SECTION IV -- REGULATORY STATUS
MATERIAL SAFETY DATA SHEET
A. CAL SAFE DRINKING WATER & TOXIC ENFORCEMENT ACT OF 1986
SECTION I -- PRODUCT INFORMATION NO. CHEMICAL NAME CAS. NO. CANCER/REPRO.TOX QUANTITY
SANCON PRIMER B
SANCON ENGINEERING, INC. PHONE NUMBER: (714) 891-2323
5841 ENGINEER DRIVE CHEMICAL TRANSPORTATION EMERGENCY:
HUNTINGTON BEACH, CA. 92649 (800) 726-2664
THIS PRODUCT MAY CONTAIN TRACES OF, OR OTHER PROP. 65 LISTED CHEMICALS
DATE OF PREPARATION: 9/7/04 SUPERSEDES: 5/24/95 AS IMPURITIES. HOWEVER, NONE ARE USED AS INGREDIENTS.
PROPER SHIPPING NAME .... : Corrosive Liquid, N.O.S.
CONTAINS ..... : MODIFIED AMINE MIXTURE
B. CERCLA -- 40 CFR 302.4
HAZARD CLASS...................... : 8
RELEASES EXCEEDING THE REPORTABLE QUANTITY (RQ) MUST BE REPORTED TO THE
UN NUMBER ........................... : UN1760
NATIONAL RESPONSE CENTER. (800)424-8802
PACKAGING GROUP.............. : III
HAZARD LABEL(S) ................. : Corrosive RQ = 100lbs. (UNLISTED HAZARDOUS WASTE - CHARACTERISTIC OF CORROSIVITY)
HMIS CODES: RATINGS:
HEALTH..................... = 3 0 = MINIMAL 3 = SERIOUS
C. OSHA -- 29 CFR 302.4
FLAMMABILITY ......... = 1 1 = SLIGHT 4 = SEVERE
ACCORDING TO OSHA CRITERIA THE FOLLOWING COMPONENT(S) ARE HAZARDOUS:
REACTIVITY.............. = 0 2 = MODERATE
1 MODIFIED AMINE MIXTURE N.A. < 100%
PERSONAL PROTECTION RATING TO BE SUPPLIED BY USER DEPENDING ON
USE CONDITIONS. 2 BENZYL ALCOHOL 100-51-6 < 30%
Ph PHENOL 108-95-2 < 10 %
SECTION II -- PRODUCT/COMPOSITION
THE PRECISE COMPOSITION OF THIS PRODUCT IS PRIVILEGED INFORMATION. A MORE
COMPLETE DISCLOSURE CAN BE PROVIDED TO A HEALTH, SAFETY, OR REGULATORY
PROFESSIONAL IF REQUIRED.
NO. COMPONENT CAS. NO. PERCENT
D. RCRA -- 40 CFR 261.33
1 MODIFIED AMINE MIXTURE N.A. < 100%
PHENOL (CAS 108-95-2) PRESENT @ < 10% IS A RCRA U188 WASTE.
2 BENZYL ALCOHOL 100-51-6 < 30%
Ph PHENOL 108-95-2 < 10 %
E. SARA TITLE III -- 52 CFR 13378, 52 CFR 21152
NO. RQ(lbs.) TPQ(lbs.) SEC.313 313 CAT. 311/312
(?) (?) (?) (?) (?)
1 NONE NOT LISTED NOT LISTED NONE H1,H2
SECTION III -- HAZARD STATUS
NO. CANCER REPRO-TOX TARGET ORGANS ACGIH/TLV OSHA/PEL 2 N.A. N.A. NO YES H1
N.A.mg/M3 N.A.mg/M3
1 NO NO LIVER, KIDNEYS, CNS
Ph 1,000 # 500# YES NONE H1,P3
2 NO NO UNKNOWN N.A. mg/M3 N.A. mg/M3
OTHER SARA SUBSTANCE(S) IF PRESENT ARE ALL BELOW THE DE MINIMUS
19 mg/M3
Ph NO NO POISON 5 ppm
CONCENTRATION(S).
? = REPORTABLE QUANTITY OF EXTREMELY HAZARDOUS SUBSTANCE, SEC. 302
? = THRESHOLD PLANNING QUANTITY, EXTREMELY HAZARDOUS SUBSTANCE, SEC. 302
? = TOXIC CHEMICAL, SEC. 313 (INDIVIDUAL CHEMICAL LISTED)
? = TOXIC RELEASE INVENTORY FORM CATEGORY SEC. 313 (40 CFR 372.65 C)
? = HAZARD CATEGORY FOR SARA SEC. 311/312 REPORTING
H1 = IMMED. (ACUTE) HEALTH HAZARD H2 = DELAYED (CHRONIC) HEALTH HAZARD
P3 = FIRE HAZARD P4 = SUDDEN PRESSURE RELEASE HAZARD P5 = REACTIVE HAZ.
1 2
SECTION VIII -- REACTIVITY DATA
F. TSCA -- 44 CFR 59764
? STABILITY: STABLE UNDER NORMAL STORAGE CONDITIONS. UNSTABLE AT
ALL COMPONENTS LISTED.
ELEVATED TEMPERATURES.
?br>
G. VOC -- SCAQMD RULES INCOMPATIBILITY: STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
? HAZARDOUS DECOMPOSITION PRODUCTS: OXIDES OF CARBON AND NITROGEN AND
NO. CHEMICAL QUANTITY VP mm HG gms./l. @ 20篊
OTHER UNKNOWN ORGANIC COMPOUNDS.
NIL
SECTION IX -- SPILL OR LEAK PROCEDURES
? IF MATERIAL IS SPILLED: AVOID CONTACT WITH MATERIAL. PERSONS NOT WEARING
NOTE: THIS PRODUCT DOES NOT CONTAIN SOLVENTS, BUT MAY CONTAIN
PROPER PROTECTIVE EQUIPMENT (SEE BELOW) SHOULD BE EXCLUDED FROM THE
INGREDIENTS WITH VP'S LOW ENOUGH TO BE EMITTED IF HEATED ALONE.
AREA UNTIL CLEAN UP IS COMPLETE. DIKE AREA TO PREVENT SPILL SPREADING
WHEN 2 PART RESINS AND HARDENERS ARE PROPERLY MIXED TOGETHER
AND SCOOP UP EXCESS TO RECOVERY CONTAINERS. ABSORB REMNANT ON
THESE INGREDIENTS REACT TOGETHER AND ARE CONSUMED WITHOUT
NONCOMBUSTIBLE MATERIAL SUCH AS CLAY AND SHOVEL INTO CONTAINERS FOR
SIGNIFICANT ATMOSPHERIC EMISSIONS.
DISPOSAL.
?br>
SECTION V -- PHYSICAL DATA WASTE DISPOSAL METHOD: DISPOSE OF WASTE IN ACCORDANCE WITH FEDERAL,
STATE, AND LOCAL REGULATIONS.
PHYSICAL STATE ......: LIQUID
SECTION X -- SPECIAL PROTECTION INFORMATION
COLOR........................: AMBER
?br>
SP. GR. .......................: 1.06 RESPIRATORY PROTECTION: NOT NORMALLY NECESSARY UNLESS THE MATERIAL IS
DENSITY.....................: 8.8 lbs./gal. BEING USED IN SUCH A WAY AS TO PRODUCE DUST, MIST, VAPOR, FUMES, OR
SMOKE, IN WHICH CASE NIOSH APPROVED RESPIRATORY PROTECTION SHOULD BE
SECTION VI -- FIRE AND EXPLOSION HAZARD DATA USED.
? VENTILATION: SHOULD BE SUFFICIENT TO CONTROL ANY DUST, MIST, VAPOR OR
FLASH POINT : 210篎 (FOR PRODUCT OR LOWEST FLASH POINT INGREDIENT)
FUMES PRODUCED BY PROCESSING OR HANDLING METHOD. BREATHING OF VAPOR
FLAMMABILITY CLASSIFICATION: COMBUSTIBLE CLASS (IIIB)
MUST BE AVOIDED.
EXTINGUISHING MEDIA: WATER FOG, DRY CHEMICAL, CARBON DIOXIDE, OR FOAM.
? HAND PROTECTION: IMPERVIOUS GLOVES, NEOPRENE OR RUBBER GLOVES.
NOTE: EITHER ATMOSPHERE-SUPPLY OR AIR-PURIFYING RESPIRATORS SHOULD BE
? EYE PROTECTION: SPLASH PROOF GOGGLES OR SAFETY GLASSES WITH SIDE
AVAILABLE FOR FIRE FIGHTERS (20 CFR 1910.134).
SHIELDS.
SECTION VII -- HEALTH HAZARD DATA ? OTHER PROTECTIVE EQUIPMENT: CLEAN, BODY COVERING CLOTHING AND
FOOTWEAR.
EFFECTS OF OVEREXPOSURE:
SECTION XI -- SPECIAL PRECAUTIONS
ACUTE:
? EYES: CAUSES SEVERE CONJUNCTIVAL IRRITATION, CORNEAL INJURY AND IRITIS. ? AVOID SKIN AND EYE CONTACT.
? SKIN: MAY CAUSE IRRITATION, BURNS, ULCERATION, OR SKIN SENSITIZATION. ? AVOID BREATHING VAPOR, MIST OR FUMES.
? INHALATION: VAPORS ARE IRRITATING AND MAY CAUSE TEARS, BURNING OF NOSE ? ENSURE THAT ALL CONTAINERS ARE PROPERLY LABELED TO PREVENT ACCIDENTAL
AND THROAT, COUGHING, WHEEZING, NAUSEA, AND VOMITING. INGESTION OR IMPROPER DISPOSAL.
? INGESTION: MODERATELY TOXIC, MAY CAUSE MOUTH AND THROAT BURNS, ? RESEAL PARTLY USED CONTAINERS.
ABDOMINAL PAIN, NAUSEA, VOMITING, WEAKNESS, THIRST, AND COMA.
? WASH WITH SOAP AND WATER BEFORE EATING, DRINKING OR USING TOILET
CHRONIC:
FACILITIES.
? AMINE VAPORS MAY CAUSE LIVER & KIDNEY INJURY. EYE, SKIN OR LUNG
? STORE UNDER COOL, DRY CONDITIONS AND AWAY FROM OPEN FLAMES AND HIGH
DISORDERS MAY DEVELOP OR BE AGGRAVATED BY AMINES.
TEMPERATURES.
EMERGENCY AND FIRST AID PROCEDURES:
? OBSERVE CONDITIONS OF GOOD INDUSTRIAL HYGIENE AND SAFE WORKING
? EYES: IMMEDIATELY FLUSH EYES WITH LARGE AMOUNTS OF WATER FOR 15
PRACTICE.
MINUTES. GET MEDICAL ATTENTION.
? We believe that the information contained herein is correct as of the date of this
SKIN: WASH AFFECTED AREA IMMEDIATELY WITH LARGE AMOUNTS OF SOAP AND
Material Safety Data Sheet. Since the use of this information and these opinions and
WATER. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE. CONTACT
A PHYSICIAN IF IRRITATION OCCURS. the conditions of use of this product are not within the control of SANCON, it is the
? INHALATION: REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS user's obligation to determine the conditions of safe use of the product.
DIFFICULT. GET MEDICAL ATTENTION. SANCON makes no warranty, expressed or implied regarding the accuracy of these
? INGESTION: DO NOT INDUCE VOMITING. GIVE LARGE QUANITIES OF WATER. CALL A data. SANCON assumes no responsibility for injury from the use of the product
PHYSICIAN IMMEDIATELY. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
described herein. Further, there are many federal, state, and local laws and
PERSON.
regulations governing chemical products and it is beyond the scope of this MSDS to
determine which of these apply and it is the responsibility of the user to determine
how these effect their use of the product.
3 4
|