Superior Graphite Co.
1. Chemical Product and Company Identification
Product Name: MowerGUARD (R)
Manufacturer: Superior Graphite Co.
Address: 10 S. Riverside Plaza
Chicago IL 60606
Information Number: (312) 559-2999
2. Composition/Information on Ingredients
Hazardous Components CAS# OSHA PEL ACGIH TLV Other Limits %
Graphite, Natural 7782-42-5 2.5 mg/m3 2.0 mg/m3 None <10
(as respirable dust)
Silica, Crystalline Quartz 14808-60-7 0.1 mg/m3 0.05 mg/m3 None <0.1
(as respirable dust)
Toluene 108-88-3 100 ppm 50 ppm None 2.4%.
Acetone 67-64-1 1000 ppm 500 ppm 750 STEL <45
VM&P Naphtha 8032-32-4 300 ppm 300 ppm None 5-15
Petroleum Distillate Blend Blend None 5-15
Heptane 400 ppm 400 ppm
Methylcyclohexane 400 ppm 400 ppm
Propane 74-98-6 1000 ppm 1000 ppm None <25
Notes:
Toluene is a toxic chemical subject to the reporting requirements of section 313 of Sara Title III and of 40 CFR 372.Tests performed
on natural graphite have shown quartz levels ranging from 2% to 10%.
3. Hazards Identification
Route (s) of Entry: Inhalation Skin Ingestion
Yes Yes Yes
Health Hazards (acute and chronic): Eyes, skin and respiratory system irritant. Narcotic in high
concentrations. Severe overexposure may cause damage to the blood. Reports have associated
repeated and prolonged occupational exposure to solvents with permanent brain and nervous system and
other internal organ damage.
Carcinogenicity: NTP IARC Monographs OSHA Regulated
No Yes No
Notes:
Silica as quartz; animal sufficient evidence, human sufficient evidence.
1
Superior Graphite Co.
Signs and Symptoms of Exposure:
Inhalation: Respiratory irritation, dizziness, headache, nausea, fatigue, drowsiness, impaired
coordination, central nervous system depression or heart arrhythmia.
Skin: Contact may dry the skin prolonged contact may cause irritation. Can not be easily absorbed
through the skin. Solvent action can dry and defat the skin causing skin to crack, leading to dermatitis.
Eyes: Liquid or vapor can cause moderate to severe irritation.
Ingestion: Not a likely route of exposure.
Medical Conditions Generally Aggravated by Exposure: Liver and kidney disease, anemia, coronary
disease or rhythm disorders of the heart.
4. First Aid Measures
Eyes: Flush thoroughly with water for 15 minutes. Get medical attention.
Skin: Wash exposed skin with soap and water. If irritation persists get medical attention.
Launder severely contaminated clothing before reuse.
Ingestion: Do not induce vomiting. Get medical attention.
Inhalation: Remove to fresh air. Administer oxygen if needed. Apply artificial respiration if
breathing has stopped. Get medical attention.
5. Fire Fighting Measures
Flash Point: (method) N/A Flammable Limits: LEL: UEL:
N/D N/D
Extinguishing Media: Foam, carbon dioxide, dry chemical or water spray (fog).
Special Fire Fighting Procedures: Wear a NIOSH approved self contained breathing apparatus to fight a
fire involving this material. Water spray may be ineffective. Water may be used to cool containers to
prevent pressure build-up and explosion when exposed to extreme heat. If water is used, fog nozzles are
preferred.
Unusual Fire and Explosion Hazards: Closed containers may explode from internal pressure build-up
when exposed to extreme heat and discharge contents. Vapor accumulation can flash or explode if
ignited. Overexposure to decomposition products may cause a health hazard. Symptoms may not be
immediately apparent. Obtain medical attention.
NFPA Hazard Rating:
Health Flammability Reactivity
2 4 0
NFPA Notes:
6. Accidental Release Measures
Spill/Leak Procedures: Avoid breathing vapors. Ventilate area, remove all sources of ignition. Clean up
area with absorbent material and place in closed containers for disposal.
Dispose of in accordance with local, state and federal regulaitons.
2
Superior Graphite Co.
7. Handling and Storage
Handling and Storage Precautions: Store and use in cool, dry, well-ventilated areas. Do not store above
120 F. Do not puncture or incinerate (burn) cans. Do not stick a pin, nail or any other sharp object into
opening on top of can. Do not spray in eyes. Do not take internally. See product label for additional
information. Small pressurized containers of flammable products may be stored in areas suitable for
ordinary combustibles with respect to construction, drainage, control of ignition sources and ventilation
except that they should not be stored in basements.
Work/Hygienic Practices: Follow good hygienic practice for solvent borne products. Use adequate
ventilation. Wash hands and face after handling this product.
8. Exposure Controls /Personal Protection
Respiratory Protection (specify type): Use NIOSH/MSHA approved mask for chemical products if ACGIH,
OSHA and/or TWA limits will be exceeded.
Local Exhaust Mechanical (general) Special Other
Required Required None None
Eye/Face Protection: Goggles, safety glasses or face shield. Eye wash station should be available.
Skin Protection: Chemical resistant gloves. Safety shower should be available.
9. Physical/Chemical Characteristics
Physical State: Liquid Boiling Point: N/A
Appearance: Aerosol Melting Point: N/A
Odor: Solvent Vapor Pressure (mm Hg): N/A
Specific Gravity (H2O=1): N/A Vapor Density (air=1): N/A
Water Solubility: Slight Evaporation Rate: N/A
(Butyl Acetate = 1)
10. Stability and Reactivity
Stability: Material is stable.
Incompatibility (materials to avoid): Strong oxidizing agents, acids and alkalis.
Hazardous Decomposition Products: On burning, may release carbon dioxide and carbon monoxide.
Hazardous Polymerization: Will not occur.
11. Transportation Information
3
Superior Graphite Co.
(VIA TRUCK)
Consumer Commodity, ORM-D (No flammable label needed)
(Box must be marked "Consumer Commodity, ORM-D")
(VIA AIR)
Aerosols, flammable (Class 2 Flammable Gas label)
Class 2.1 No Pkg. Group UN1950
Box must be marked "Aerosol, flammable, UN1950, LTD. QTY."
(Cover "Consumer Commodity, ORM-D" on pre-printed box)
(VIA OCEAN)
Aerosol (No flammable label needed)
Class 2 No Pkg. Group UN1950
Box must be marked "Aerosol, UN1950"
(Cover "Consumer Commodity ORM-D" on pre-printed box)
12. Other Information
Disclaimer: The information contained herein is based on data available. However, no warranty is
expressed or implied regarding the accuracy of the data or the results obtained from the use thereof.
Because the information contained herein may be applied under conditions beyond our control, we
assume no responsibility for its use.
All components of this product are on the TSCA inventory.
Unk. = Unknown
N/A = Not applicable
Nav = Not available
N/D = Not determined
N/E = Not established
Prop. = Proprietary
Prepared: Date 03/31/2006
4
|