MATERIAL SAFETY DATA SHEET
PAGE 1 OF 3
MANUFACTURER'S NAME / ADDRESS
SECTION 1: PRODUCT INFORMATION
CROSSFIELD PRODUCTS CORP. TRADE NAME: LT PRIMER, COMPONENT `B'
3000 E. HARCOURT ST. CHEMICAL FAMILY: POLYAMINE SOLUTION
RANCHO DOMINGUEZ, CA 90221 INTENDED USE: SPECIALTY FLOORING CURATIVE
(310) 886-9100 (8:00a.m. to 5:00p.m. pacific time) WHMIS CLASSIFICATION: 2A, 2B, E
140 VALLEY RD.
ROSELLE PARK, NJ 07204
(908) 245-2800 (8:00 a.m. to 5:00 p.m. eastern time)
(800) 424-9300 (CHEMTREC)
INITIAL ISSUE DATE: DECEMBER 13, 2002 REVISION DATE: JUNE 15, 2004 PREPARED BY: J.W. ESSIG
SECTION 2: HAZARDOUS INGREDIENTS
INGREDIENTS Wt. % CAS Number
BENZENE-1, 3-DIMETHANEAMINE, REACTION
PRODUCTS WITH PHENOL/FORMALDEHYDE 60-100 057214-10-5
BENZENE-1, 3-DIMETHANEAMINE 15-40 001477-55-0
PHENOL 7-13 000108-95-2
EXPOSURE LIMITS (ppm)
INGREDIENTS (CAS) OSHA ACGIH OTHER
TWA STEL TWA STEL
057214-10-5 NE NE NE NE
001477-55-0 NE NE NE NE
000108-95-2 5 NE 5 NE
LEGEND: (M) MAX. EXPOSURE LIMIT; (S) OCCUPATIONAL EXP. LIMIT; (R) SUPPLIERS REC. LIM (+) PERCUTANEOUS RISK
VOC: COMPONENT = 0 grm/Liter AS APPLIED: 0 grm/Liter (PART OF MULTI-COMPONENT SYSTEM)
SECTION 3: PHYSICAL DATA
BOILING POINT: 235OC (455OF) SPECIFIC GRAVITY: 1.12
MELTING POINT: 0OC (32OF)
VAPOR PRESSURE: ND
VAPOR DENSITY: ND (>Air) EVAPORATION RATE: ND
(AIR = 1) (BUTYL ACETATE = 1)
SOLUBILITY IN WATER: <1% Ph: NE (ALKALINE)
APPEARANCE AND ODOR: AMBER VISCOUS LIQUID. PHENOLIC ODOR.
ODOR THRESHOLD: NE
COEFFICIENT of WATER/OIL DISTRIBUTION: ND
SECTION 4: FIRE AND EXPLOSION HAZARD
FLASH POINT: 110OC (230OF) ?PENSKY-MARTIN CLOSED CUP
CONDITIONS OF FLAMMABILITY: NA
FLAMMABLE LIMITS: LEL: ND UEL: ND
OSHA CLASS: III B
AUTO IGNITION TEMP: ND
(NA= NOT APPLICABLE) (NE=NOT ESTABLISHED)
(ND= NO DATA)
LT PRIMER COMPONENT `B' PAGE 2 OF 3
SECTION 4: FIRE AND EXPLOSION HAZARD CON'T.
HAZARDOUS COMBUSTION PRODUCTS: CO; CO2; NH3. NITROGEN OXIDES CAN BE PRODUCED IF HEATED,
BURNED OR REACTED WITH INCOMPATIBLE MATERIALS.
SENSITIVITY TO IMPACT: ND
SENSITIVITY TO STATIC DISCHARGE: ND
EXTINGUISHNG MEDIA: IGNTION MAY GIVE RISE TO A CLASS B FIRE. IN CASE OF FIRE USE: WATER FOG,
CARBON DIOXIDE, DRY CHEMICAL, ALCOHOL FOAM.
SPECIAL FIRE FIGHTING PROCEDURES: NONE LIKELY WITH SMALL QUANTITIES. FOR LARGE
QUANTITES,
FIREFIGHTERS SHOULD WEAR BUTYL RUBBER BOOTS, GLOVES AND BODY SUIT. SELF-CONTAINED
BREATHING APPARATUS SHOULD BE WORN. WATER SPRAY IS USEFUL IN COOLING FIRE-EXPOSED
VESSELS AND IN DISPERSING VAPORS.
UNUSUAL FIRE AND EXPLOSIVE HAZARDS: MAY GENERATE TOXIC OR IRRITATING COMBUSTION
PRODUCTS. SUDDEN REACTION AND FIRE MAY RESULT IF PRODUCT IS MIXED WITH AN OXIDIZING
AGENT.
SECTION 5: HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: INGESTION, SKIN CONTACT, INHALATION.
HEALTH HAZARDS (ACUTE AND CHRONIC EXPOSURES)
EYES: ACUTE ?SEVERE IRRITANT. MAY CAUSE BURNS. VAPOR MAY CAUSE LACRIMATION AND
REVERSIBLE CORNEAL EDEMA.
CHRONIC ?CONJUNTIVITIS OR CORNEAL DAMAGE.
SKIN CONTACT: ACUTE ?UNDILUTED PRODUCT QUICKLY CAUSES IRRITATION. MAY CAUSE
CHEMICAL BURNS.
CHRONIC ?MAY CAUSE ALLERGIC REACTION/SENSITIZATION, DEFATTING OF
SKIN, RASH AND IRRITATION.
SKIN ABSORPTION: ACUTE -- NE
CHRONIC -- NE
INHALATION: ACUTE ?VAPORS MAY CAUSE DAMAGE TO CONTACTED TISSUE AND PRODUCE
SCARRING.
CHRONIC ?REPEATED AND/OR PROLONGED EXPOSURES CAN CAUSE TIGHTNESS
OF CHEST, SHORTNESS OF BREATH AND COUGH.
INGESTION: ACUTE ?MAY CAUSE IRRITATION AND BLEEDING OF THE GASTROINTESTINAL
TRACT.
CHRONIC ?SCARRING OF THE AFFECTED TISSUES MAY OCCUR.
CONDITIONS AGGRAVATED BY EXPOSURE: ASTHMA; BRONCHITIS, EMPHYSEMA; EYE DISEASE; SKIN
DISORDERS AND ALLERGIES.
CARCINOGENIC DATA: NTP: NONE OSHA: NONE IARC: NONE
TERATOGENICITY: NONE LISTED MUTAGENICITY: NONE LISTED
EMBRYOTOXICITY: NONE LISTED SYNERGISTIC MATERIAL: NONE LISTED
OVEREXPOSURE EFFECTS: LACRIMATION OF EYES, SKIN IRRITATION, DIZZINESS.
IRRITANCY: YES
SENSITIZER: YES
EMERGENCY AND FIRST AID PROCEDURES:
GENERAL: REMOVE PERSON FROM AFFECTED AREA AND MAKE COMFORTABLE. TREAT
SYMPTOMATICALLY.
EYES: FLUSH WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
SKIN: REMOVE PRODUCT AND FLUSH AFFECTED AREA WITH WATER FOR 15 MINUTES. IF
IRRITATION PERSISTS, GET MEDICAL ATTENTION. VICTIMS OF MAJOR SKIN AREA CONTACT SHOULD
REMAIN UNDER MEDICAL OBSERVATION FOR 24 HOURS.
INHALATION: MOVE TO FRESH AIR. GIVE ASSISTED RESPIRATION IF BREATHING HAS STOPPED
OR IS LABORED (CALL A PHYSICIAN).
INGESTION: GIVE 3 ?4 GLASSES OF WATER OR MILK IF PERSON CONSCIOUS. DO NOT INDUCE
VOMITING! OBTAIN MEDICAL CARE AND TREATMENT.
ACUTE TOXICITY EFFECTS: ORAL LD50 (rats): >2000mg/kg. NO DATA FOR INHALATION EFFECTS.
LT PRIMER COMPONENT `B' PAGE 3 OF 3
SECTION 6: REACTIVITY DATA
STABILITY: STABLE.
CONDITIONS TO AVOID: NOT APPLICABLE (MATERIAL IS STABLE).
INCOMPATIBILITY (MATERIAL TO AVOID): OXIDIZING AGENTS (PEROXIDES, NITRATES), ACIDS.
HAZARDOUS DECOMPOSITION PRODUCTS: NONE.
HAZARDOUS POLYMERIZATION (REACTIVITY): WILL NOT OCCUR.
SECTION 7: SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE OF MATERIAL IS RELEASED OR SPILLED: SHUT OFF SOURCES OF
IGNITION. COVER SPILLS WITH ABSORBENT. PLACE IN METAL CONTAINERS FOR RECOVERY OR
DISPOSAL. PREVENT ENTRY INTO SEWERS, STORM DRAINS, WATERWAYS.
WASTE DISPOSAL METHODS: INCINERATION IS PREFERRED. COMPLY WITH ALL FEDERAL, STATE AND
LOCAL REGULATIONS. CHEMICAL AND/OR BIOLOGICAL DEGRADATION IS FEASIBLE.
ECOLOGICAL INFORMATION: CAS 000108-95-2 PHENOL; BIODEGRADABILITY + 99.5% AT 7 DAYS.
ECOTOXICITY: ND
SECTION 8: SPECIAL PROTECTION INFORMATION
ENGINEERING CONTROLS: GENERAL AND LOCAL EXHAUST.
RESPIRATORY PROTECTION: NONE REQUIRED IN ADEQUATELY VENTILATED AREAS. APPROPRIATE
RESPIRATORY PROTECTION IS REQUIRED WHEN EXPOSURE TO AIRBORNE CONTAMINANTS MAY EXCEDE
ACCEPTABLE LIMITS. RESPIRATORS SHOULD BE SELECTED AND USED IN ACCORDANCE WITH OSHA,
SUBPART I (29 CFR 1910.134)
PROTECTIVE GLOVES: NITRILE RUBBER.
EYE PROTECTION: SPLASH-PROOF GOGGLES OR CHEMICAL SAFETY GLASSES.
OTHER PROTECTIVE EQUIPMENT: LONG SLEEVED SHIRTS AND TROUSERS. EMERGENCY SHOWERS
AND EYE WASH STATIONS SHOULD BE READILY ACCESSIBLE.
SECTION 9: HANDLING & STORAGE
GENERAL: KEEP AWAY FROM OXIDIZERS, HEAT OR FLAME. STORE AND HANDLE IN WELL VENTILATED
AREAS. KEEP COOL, DRY AND IN CLOSED CONTAINERS.
SECTION 10: SUPPLEMENTAL INFORMATION
HMIS RATING: HEALTH: 3 FLAMMABILITY: 1 REACTIVITY: 0
DOT PROPER SHIPPING NAME: Amines, liquid, corrosive, n.o.s. (BENZENE-1, 3-DIMETHANEAMINE (MXDA)) //
8 // UN2735 // PG II // NAERG Guide No. 153
HAZARD CLASS: CORROSIVE
UN NUMBER: UN 2735 PACKING GROUP: II
IMO SHIPPING DATA: : Amines, liquid, corrosive, n.o.s. (BENZENE-1, 3-DIMETHANEAMINE (MXDA)) : 8 :
UN2735 ; II ; IMDG PAGE 8103; F.P.110.0 C; PLACARDED CORROSIVE; HAZMAT STCC=4935601.
ICAO/IATA SHIPPING DATA Amines, liquid, corrosive, n.o.s. (BENZENE-1, 3-DIMETHANEAMINE (MXDA)) // 8 //
UN2735 // II // SHIPMENT PER 49 CFR 171.11 // NAERG Guide No. 153.
TSCA (TOXIC SUBSTANCE CONTROL ACT): ALL COMPONENTS ARE LISTED IN THE TSCA CHEMICAL
SUBSTANCE INVENTORY.
CERCLA (COMPREHENSIVE RESPONSE COMPENSATION and LIABILITY ACT): ND
SARA TITLE III
SECTION 312 HAZARD CLASS: IMMEDIATE HEALTH HAZARD.
SECTION 313 LISTED INGREDIENTS: 108-95-2 PHENOL AT NO MORE THAN 20%
CALIFORNIA PROPOSITION 65: The below list of compounds are known to the State of California to cause cancer, birth
defects or other reproductive harm: NONE
The information and recommendations contained herein are based upon data believed to be correct. However, no guarantee or
warranty of any kind, express or implied, is made with respect to the accuracy of the information contained herein. We accept
no responsibility and disclaim all liability for any harmful effects which may be caused by exposure to our products.
Customers/users of this product must comply with all applicable health and safety laws, regulations and orders.
|