MATERIAL SAFETY DATA SHEET
PRODUCT NAME: NEOPRENE CEMENT, LP33 (CLEAR AND BLACK) LP31
MSDS DATE: 5/8/1996
I HAZARDOUS INGREDIENTS / SARA III INFORMATION
OCCUPATIONAL EXPOSURE LIMITS VAPOR PRESSURE WEIGHT
HAZARDOUS COMPONENTS CAS # OSHA PEL ACGIH TLV OTHER MM HG @ TEMP PERCENT
TOLULENE* 108-88-3 100 PPM 100 PPM 22.0 68F 11
HEXANE 110-54-3 50 PPM 50 PPM 140.0 68F 45
METHYL ETHYL KETONE* 78-93-3 200 PPM 200 PPM 74.9 68F 27
* INDICATES TOXIC CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313
OF TITLE III AND OF 40 CRF 372. WARNING..... THIS PRODUCT CONTAINS CHEMICALS KNOWN TO
THE STATE OF CALIFORNIA TO CAUSE CANCER AND / OR BIRTH DEFECTS OR OTHER REPRO-
DUCTIVE HARM.
II PHYSICAL DATA
APPEARANCE & ODOR: LOW VISCOSITY LIQUID WITH MILD NON-RESIDUAL ODOR
BOILING POINT APPROX. 156 F SPECIFIC GRAVITY 0.8
WATER =1
SOLUBILITY IN WATER NIL EVAP. RATE (BUAC=1) SLOWER THAN ETHER
III FIRE & EXPLOSION HAZARD
FLASH POINT= -10 DEG F METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: 1.0% UPPER: 11.4%
SPECIAL FIREFIGHTING PROCEDURES: SELF CONTAINED BREATHING APPARATUS IS REQUIRED
FOR FIRES IN ENCLOSED AREAS.
EXTINGUISHING MEDIA: FOAM, C02, DRY CHEMICAL, WATER FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS; VOLATILE SOLVENT CONSTITUENT CAN READILY FORM EXPLOSIVE OR
FLAMMABLE MIXTURES IN AIR. VAPORS CAN FLOW ALONG SURFACES TO DISTANT IGNITION SOURCES AND FLASH
BACK.
PAGE 2 OF 3 PRODUCT NAME: NEOPRENE CEMENT
IV REACTIVITY DATA
STABILITY HAZARDOUS HAZARDOUS
POLYMERIZATION DECOMP. BYPRODUCT
(X)STABLE ( ) MAY OCCUR
( )UNSTABLE (X)WILL NOT OCCUR BURNING MAY PRODUCE C02, C0, HCL
CONDITIONS TO AVOID; KEEP AWAY FROM ALL SOURCE OF IGNITION AND HEAT.
INCOMPATIBILITY (MATERIALS TO AVOID); STRONG OXIDIZATION AGENTS CAN CAUSE
SPONTANEOUS COMBUSTION.
V HEALTH HAZARD INFORMATION & FIRST AID PROCEDURES
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
HIGH CONCENTRATIONS, OR PROLONGED EXPOSURE TO LOWER CONC., MAY BE IRRITATING TO MUCOUS MEM-
BRANES AND MAY CAUSE CNS DEPRESSION.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
LIQUID OR HIGH VAPOR CONCENTRATION CONTACT CAN BE SEVERELY IRRITATING TO THE EYES. PROLONGED OR
REPEATED LIQUID CONTACT CAN RESULT IN DRYING OF THE SKIN WHICH MAY RESULT IN SKIN IRRITATION AND
DERMATITIS.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
UNKNOWN. NOT LIKELY TO OCCUR.
INGESTION HEALTH RISK AND SYMPTOMS OF EXPOSURE
MODERATE CNS DEPRESSION MAY BE SHOWN BY GIDDINESS, HEADACHE, DIZZINESS, AND NAUSEA. IF VOMITING
OCCURS, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID INTO THE LUNGS. ASPIRATION PNEUMONI-
TIS MAY BE EVIDENCED BY COUGHING AND CYANOSIS.
HEALTH HAZARDS (ACUTE AND CHRONIC)
ACUTE: MAY CAUSE EYE, OSE RESPIRATORY TRACT, AND SKIN IRRITATION. HEADACHE, DIZZINESS, DROWSINESS
AND NAUSEAARE ALSO SYMPTOMS. CHRONIC; HIGH CONCENTRATIONS OF VAPOR MAY CAUSE NARCOSIS OR CNS
DEPRESSION. LONG TERM SKIN CONTACT CAN RESULT IN IRRITATION AND DRYING OF THE SKIN. SEE ADDENDUM
FOR FURTHER CHRONIC EFFECTS.
CARCINOGENICITY; NTP? NO IARC MONOGRAPHS? NO OSHA REGULATED? NO
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
SKIN CONTACT MAY AGGRAVATE AN EXISTING DERMATITIS. PREEXISTING EYE AND RESPIRATORY DISORDERS MAY
BE AGGRAVATED.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING, IF REQUIRED. PROVIDE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION. EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINUTES WITH
EYELIDS OPEN. GET MEDICAL EXAM. & TREATMENT. INGESTION: DO NOT INDUCE VOMITING. IF VOMITING OCCURS,
KEEP HEAD BELOW HIPS TO PREVENTASPIRATION. GET MEDICAL ATTENTION. NOTE TO PHYSICIAN: IF MORE THAN
2.0 ML PER KG HAS BEEN INGESTED, ENISIS SHOULD BE INDUCED.
PAGE 3 OF 3 PRODUCT NAME: NEOPRENE CEMENT
VI PRECAUTION FOR SAFE HANDLING AND USE
MATERIAL IS SPILLED / RELEASED HANDLE AS A FLAMMABLE LIQUID. REMOVE ALL IGNITION SOURCES. SOAK UP WET
MATERIAL ON A NON-COMBUSTIBLE ABSORBENTAND PLACE IN A CLOSED METAL CONTAINER.
WASTE DISPOSAL FOLLOW ALL FEDERAL, STATE AND LOCAL WASTE REGULATIONS,
SOLID INGREDENTS NOT CONSIDERED HAZARDOUS.
HANDLING & STORAGE; STORE IN COOL, WELL VENTILATED AREAS AWAY FROM ANY IGNITION SOURCES AND STRONG OXIDIZ-
ING AGENTS. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN USE. DO NOT TRANSFER TO PLASTIC CONTAINERS.
OTHER PRECAUTIONS: GROUND AND BOND METAL CONTAINERS WHEN DISPENSING. NO SMOKING IN AREAS OF USE OR STOR-
AGE. USE ONLY NON-SPARKING TOOLS NEAR WETADHESIVE OR SOLVENT VAPORS. SOLVENT VAPOR MUCH HEAVIER THAN AIR
AND CAN COLLECT IN DANGEROUS CONCENTRATIONS IN FLOOR DRAINS OR LOW AREAS.
VII CONTROL MEASURES
RESPIRATORY PROTECTION
WEAR A NIOSH APPROVED SELF CONTAINED BREATHING APPARATUS IN THE PRESSURE
DEMAND MODE, OR A FULLFACE SUPPLIED AIR RESPIRATOR.
VENTILATION
MECHANICAL VENTILATION AND / OR LOCAL EXHAUST, SUFFICIENT IN PATTERN AND VOLUME,
TO MEET TLV REQUIREMENTS AND PREVENT EXPLOSIVE CONCENTRATIONS O SOLVENT
VAPORS.
PROTECTIVE GLOVES
USE POLYETHYLENE OR NITRILE GLOVES IF FREQUENT SKIN CONTACT IS LIKELY.
EYE PROTECTION
SAFETY GLASSES WITH SPLASH GUARDS OR SIDE SHIELDING RECOMMENDED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
EYE WASH FOUNTAIN OR BOTTLES. SOLVENT INSOLUBLE BARRIER HAND CREAM.
WORK / HYGIENIC PRACTICES
DO NOT WEAR, CONTACT LENSES. WASH CONTAMINATED CLOTHING BEFORE REUSE.
MSDS PREPARED BY: QUALITY CONTROL DEPT.
THE INFORMATION CONTAINED HEREIN HAS BEEN DEVELOPED BASED UPON CURRENT AVAILABLE SCIENTIFIC DATA. NEW
INFORMATION MAY BE DEVELOPED FROM TIME T0 TIME WHICH MAY RENDER THE CONCLUSIONS OF THIS REPORT OBSOLETE.
THEREFORE, NO WARRANTY IS EXTENDED AS TO THE APPLICABILITY OF THIS INFORMATION TO THE USER'S INTENDED PUR-
POSE OR FOR THE CONSEQUENCES OF ITS USE OR MISUSE