Supplier:
Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106
Telephone: 1-87-Permatex
(877) 376-2839
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 137DA MOTOR MUSCLE CARB & CHOKE CLEANER 12OZ AE
Item No: 80079
Product Type: Aerosol cleaner
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
ACETONE 50-60 500 ppm TWA; 1188 mg/m3 TWA 1000 ppm TWA; 2400 mg/m3 TWA
67-64-1
TOLUENE 10-20 50 ppm TWA; 188 mg/m3 TWA 200 ppm TWA; C 300 ppm
108-88-3
PROPANE 10-20 simple asphyxiant; 2500 ppm TWA 1000 ppm TWA; 1800 mg/m3 TWA
74-98-6
XYLENE, MIXTURE OF ISOMERS 10-20 100 ppm TWA; 434 mg/m3 TWA 100 ppm TWA; 435 mg/m3 TWA
1330-20-7
ETHYL BENZENE 1-10 100 ppm TWA; 434 mg/m3 TWA 100 ppm TWA; 435 mg/m3 TWA
100-41-4
3. HAZARDS IDENTIFICATION
Aspiration hazard if swallowed. Deliberately concentrating and inhaling the vapor may be harmful or
Toxicity:
fatal. Exposure to vapors or mist may result in irritation of the respiratory tract. Long term exposure to
high concentrations of vapor may cause lung, liver or kidney damage. May cause eye and skin
irritation. Reports have associated repeated and prolonged overexposure to solvents with permanent
brain and nervous system damage (sometimes referred to as "solvent" or "painter's syndrome").
Symptoms include fatigue, concentration difficulties, anxiety, depression, rapid mood swings, and
short-term memory loss.
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Excessive overexposure may cause giddiness, dizziness, headache, nausea and in extreme cases,
Signs and Symptoms of Exposure:
unconsciousness and respiratory depression. May cause redness to eyes and irritation to nasal
passages.
ACGIH Carcinogens IARC:
Ingredients Percent NTP:
ACETONE 50-60 A4 - Not Classifiable as a
67-64-1 Human Carcinogen
TOLUENE 10-20 male rat-no evidence; A4 - Not Classifiable as a
108-88-3 female rat-no evidence Human Carcinogen
XYLENE, MIXTURE OF ISOMERS 10-20 male rat-no evidence; A4 - Not Classifiable as a Group 3: Vol. 71, pg 1189,
1330-20-7 female rat-no evidence; male Human Carcinogen 1999
mice-no evidence; female
mice-no evidence
ETHYL BENZENE 1-10 Group 2: Vol. 77, pg 227,
100-41-4 2000
Medical Conditions Recognized as Being Heart disease, respiratory disorders, liver and kidney diseases, amenia, rhythm disorders of the heart.
Preexisting eye, skin and respiratory disorders may be aggravated by overexposure to this product.
Aggravated by Exposure:
4. FIRST AID MEASURES
Page 1 of 4
Product Name: 137DA MOTOR MUSCLE CARB & CHOKE CLEANER 12OZ AE
Item No: 80079
If swallowed, do NOT induce vomiting. Give victim two glasses of water, Call a physician
Ingestion:
immediately. Never give anything by mouth to an unconscious person.
If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If
Inhalation:
breathing is difficult give oxygen. Get medical attention.
Remove contaminated clothing. Wash area with soap and water. If irritation persists, seek medical
Skin Contact:
attention.
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
<0 degrees F. Based on propellant
Flash Point (癋/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus. Keep containers cool. Use equipment or
Special Fire-Fighting Procedures:
shielding required to protect against bursting or venting of containers. Water spray may be ineffective
on flames but should be used to keep fire-exposed containers cool.
Oxides of carbon. Irritating vapors.
Hazardous Products Formed by Fire or
Thermal Decomposition:
Contents under pressure. Exposure to temperatures over 120 degrees F. may cause bursting or
Unusual Fire/Explosion Hazards:
venting. Use equipment or shielding to protect personnel from bursting containers.
1.0
Lower Explosive Limit:
12.8
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 120 degrees F.
Storage:
Exposure to high temperatures may cause container to burst.
Avoid contact with skin and eyes. Do not inhale vapors. Do not puncture or incinerate container. Do
Handling:
not use near heat, sparks or open flame. Extinguish all flames, pilot lights and heaters. Turn off
stoves, electric tools and appliances, and other sources of ignition. Intentionally concentrating and
inhaling the vapor may be harmful or fatal. Use only in a well ventilated area. Vapors may accumulate
readily and may ignite explosively. Wash hands before eating, drinking, chewing gum, using tobacco
or using the toilet.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses with side shields.
Eyes:
Not normally required when using an aerosol. Wear chemical resistant gloves if repeated skin contact
Skin:
occurs or causes irritation.
General; local exhaust ventilation as necessary to control any air contaminants to within their
Ventilation:
exposure limits during the use of this product.
An approved respirator (i.e. NIOSH, etc.) should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Clear liquid
Appearance:
SOLVENT ODOR
Odor:
<0 to 292 degrees F.
Boiling Point (癋):
Does not apply
pH:
Nil
Solubility in Water:
0.75
Specific Gravity:
45% by weight
VOC Content(Wt.%):
Not determined
Vapor Pressure:
Heavier than air
Vapor Density (Air=1):
Faster than ether
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR
Hazardous Polymerization:
Strong oxidizers.
Incompatabilities:
Page 2 of 4
Product Name: 137DA MOTOR MUSCLE CARB & CHOKE CLEANER 12OZ AE
Item No: 80079
Do not expose to heat or store at temperatures above 120 F.
Conditions to Avoid:
Oxides of carbon. Irritating vapors.
Hazardous Products Formed by Fire or
Thermal Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Disposal should be made in accordance with federal, state and local regulations. This container may
Recommended Method of Disposal:
be recycled in aerosol recycling centers. Before offering for recycling, empty the can by using the
product according to the label. If recycling is not available, wrap the container and discard in the
trash.
D001 as per 40CFR 261.21
US EPA Waste Number:
14. TRANSPORT INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
DOT Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
UN/ID Number: None
Marine Pollutant: None
IATA
Proper Shipping Name: Consumer Commodity
Class or Division: Class 9
UN/NA Number: ID 8000
IMDG
Proper Shipping: Aerosols, Limited Quantity
Hazard Class: Class 2.1
UN Number: UN 1950
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
XYLENE, ETHYL BENZENE, TOLUENE
CALIFORNIA PROP 65:
WARNING: This product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive
harm.
TSCA Inventory Status:
All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 4 , REACTIVITY 0
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 4, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Denise Boyd Health and Safety Manager
Company: Permatex. Inc. 10 Columbus Blvd. Hartford, CT 06106
Telephone Number: 1-87-Permatex (877) 376-2839
Page 3 of 4
Product Name: 137DA MOTOR MUSCLE CARB & CHOKE CLEANER 12OZ AE
Item No: 80079
06/19/2002
Revision Date:
0
Revision Number:
Page 4 of 4
|