VCTS-6 Clear
PRODUCT:
MSDS ID: ND1027
3/01/93
ORIG. DATE:
11/5/07
REV. DATE:
ND INDUSTRIES , INC. (248) 288-0000 Fax: (248) 288-0022
12/22/08
REV. DATE:
24 hr. EMERGENCY CHEMTREC:
1893 BARRETT ROAD
Chemical Safety
PREPARED BY:
1-800-424-9300
TROY, MICHIGAN 48084
H: 2 F: 1 R: 0 PPE: C
SECTION I -Material Identification and Information
PERCENT OSHA OTHER LIMITS
ACGIH
CAS #
COMPONENTS PEL RECOMMENDED
TLV
%
Acrylic copolymer VTI-00-07 Unassigned 15-20 n.a. n.a. Non-hazardous
Acrylic polymer VTI-00-08 Unassigned 10-15 n.a. n.a. Non-hazardous
1,1,1 Trichloroethane 71-55-6 75-80 350 ppm 350 ppm
All ingredients are listed on the TSCA Inventory. n.a.= not applicable / n.e.=not established
SECTION II -Physical and Chemical Characteristics
BOILING POINT: 74癈
VOC #/gal. : 7.714
VAPOR DENSITY: air = 1
>5.1
DENSITY OF COATING:
VAPOR PRESSURE: 100 mmHg @ 20癈
MELTING POINT: n.a.
SPECIFIC GRAVITY: 1.3 water = 1
EVAPORATION RATE: 0.4
WATER REACTIVE: No
SOLUBILITY IN WATER: 0.08g/100g @ 25癈
APPEARANCE AND ODOR: Clear viscous liquid with non-residual, "solvent- like" odor.
SECTION III - Fire and Explosion Hazard Data
FLASH POINT: n.a.
AUTOIGNITION TEMPERATURE: n.a.
UEL: 15.0
FLAMMABILITY LIMITS % IN AIR: LEL: 7.5
EXTINGUISHER MEDIA: Use water spray, carbon dioxide, dry chemicals and/or foam.
Wear a NIOSH approved self-contained breathing apparatus with full face piece operated in pressure-demand or
SPECIAL
positive pressure mode when fighting fires. Cool fire exposed containers with water.
FIREFIGHTING
PROCEDURES:
UNUSUAL FIRE Concentrated vapors can be ignited by high intensity heat source. Combustion yields oxides of carbon, chlorine and
HAZARDS AND small quantities of phosgene.
CONDITIONS TO
AVOID:
PRODUCT: VCTS-6 Clear
SECTION IV - Reactivity Hazard Data
STABILITY: stable: X unstable:
HAZARDOUS POLYMERIZATION: may occur: will not occur: X
CONDITIONS Avoid all sources of ignition, heat, fire, etc...
TO AVOID:
INCOMPATIBILITY: Avoid contact with acids, bases, amines, oxidizing agents, halogens and molten sulfur
HAZARDOUS Decomposition may yield acrylic monomers.
DECOMPOSITION
PRODUCTS:
SECTION V - Health Hazard Data
X X
PRIMARY ROUTES OF ENTRY: X
INHALATION: INGESTION: SKIN ABSORPTION:
EYE CONTACT: Eye contact can cause severe eye irritation with transient or permanent corneal injury.
FIRST AID: Immediately flush eyes with generous amounts of water for 15 minutes lifting both upper and
lower eyelids occasionally. Get prompt medical attention.
Contact can result in moderate skin irritation. Prolonged or repeated contact can cause defatting and drying of
SKIN
the skin which can lead to irritation and dermatitis.
CONTACT:
Thoroughly wash exposed area with soap and water. If irritation occurs, seek medical attention.
FIRST AID:
Inhalation of material can result in anesthetic or narcotic effect. High levels of exposure can cause dizziness,
INHALATION:
drunkenness, loss of consciousness and death.
Move subject to fresh air. If breathing is difficult give oxygen. Give artificial respiration if breathing has stopped.
FIRST AID:
Get prompt medical attention.
INGESTION: Ingestion of this material can result in aspiration of material into lungs resulting in injury to other body systems.
FIRST AID: Do NOT induce vomiting. Immediately drink two glasses of water and get medical
attention. Never give anything by mouth, to an unconscious person.
Long term exposure at high concentrations may lead to CNS Depression.
CHRONIC
EFFECTS:
Carcinogenic: Not listed.
PRODUCT: VCTS-6 Clear
Component Oral LD50 Dermal LD50 Inhalation LC50
not determined
>3000 mg/Kg (rabbit)
Acrylic copolymer >5000 mg/Kg (rat)
not determined
not determined
Acrylic copolymer not determined
not determined
15000 mg/Kg (rabbit)
1,1,1-Trichloroethane >10000 mg/Kg (rat)
SECTION VI - Control and Protective Measures
RESPIRATORY Wear NIOSH approved respirator in high vapor concentrations.
PROTECTION:
PROTECTIVE Use rubber or vinyl.
GLOVES:
EYE PROTECTION: Wear NIOSH approved safety glasses with side shields or chemical splash goggles.
VENTILATION LOCAL EXHAUST: X MECHANICAL: SPECIFIC:
TO BE USED: OTHER (specify):
PROTECTIVE CLOTHING Wear impervious clothing to prevent repeated prolonged skin contact.
AND EQUIPMENT:
Practice careful chemical handling and good personal hygiene when working with product. Wash
HYGIENIC WORK
hands after use.
PRACTICES:
SECTION VII - Precautions for Safe Handling and Spill/Leak Procedures
STEPS TO BE TAKEN IF MATERIAL IS SPILLED OR RELEASED:
Immediately extinguish all sources of ignition. If large spill, absorb material using an inert filler (saw dust, vermiculite or floor absorb) and
transfer to ventilated area. Scrape up small spills and dispose of properly.
Dispose of material in accordance with local, state and federal regulations.
WASTE DISPOSAL
METHODS:
Avoid breathing product vapors. Keep material away from extreme heat or open flame. Keep container lid
SAFE HANDLING
closed when not in use. Store product in a cool dry place.
AND STORAGE:
OTHER PRECAUTIONS AND SPECIAL HAZARDOUS INFORMATION:
Containers of this product may be hazardous when emptied, since containers retain product residue, observe all precautions.
RECOMMENDED 2 1 0 C
HEALTH FLAMMABILITY REACTIVITY PERSONAL
NFPA/HMIS PROTECTION
note: ratings may differ according to application, environment, and physical state.
RATING
PRODUCT: VCTS-6 Clear
NOTES:
DOT Shipping Name:
1,1,1-Trichloroethane solution
6.1, UN2831, PGIII
SECTION 313 SUPPLIER NOTIFICATION
Detaching this notification from the Material Safety Data Sheet is prohibited by law and any copying or
distribution of same requires this attachment be included.
This product contains the following toxic chemicals subject to the reporting requirements of section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 and 40 CFR 372:
CAS # CHEMICAL NAME % BY WEIGHT
71-55-6 1,1,1-Trichloroethane 60
1330-20-7 Xylene 1.65
This product contains the following materials that under California Proposition 65 of the Safe Drinking Water and Toxic
Enforcement Act of 1986 are recognized to cause cancer or reproductive toxicity.
Cancer Reproductive cancer Reproductive
Concentration &
Material CAS # agent Toxin
Agent Toxin
%
Toluene 108-88-3 0.36 % X
ND Vibra-Tite?is a registered trademark of ND Industries,Inc.
The information contained herein is based on the data available to us and is believed to be correct. However, ND Industries?
Inc. makes no warranty, expressed or implied regarding the accuracy of these data or the results to be obtained from the use
thereof. Information is supplied upon the condition that the persons receiving same will make their own determination as to its
suitability for their properties prior to use. Since conditions of use are beyond our control, all risks are assumed by the user.
|