HENKEL LOCTITE CORPORATION
09/08/02
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 01
of 05
Loctite(R) 567 Thread Sealant
56747
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Name: Loctite(R) 567 Thread Sealant
PST(R) Pipe Sealant With Teflon(R)
Item No.: 56747
Product Type: Anaerobic
2. COMPOSITION, INFORMATION ON INGREDIENTS
Ingredients CAS No. %
Bisphenol A fumarate resin 39382-25-7 30-35
Polyglycol dimethacrylate 25852-47-5 20-25
Polyglycol laurate 9004-81-3 20-25
Poly(ethylene) 9002-88-4 5-10
Poly(tetrafluoroethylene) 9002-84-0 5-10
TITANIUM DIOXIDE 13463-67-7 3-5
CUMENE HYDROPEROXIDE* 80-15-9 1-3
N,N-Dialkyltoluidines 613-48-9 1-3
Saccharin 81-07-2 1-3
SILICA, AMORPHOUS, FUMED,
CRYSTALLINE-FREE 112945-52-5 1-3
Epoxy resin 25068-38-6 0.1-1
* This component is listed as a SARA Section 313 Toxic Chemical.
Ingredients which have exposure limits
Exposure Limits (TWA) ACGIH OSHA OTHER
Ingredients (TLV) (PEL)
Poly(tetrafluoroethylene) None None AEL
(DuPont)
5mg/m3 8hr
dust
TITANIUM DIOXIDE 10 mg/m3 15 mg/m3 None
Total dust
CUMENE HYDROPEROXIDE None None
1ppm(6mg/m3)
Skin(WEEL)
SILICA, AMORPHOUS, FUMED,
CRYSTALLINE-FREE 10 mg/m3 TWA 6 mg/m3 TWA 3 mg/m3 TWA
resp. dust
Exposure Limits (STEL) ACGIH OSHA
Ingredients (TLV) (PEL)
HENKEL LOCTITE CORPORATION
09/08/02
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 02
of 05
Product Name: Loctite(R) 567 Thread Sealant
PST(R) Pipe Sealant With Teflon(R)
Item No.: 56747
3. HAZARDS IDENTIFICATION
Toxicity: Moderate eye irritant.
Primary Routes of Entry: None known
Signs and Symptoms
of Exposure: May cause dermatitis on prolonged contact in
sensitive individuals
Existing Conditions
Aggravated by Exposure: None known
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC
OSHA
Bisphenol A fumarate resin ALG IRR NO NO NO
Polyglycol dimethacrylate ALG IRR NO NO NO
Polyglycol laurate ALG NO NO NO
Poly(ethylene) NTO NO N/A NO
Poly(tetrafluoroethylene) NTO NO N/A NO
TITANIUM DIOXIDE IRR RES NO NO NO
CUMENE HYDROPEROXIDE ALG CNS COR IRR MUT NO NO NO
N,N-Dialkyltoluidines NTO NO NO NO
Saccharin NTO NO N/A NO
SILICA, AMORPHOUS, FUMED,
CRYSTALLINE-FREE NUI NO N/A NO
Epoxy resin ALG IRR NO NO NO
------------------------------------------------------------------------------
-
Abbreviations
N/A Not Applicable ALG Allergen
CNS Central nervous system COR Corrosive
IRR Irritant MUT Mutagen
NTO No Target Organs NUI Nuisance dust
RES Respiratory
4. FIRST AID MEASURES
Ingestion: Do not induce vomiting. Keep individual calm.
Obtain medical attention.
Inhalation: Does not apply
Skin Contact: Wash with soap and water.
Eye Contact: Flush at least 15 minutes with water. Obtain
medical attention.
HENKEL LOCTITE CORPORATION
09/08/02
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 03
of 05
Product Name: Loctite(R) 567 Thread Sealant
PST(R) Pipe Sealant With Teflon(R)
Item No.: 56747
5. FIRE FIGHTING MEASURES
Flash Point: More than 200癋 Method: Tag Closed Cup
Recommended
Extinguishing Agents: Carbon dioxide, foam, dry chemical
Special Firefighting
Procedures: Not available
Hazardous Products formed
by Fire or Thermal Decomp Irritating organic vapors
Unusual Fire or
Explosion Hazards: None
Explosive Limits:
(% by volume in air)Lower Not available
(% by volume in air)Upper Not available
6. ACCIDENTAL RELEASE MEASURES
Steps to be taken in case
of spill or leak: Soak up in an inert absorbent. Store in a
partly
filled, closed container until disposal.
7. HANDLING AND STORAGE
Safe Storage: Store below 100癋
(Contact Loctite Customer Service 1-800-243-4874 for shelf life
information)
Handling: Avoid prolonged skin contact. Keep away from
eyes.
8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Eyes: Safety glasses or goggles.
Skin: Rubber or plastic gloves.
Ventilation: Does not apply
Respiratory NIOSH approved respirator if ventilation is
inadequate.
See Section 2 for Exposure Limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: White paste
Odor: Mild
Boiling Point: More than 300癋
pH: Does not apply
Solubility in Water: Slight
Specific Gravity 1.14 at 80癋
Volatile Organic Compound
(EPA Method 24) 8.6%; 98.04 grams per liter
Vapor Pressure: Less than 5mm at 80癋
HENKEL LOCTITE CORPORATION
09/08/02
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 04
of 05
Product Name: Loctite(R) 567 Thread Sealant
PST(R) Pipe Sealant With Teflon(R)
Item No.: 56747
9. PHYSICAL AND CHEMICAL PROPERTIES
(continued)
Vapor Density: Not available
Evaporation Rate
(Ether = 1) Not available
10. STABILITY AND REACTIVITY
Stability: Stable
Hazardous Polymerization: Will not occur
Incompatibility: None
Conditions to Avoid: Not available
Hazardous Decomposition
Products (non-thermal): None
11. TOXICOLOGICAL INFORMATION
Oral LD50 greater than 10,000 mg/kg.
Estimated dermal LD50 greater than 2000 mg/kg.
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended methods of
disposal: Incinerate following EPA and local regulations.
EPA Hazardous Waste
Number NH - Not a RCRA Hazardous Waste Material
14. TRANSPORTATION INFORMATION
DOT (49 CFR 172)
Domestic Ground Transport
Proper Shipping Name: Unrestricted
Hazard Class or
Division: Unrestricted
Identification Number: None
Marine Pollutant: None
IATA
Proper Shipping Name: Unrestricted
Class or Division: Unrestricted
UN or ID Number: None
HENKEL LOCTITE CORPORATION
09/08/02
ROCKY HILL, CONNECTICUT 06067
EMERGENCY PHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 05
of 05
Product Name: Loctite(R) 567 Thread Sealant
PST(R) Pipe Sealant With Teflon(R)
Item No.: 56747
15. REGULATORY INFORMATION
CA Proposition 65: WARNING: This product contains a chemical known
to
the State of California to cause
cancer.
Epichlorohydrin
16. OTHER INFORMATION
Estimated NFPA(R) Code:
Health Hazard: 1
Fire Hazard: 1
Reactivity Hazard: 1
Specific Hazard: Does not apply
Estimated HMIS(R) Code:
Health Hazard: 1*
Flammability Hazard: 1
Reactivity Hazards: 1
Personal Protection: See Section 8.
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings
Assn.
Prepared By: Stephen Repetto
Title: Research Chemist - Health & Regulatory Affairs
Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT
06067
(24hr.) Phone: (860) 571-5100
Revision Date: January 27, 1999 Revision: 0034
application assistance . browse catalog . troubleshooting . equipment
datasheets . distributor locator .what's new . career opportunities
about loctite . contact loctite . literature . loctite world wide . search . home
copyright ?1997-2000 Loctite
|