Material Safety Data Sheet
Section I
Product Identification: EGS MORTAR & GROUT SYSTEM (part A)
100% EPOXY
==============================================================
Southern Grouts and Mortars, Inc.
1502 SW 2nd Place
Pompano Beach, Florida 33069
(954) 943-2288
==============================================================
Section II - Components Ingredient
Hazardous Components: Bisphenol A / Epichlorohydrin (CAS 25068-38-6)
(Based epoxy resin)
OSHA PEL: Limits has not been established.
ACGIH TLV: Limits has not been established.
=====================================================================
SECTION III - PHYSICAL DATA
Boiling Point : >500F
Vapor Pressure : 0.03 MM HG @ 77C
Vapor Density : N/A
Evaporation Rate : N/A
Solubility in Water : Neglible
Specific Gravity : 1.17
Melting Point : N/A
Appearance and odor : Very light yellow / Very viscous liquid.
======================================================================
Section IV - Fire and Explosion Data
Flash point : 480F PMCC
Flammable Limits : %Volume in air - Lower N/AV/ Upper N/AV
Extinguishable Media : Use water fog, foam, dry chemical or CO2
Special Fire Fighting Procedures: Heating above 300f in the presence of air, may
cause oxidative decomposition and/or polymerization.
Unusual Fire and Explosion Hazards: Fumes and vapors may be toxic. Do not breath
fumes. Use NIOSH approved respirator.
=====================================================================
Section V - Reactivity Data
Stability : Stable
Incompatibility : Strong oxidizing agents
Hazardous Decomposition or byproducts: Thermal decomposition may form carbon
monoxide.
Hazardous Polymerization : Aldehydes and acids
==================================================================
EGS Mortar & Grout System
Page 1
Section IV - Health Hazard Data
Primary Routes of Entry:
Inhalation: Not relevant due to low volatility. Skin: Moderately irritating. Ingestion: Low order
of acute toxicity.
Health Hazards
Acute: Moderately irritating to the eyes and skin.
Chronic: N/A
Carcinogenicity: N/A
NTP: N/A IARC Monographics: N/A OSHA Regulated: N/A
Signs and Symptoms of Exposure: N/A
Medical Conditions Aggravated by Exposure: None known.
Emergency and First Aid Procedure: Flush eyes with water. Flush exposed skin with
water. Remove victim to fresh air. Provided with oxygen if breathing is difficult
======================================================================
Section VII - Precautions for Safe Handling and Use
Released or Spilled: Soak up with absorbent clay or sand.
Waste Disposal Method: Scrape up and dispose as common waste according to local,
state and federal regulations.
======================================================================
Section VIII - Control Measures
Respiratory Protection: None required
Ventilation:
Local Exhaust: Yes Mechanical: No Special: No
Protective Gloves: Rubber gloves recommended
Eye Protection: Safety goggles or glasses
Other Protective Clothing: N/A
Work Hygienic Practices: Avoid contact with skin, eyes and clothing. Wash thoroughly
after handling.
==============================================================
Date: _________________
Disclaimer:
The information contained herein is based on data considered accurate. However, no
warranty is expressed or implied regarding the accuracy. Since the use of this information
and the conditions of use of the product are not within the control of Southern Grouts and
Mortars, Inc., it is the users obligation and responsibility to determine the condition of safe
use of the product. SGM Inc., assumes no responsibility for personal injury or property
damage.
EGS Mortar & Grout System
Page 2
Material Safety Data Sheet
Section I
Product Identification: EGS MORTAR & GROUT SYSTEM (part B)
100% EPOXY
================================================================
Southern Grouts and Mortars, Inc.
1502 SW 2nd Place
Pompano Beach, Florida 33069
(954) 943-2288
================================================================
Section II - Components Ingredient
Hazardous Components:
1) Tetraethylenepentamine, Talloil Fatty Acid Amino Amine
(CAS 68953-36-6) 90%
** No data available
2) Tetraethylenepentamine (CAS 112-57-2) 10%
Acute Oral LD 50 3.99 G/Kg (Rat)
Acute Dermal LD 50 0.66 G/Kg (Rabbit)
Acute Inhalation LD 50 300 Mg/M3 (Mouse)
3) Triethlenetetramine (CAS 112-24-3) 3%
Acute Oral LD 50 3.99 G/Kg (Rat)
Acute Dermal LD 50 0.66 G/Kg (Rabbit)
Acute Inhalation LD 50 300 Mg/M3 (Mouse)
======================================================================
SECTION III - PHYSICAL DATA
Boiling Point : >340F
Vapor Pressure : 1.0 @ 20 C
Vapor Density : N/A
Evaporation Rate : N/A
Solubility in Water : Partial
Specific Gravity : 0.94
Melting Point : N/A
Appearance and odor : Clear amber liquid with Amine odor.
======================================================================
Section IV - Fire and Explosion Data
Flash point : >200F Setaflash
Flammable Limits : %Volume in air - Lower 1.4 / Upper N/A
Extinguishable Media : Use water fog, foam, dry chemical or CO
Special Fire Fighting Procedures: N/A
Unusual Fire and Explosion Hazards: N/A
======================================================================
Section V - Reactivity Data
EGS Mortar & Grout System
Page 3
Stability : Stable
Incompatibility : Mineral Acids
Hazardous Decomposition or byproducts: Thermal decomposition may form carbon
monoxide, aldehydes and acids.
Hazardous Polymerization : Will not occur.
======================================================================
Section IV - Health Hazard Data
Primary Routes of Entry:
Inhalation: Yes Skin: Yes Ingestion: Yes
Health Hazards
Acute: Can dry the skin, Irritate eyes and upper respiratory system.
Chronic: Inhalation can cause inflammation of interior of nose, throat repertory tract,
headache and nausea.
Carcinogenicity: N/A
NTP: No IARC Monographics: No OSHA Regulated: No
Signs and Symptoms of Exposure: Shortness of breath, excessive inhalation may cause
headache, nausea and dizziness.
Medical Conditions Aggravated by Exposure: None known.
Emergency and First Aid Procedure: Flush eyes with water. Wash exposed skin with
water. Remove victim to fresh air. If accidentally ingested consult physician.
======================================================================
Section VII - Precautions for Safe Handling and Use
Released or Spilled: Scrape up and place in closed container.
Waste Disposal Method: Dispose as common waste according to local, state and
federal regulations.
======================================================================
Section VIII - Control Measures
Respiratory Protection: None required
Ventilation:
Local Exhaust: Yes Mechanical: N/A Special: N/A
Protective Gloves: Rubber gloves recommended
Eye Protection: Safety goggles or glasses
Other Protective Clothing: N/A
Work Hygienic Practices: Avoid contact with skin, eyes and clothing. Wash thoroughly
after handling.
======================================================================
Date: _________________
Disclaimer:
The information contained herein is based on data considered accurate. However, no
warranty is expressed or implied regarding the accuracy. Since the use of this information
and the conditions of use of the product are not within the control of Southern Grouts and
Mortars, Inc., it is the users obligation and responsibility to determine the condition of safe
use of the product. SGM Inc., assumes no responsibility for personal injury or property
damage.
EGS Mortar & Grout System
Page 4
Material Safety Data Sheet
Section I
Product Identification: EGS MORTAR & GROUT SYSTEM (part C)
100% EPOXY
==============================================================
Southern Grouts and Mortars, Inc.
1502 SW 2nd Place
Pompano Beach, Florida 33069
(954) 943-2288
==============================================================
Section II - Components Ingredient
Hazardous Components: Silica sand (CAS 14808-60-7)
OSHA PEL: 0.1 mg/m3 (Respirable dust) 0.3 mg/m3 (total dust)
ACGIH TLV: 0.1 mg/m3 (Respirable dust)
Nuisance Dust
OSHA PEL: 5 mg/m3 (Respirable dust) 15 mg/m3 (total dust)
ACGIH TLV: 10 mg/m3 TWA
==================================================================
SECTION III - PHYSICAL DATA
Boiling Point : N/A
Vapor Pressure : N/A
Vapor Density : N/A
Evaporation Rate : N/A
Solubility in Water : Miscible
Specific Gravity : 2.5
Melting Point : N/A
Appearance and odor : Gray, white or colored coarse textured powder; No
odor
==================================================================
Section IV - Fire and Explosion Data
Flash point : N/A
Flammable Limits : N/A
Extinguishable Media : N/A
Special Fire Fighting Procedures: Material will not burn unless preheated. Do not enter
confined fire space without full bunker gear, including positive pressure self-contained
breathing apparatus.
Unusual Fire and Explosion Hazards: Delayed lung damage can be experienced with
hours after exposure to combustion products. Nitrogen containing organic compounds
may be released upon combustion.
*Colors may contain one or more of the following pigments:
Yellow Iron Oxide (CAS 57124-00-1), Red Iron Oxide (CAS 1309-37-1), Black Iron Oxide (CAS 1317-61-
9), Chromium Oxide (CAS 1308-38-9), Carbon Black (CAS 1333-86-4), Barium Sulfate (CAS 7727-43-
7), Titanium Dioxide (CAS 13463-67-7), Calcium Carbonate (CAS 1317-65-3), Metal Oxide Silicate
(CAS 12713-03-03-0), Magnesium Aluminum Silicate (CAS 8031-18-3), Phthalocyanine Blue (CAS
471-34-1).
EGS Mortar & Grout System
Page 5
Section V - Reactivity Data
Stability : Stable
Incompatibility : Avoid heat, flame and contact with strong oxidizing
agents.
Hazardous Decomposition or byproducts: Nitrogen oxides, CO and unidentified organic
products may form combustion.
Hazardous Polymerization : Will not occur.
==================================================================
Section IV - Health Hazard Data
ACUTE
Eye contact: Corrosive and may cause severe damage.
Skin Corrosive and may cause sensitization. May be toxic if absorbed through the skin.
May cause reproductive effects.
Inhalation: Vapors/Mists may be corrosive to upper respiratory tract. Repeated exposure
can result in lung damage. May cause repiratory tract sensization.
Ingestion: Corrosive and may cause severe permanent damage to mouth, throat, and
stomach.
Signs and Symptoms of Exposure: Skin and/or eye irritation, shortness of breath,
wheezing and chronic cough.
Emergency and First Aid Procedure:
Eye contact - Flush eyes with water for fifteen (15) minutes and get medical attention.
Skin contact - Remove contaminated clothing. Wipe off from skin and flush with water.
Inhalation - Remove victim to fresh air. Provide oxygen if breathing is difficult. Get
medical attention.
Ingestion - Do not induce vomiting. Give one (1) glass of water, seek immediate medical
attention.
==================================================================
Section VII - Precautions for Safe Handling and Use
Released or Spilled:
Small spills - Soak up with sand or clay or absorbent materials and place in containers.
Large spills - Eliminate fire hazard, vacuum truck, soak up liquid with clay, sand or
absorbent material and place in sealed container.
Waste Disposal Method: Dispose according to local, state and federal regulations.
==================================================================
Section VIII - Control Measures
Respiratory Protection: Use NIOSH approved respirator n accord with 29 CFR 1910.34
Protective Clothing: Wear Chemical goggles, protective gloves, apron and overshoes.
Work Hygienic Practices: In accordance with good housekeeping.
==============================================================
Date: _________________
Disclaimer:
The information contained herein is based on data considered accurate. However, no warranty is
expressed or implied regarding the accuracy. Since the use of this information and the conditions
of use of the product are not within the control of Southern Grouts and Mortars, Inc., it is the users
obligation and responsibility to determine the condition of safe use of the product. SGM Inc.,
assumes no responsibility for personal injury or property damage.
EGS Mortar & Grout System
Page 6
|