" Weather strip Adhesive Page 5 of 6
OSHA Status: This material meets the requirement of hazardous material
and is subject to 29CFR1910.1200.
USA State Information
California Proposition 65: WARNING: This product contains chemical(s)
known to the State of California to cause birth defects or other
reproductive harm.
Pennsylvania RtK Status: This material contains chemical(s) subject to
notification under Pennsylvania Right to Know.
New Jersey RtK Status: This material contains chemical(s) subject to
notification under New Jersey Right to Know.
Massachusetts RtK Status: This material contains chemical(s) subject
to notification under Massachusetts Right to Know.
Rhode Island RtK Status: This material contains chemical(s) subject to
notification under Rhode Island Right to Know.
International Regulations
Canada
DSL Status: All known major components of this product are listed on
the DSL Inventory and/or are otherwise in compliance with the DSL
NDSL Status: Contains no chemicals on the NDSL
WHMIS: B2D2B
New Zealand
The HSNO Approval Number for this Group Standard is HSR002662.
EINECS Status: All components of this material are listed on the
EINECS Inventory.
16. OTHER INFORMATION
To the best of our knowledge, the information contained herein is
accurate, obtained from sources believed by Transtar Autobody
Technologies to be accurate. As with all chemicals, KEEP AWAY FROM
CHILDREN AND ANIMALS. FOR PROFESSIONAL USE ONLY. The hazard
information contained herein is offered solely for the consideration
of the user, subject to his own investigation and verification of
compliance with applicable regulations, including the safe use of the
product under every foreseeable condition.
________________________________________________________________________________
Converted to New Zealand Standard by Sam Gunaratna B Sc, Post-Grad Dip in Science (University of Auckland)
Ph: 02102776004; email: olu@ihug.co.nz September 2008
====================================================================================
Safety Data Sheet - "Only 1" Weather strip Adhesive Page 6 of 6
|