MATERIALS HEALTH, SAFETY AND ENVIRONMENTAL SHEET
Prepared 01/01/2006
NFPA PLACARD CODE
FIX STIXTM
Product Name: Producer's Name: InduMar Products, Inc. HMIS CODE
Address: P.O. Box 770008
Health -1 Slight
For Information: Office (713) 977-4100 Houston, TX 77215-0008
Fire -0 Minimal
Fax (713) 977-4164 Reactivity -0 Minimal
Section I. Product Identification and DOT Requirements
Known Hazards Under 29 CFR 1910.1200 (continued):
PRODUCT CHEMICAL CHEMICAL
NAME FAMILY NAME FORMULA
YES NO YES NO
Organic peroxide X Blood toxin X
FIX STIXTM Epoxy & polymercaptan resins Not Applicable Mixture
Corrosive material X Nervous system toxin X
Compressed gas X Lung toxin X
Section II. Hazard Information Irritant (possible) X Liver toxin X
Skin hazard X Kidney toxin X
TOXICITY CAS
Reproductive toxin X Other X
100% INGREDIENTS % DATA NUMBER
EPA Hazardous Waste ID No: N/A
2,4,6 - tri (dimethylaminomethyl) phenol 1 5 ppm 8 - hr. TWA 90-72-2
EPA Hazard Waste Class: N/A
Epoxy resin (diglycidyl ether of bisphenol A) 10 Oral LD50 (rbt) = 25068-38-6
20 g/kh
Magnesium silicate 40 14807-96-6
Mercaptan terminated polyether 10 Trade Secret
Amorphous silica 15 67762-90-7 Section III. Physical Data
Crystalline silica 4 14808-60-7
Iron alloy 20 Unknown
Evaporation Rate (BuAC=1): Nil
Boiling Point (癋): N/A
Volatile Components: N/A
Vapor Pressure (MM hg): N/A
Known Hazards Under 29 CFR 1910.1200:
YES NO YES NO Melting Point: N/A
Vapor Density (Air=1): N/A
Combustible liquid X Oxidizer X
Appearance: Putty-like
Solubility in Water: Nil
Flammable liquid X Eye hazard X
Percent Volatile by Volume (%): Nil
Specific Gravity (Water=1): 1.9
Pyrophoric material X Toxic agent X
Explosive material X Highly toxic agent X
Odor: Mercaptan
PH: N/A
Unstable material X Sensitizer (possible) X
Water reactive material X Carcinogen X
MATERIALS HEALTH, SAFETY AND ENVIRONMENTAL SHEET
Preparation Date: 01/01/04
Section VII. Fire and Explosion Hazard Data
Section IV. Emergency Response Data
Fire: Extinguishing Media: Water spray, foam, CO2, dry chemicals Flash Point: None
Special Procedures: None Flammable Limits: LEL/UEL: Not applicable
Unusual Hazards: CO2 aldehydes, acids, oxides of sulfur Stability: Stable
and nitrogen may be formed
Conditions to Avoid: None
Over-Exposure: Inhalation: N/A
Hazardous Polymerization: Will not occur
Ingestion: Induce vomiting
Conditions to Avoid: None
Skin Contact: Wash with soap and water
Hazardous Decomp Products: CO, aldehydes, acids, oxides of S and N
Eye Contact: Flush with water - consult physician
Spills or Leaks: Dispose of in normal manner; not a potential pollutant.
Section VIII. Special Precautions
Waste Disposal: Incinerate in furnace or bury in landfill according to
applicable regulations. No special handling procedures are necessary.
Follow good industrial hygiene practices.
NOT FOR INTERNAL CONSUMPTION. KEEP AWAY FROM CHLDREN.
Section V. Health and Hazard Data
IMPORTANT NOTICE TO PURCHASER: The information contained herein is based
Primary Routes of Entry: Skin contact and eye contact
on data considered accurate. However, no warranty is expressed or implied
regarding the accuracy of this data or the results to be obtained from the use thereof.
Effects of Over-Exposure: Inhalation: None
Ingestion: N/A WARRANTIES:
Skin Contact: Possible sensitizer
Eye Contact: Possible sensitizer The following is made in lieu of all warranties, expressed or implied. Seller's and
Manufacturer's only obligation shall be to replace such quantity of the product proven
to be defective. Neither Seller nor Manufacturer shall be liable for any injury, loss
Section VI. Special Protection Information or damage, direct or consequential, arising out of the use of or the inability to use
the product. Before using, user shall determine the suitability of the product for its
intended use and user assumes all risk and liability whatsoever in connection
Protective Equipment Types:
therewith. The foregoing may not be altered except by an agreement signed by
Eyes: Safety glasses
officers of the Seller and Manufacturer.
Respiratory: None required
Gloves: Polyethylene gloves for prolonged use
Other: None required
Ventilation:
General Mechanical: None required
Local Exhaust: Only if heated above 100癋 (38癈)
Precautions:
Handling and Storage: Avoid eye contact and excessive skin contact Legal responsibility is assumed only for the fact that all studies reported here and all
opinions are those of qualified experts.
Other: Wash with soap and water immediately after use