MATERIAL SAFETY DATA SHEET
A Quick Seal Pipe Repair
I - PRODUCT IDENTIFICATION
Company Name: Nu-Calgon Wholesaler, Inc. Tel No: (314) 469-7000, (800) 554-5499
Address: 2008 Altom Court, St. Louis, MO 63146-4151 CHEMTREC: (800) 424-9300
Product Name: Quick Seal Pipe Repair Product Number: 4299-P
Synonyms: Epoxy adhesive (putty)
II - HAZARDOUS INGREDIENTS OF MIXTURES
MATERIAL CAS# % By Wt TLV PEL
2,4,6 Tri (methyl aminomethyl) phenol 90-72-2
Epoxy resin 25068-38-6
Mercaptan Terminated Polymer unknown
All ingredients are TSCA listed.
III - PHYSICAL DATA
Vapor Pressure: N/A Vapor Density (Air=1) 60-90?F: N/A
Evaporation Rate: N/A VOC Content (% by wt.):
Solubility in H 2O: Negligible pH @ Solution:
pH as Distributed:
Freezing Point 癋:
Appearance: Grey or White Semi-Solid
Boiling Point 癋: N/A
Odor: Slight Mercaptan
Specific Gravity H 2O=1 @25?C: 1.9
IV - FIRE AND EXPLOSION
Flash Point F: N/A Flammable Limits: N/A
Extinguishing Media: Water spray, CO2, dry chemical.
Special Fire Fighting Procedures : Wear SCBA and protective clothing.
Unusual Fire and Explosion Hazards : May generate toxic or irritating fumes.
V - REACTIVITY DATA
Stability - Conditions to avoid : Stable - None.
Incompatibility: Oxidizers.
Hazardous Decomposition Products : Aldehydes, acids, CO, sulfur oxides.
Conditions Contributing to Hazardous Polymerizations : Will not occur.
VI - HEALTH HAZARD DATA
EFFECTS OF OVEREXPOSURE (Medical Conditions Aggravated /Target Organ Effects ),
A. ACUTE (Primary Route of Exposure ) INHALATION: N/A SKIN: Severe Irritation EYES: Severe
Irritation INGESTION: Nausea.
B. SUBCHRONIC, CHRONIC, OTHER : Prolonged skin or eye exposure may cause irritation,
sensitization.
C. MEDICAL CONDITIONS AGGRAVATED BY OVEREXPOSURE : N/A
VII - EMERGENCY AND FIRST AID PROCEDURES
INHALATION: N/A
EYES: Flush with large amounts of water for 15 minutes. Seek medical attention.
SKIN: Wash with soap and water. If irritation persists, seek medical attention.
INGESTION: Give large amounts of water. Induce vomiting. If unconscious, do not give anything by
mouth or induce vomiting. Seek medical attention.
VIII - SPILL OR LEAK PROCEDURE
Spill Management: Pick up spilled paste to prevent disposal in sewers, waterways or soil. Wear
polyethylene gloves.
Waste Disposal Methods : Collect and dispose of as non-hazardous in accordance with all local, state,
and federal regulations.
IX - PROTECTION INFORMATION /CONTROL MEASURES
Respiratory: None
Eye Protection: Safety Glasses Glove: Polyethylene Gloves
Other Clothing and Equipment : N/A
Ventilation: Local exhaust acceptable.
X - SPECIAL PRECAUTIONS
Precautions to be taken in Handling and Storing : Keep container closed when not in use. Do not stand
near heat, sparks or open flame.
Additional Information : Keep out of reach of children. Wash thoroughly before eating , drinking, smoking,
or leaving work area.
NFPA HMIS RATING
Health Hazard.....: 2 Health Hazard.........: 2
Fire Hazard.......: 0 Fire Hazard...........: 0
Reactivity........: 0 Reactivity............: 0
Specific Hazard...: Personal Protection ...: X (Sec. 9)
Revision Date: 10/04/2002
Seller makes no warranty, expressed or implied, concerning the use of this product other than indicated on the label. Buyer assumes all risk of
use and/or handling of this material when such use and/or handling is contrary to label instructions. While Seller believes that the information
contained herein is accurate, such information is offered solely for its customers' consideration and verification under their specific use
conditions.
|