Material Safety Data Sheet
Emergency Phone:(248)-373-8100 24-Hour CHEMTREC (800)-424-9300 CHEMTREC, D.C. Area (800)-483-7616
I. Chemical Product And Company Data
2
Health
PRODUCT: ISO-FLEX 885SG PART A
CHEMICALFAMILY: Polyurethane 1
Flammability
REVISION DATE: MARCH 2007 1
Reactivity
MANUFACTURER: LymTal International, Inc. H
Personal Protection
4150 S. Lapeer Rd. Orion, MI 48359
II. Composition / Information On Ingredients
This document is prepared pursuant to the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Where a proprietary ingredient is shown, the identity may be made available as provided in this standard.
All components of this product are included in the EPA Toxic Substances Control Act (TSCA) Chemical
Substance Inventory.
EXPOSURE LIMITS
HAZARDOUS INGREDIENTS CAS NO TLV STEL PEL CONTENT
Calcium Carbonate 1317-65-3 None None None <15.0%
Modified MDI Not Disclosed N/A N/A N/A 4.64%
Diphenylmethanediisocyanate 26447-40-5 N/A N/A N/A 1.55%
Petroleum Hydrocarbons 64742-95-6 100 ppm N/A N/A 5.04%
Proprietary Ingredients Balance
California Proposition 65 ingredients
None
Section 313 Supplier Notification
This product contains the following toxic chemicals subject to the reporting requirements of section 313 of
the Emergency Planning and Community Right to Know Act of 1986 (40CFR372)
1,2,4-Trimethylbenzene 95-63-6 25 ppm N/A 25 ppm 2.56%
Ethyl Benzene 100-41-4 100 ppm 125 ppm 100 ppm 0.04%
Xylene 1330-20-7 100 ppm 150 ppm 100 ppm 0.24%
Cumene 98-82-8 50 ppm N/A 50 ppm 0.12%
III. Hazards Identification
HMIS Hazard Rating No. 2
PRIMARY ROUTE OF ENTRY: Inhalation, dermal, eyes, ingestion
Symptoms of Exposure
Skin Contact: Frequent or prolonged contact may irritate and cause dermatitis, or aggravate and existing
condition.
Eyes: Contact can cause severe irritation, redness, tearing and blurred vision.
LymTal International, Inc. Iso-Flex 885SG Part A Page 1 of 4
Inhalation Vapors can be irritating to nose and mucous membranes. High exposures may result in
dizziness, headache anesthesia, drowsiness, unconsciousness and other central nervous
system effects.
Ingestion: Intake can cause gastrointestinal irritation, nausea, vomiting, diarrhea and headache.
IV. First Aid Measures
Inhalation Remove victim from exposure. If difficulty with breathing, administer oxygen and
seek medical assistance
Eyes Flush eyes with cold water for a minimum of 15 minutes, lifting lower and upper eye
lids throughout. Seek immediate medical attention.
Skin Immediately remove contaminated clothing. Wash thoroughly with soap and water. If
irritation persists seek medical attention. Wash contaminated clothing before reuse.
Ingestion Do not induce vomiting, get immediate medical attention, if vomiting occurs
spontaneously keep head below hips to prevent aspiration of liquids into lungs. Do
not give anything by mouth to an unconscious person
V. Fire Fighting Methods
HMIS Hazard Rating No. 1
Flash Point: > 68 oC (155oF ) Method: Pensky Martin C.C.
General Hazard: Decomposition and combustion products may be toxic.
Auto-Ignition Temp.: Not Available
Limits of Flammability LEL: Not Available UEL: Not Available
Extinguishing Media For small fires, use water spray, foam, CO2, or dry chemical. For large
fires, use water spray, fog, or alcohol foam.
Special Fire & Unusual Hazards Move containers from area if it can be done without risk. Cool fire-
exposed containers with water from the side. As in any fire, wear
NIOSH/MSHA approved, pressure demand self contained breathing
apparatus and full protective gear.
VI. Accidental Release Measures
Action To Take For Spills/ Leaks: Avoid contact with skin or eyes. Ventilate area, and eliminate all sources
of ignition. Wear appropriate protective gear, contain leak or spill, salvage, clean up residue with
absorbent material.
Waste Disposal Method: Handle disposal of waste material in a manner that complies with local, state,
province and federal regulation. Landfill if solidified, or incineration at agency approved waste-disposal
facilities.
VII. Handling And Storage
Average Shelf Life: Refer to Product Data Sheet
Special Instructions Store in cool, dry well ventilated areas keep away
from flames or sources of sparks.
VIII. Exposure Controls / Personal Protection
Ventilation: Ventilation is recommended. Air movement must be designed to insure turnover at all
locations in work area to avoid build up of heavy vapors.
Personal Protection Equipment: Do NOT wear contact lenses when working with this material. Use
chemical goggles/safety glasses with side shields and impervious gloves. Wear clothing with long sleeves
and pants. Wear respirator protection whenever airborne concentrations exceed TLV or TWA, use
NIOSH/OSHA approved respirators equipped with an organic vapor cartridge. Confined spaces, room, or
tanks are areas where concern for TLV's is especially important. Reference OSHA regulation CFR 29
LymTal International, Inc. Iso-Flex 885SG Part A Page 2 of 4
1910.134 for recommended respiratory protection.
IX. Physical And Chemical Properties
Boiling Point (oC): N/D Water/Oil Distribution N/A
Coefficient:
Percent Volatile: 8.0% ( 82 g/l ) Solubility in Water: Negligible
Freezing Point (oC): N/A Specific Gravity @20?C 1.02
Vapor Pressure @ 20o C N/A pH: N/A
Vapor Density >air Evaporation Rate: N/A
Odor Threshold: N/A Odor: Aromatic
Appearance: White paste
N/A = Not Available N/D=NOT Determined Ca. = Approximate
X. Stability And Reactivity
HMIS Hazard Rating No. 1
Stability Stable
Incompatibility: Strong acids, oxidizing agents.
Hazardous Decomposition Products Oxides of Carbon. Decomposition and Combustion products may be
toxic.
Conditions To Avoid Strong acids in bulk.
XI. Toxicity Information
HMIS Hazard Rating No. 2
PRIMARY ROUTE OF ENTRY: Inhalation, dermal
Effects Of Overexposure
Inhalation: Vapors can be irritating to nose and mucous membranes. High exposures
may result in dizziness, headache anesthesia, drowsiness, unconsciousness
and other central nervous system effects.
Eyes: Contact can cause severe irritation, redness, tearing and blurred vision.
Skin Contact: Frequent or prolonged contact may irritate and cause dermatitis, or aggravate
and existing condition.
Ingestion: Intake can cause gastrointestinal irritation, nausea, vomiting, diarrhea and
headache.
XII. Ecological Information
Marine Pollutant: NL
(NL = Not Listed; P = Moderate; PP = Severe; ND = Not Determined)
XIII. Disposal Considerations
Handle disposal of waste material in a manner that complies with all applicable local, state, provincial and
federal regulations.
LymTal International, Inc. Iso-Flex 885SG Part A Page 3 of 4
XIV. Transport Information
DOT SHIPPING INFORMATON
This product is not regulated by DOT in containers of 119 gallon capacity or less
XV. Regulatory Information
OSHA Hazard Communication Standard Hazardous
(29 CFR 1910.1200)
CERCLA/ Super fund (40 CFR 117,302) CASRN RQ
98-82-8 5000lbs
1330-20-7 1000lbs
100-41-4 100lbs
SARA Extremely Hazardous Substances N/A
(40 CFR 355)
SARA Hazard Categories (40 CFR 370) Health : Delayed
Physical: Fire
SARA Toxic Chemicals (40 CFR 372) CASRN %
98-82-8 0.255
1330-20-7 0.51
100-41-4 0.0085
95-63-6 5.44
Inventory Status The chemicals in this product are listed on the US
TSCA Chemical Substance Inventory and the
Canadian Domestic Substances List.
XVI. Other Information
THE INFORMATION HEREIN HAS BEEN COMPLIED FROM SOURCES BELIEVED TO BE RELIABLE
AND IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, LymTal INTERNATIONAL INC.
CANNOT GIVE ANY GUARANTEES REGARDING INFORMATION FROM OTHER SOURCES, AND
EXPRESSLY DOES NOT MAKE ANY WARRANTIES, NOR ASSUMES ANY LIABILITY, FOR ITS USE.
LymTal International, Inc. Iso-Flex 885SG Part A Page 4 of 4
Material Safety Data Sheet
Emergency Phone:(248)-373-8100 24-Hour CHEMTREC (800)-424-9300 CHEMTREC, D.C. Area (800)-483-7616
I. Chemical Product And Company Data
2
Health
PRODUCT: ISO-FLEX 885SG PART B
CHEMICALFAMILY: Polyamine 1
Flammability
REVISION DATE: MARCH 2007 1
Reactivity
MANUFACTURER: LymTal International, Inc. H
Personal Protection
4150 S. Lapeer Rd. Orion, MI 48359
II. Composition / Information On Ingredients
This document is prepared pursuant to the OSHA Hazard Communication Standard (29 CFR 1910.1200).
Where a proprietary ingredient is shown, the identity may be made available as provided in this standard.
All components of this product are included in the EPA Toxic Substances Control Act (TSCA) Chemical
Substance Inventory.
EXPOSURE LIMITS
HAZARDOUS INGREDIENTS CAS NO TLV STEL PEL CONTENT
Diethyltoluenediamine 68479-98-1 N/A N/A N/A 15.0 ?25.0%
Proprietary Ingredients Balance
California Proposition 65 ingredients
None
Section 313 Supplier Notification
This product contains the following toxic chemicals subject to the reporting requirements of section 313 of
the Emergency Planning and Community Right to Know Act of 1986 (40CFR372)
None
III. Hazards Identification
HMIS Hazard Rating No. 2
PRIMARY ROUTE OF ENTRY: Inhalation, dermal, eyes, ingestion
Symptoms of Exposure
Skin Contact: Frequent or prolonged contact may irritate and cause dermatitis, or aggravate and existing
condition.
Eyes: Contact can cause mild irritation.
Inhalation Vapors can be irritating to nose and mucous membranes. High exposures may result in
dizziness, headache anesthesia, drowsiness, unconsciousness and other central nervous
system effects.
Ingestion: Intake can cause gastrointestinal irritation, nausea, vomiting, diarrhea and headache.
LymTal International, Inc. Iso-Flex 885SG Part B Page 1 of 4
IV. First Aid Measures
Inhalation Remove victim from exposure. If difficulty with breathing, administer oxygen and
seek medical assistance
Eyes Flush eyes with cold water for a minimum of 15 minutes, lifting lower and upper eye
lids throughout. Seek immediate medical attention.
Skin Immediately remove contaminated clothing. Wash thoroughly with soap and water. If
irritation persists seek medical attention. Wash contaminated clothing before reuse.
Ingestion Do not induce vomiting, get immediate medical attention, if vomiting occurs
spontaneously keep head below hips to prevent aspiration of liquids into lungs. Do
not give anything by mouth to an unconscious person
V. Fire Fighting Methods
HMIS Hazard Rating No. 1
Flash Point: > 166 oC (330oF ) Method: Pensky Martin C.C.
General Hazard: Decomposition and combustion products may be toxic.
Auto-Ignition Temp.: Not Available
Limits of Flammability LEL: Not Available UEL: Not Available
Extinguishing Media For small fires, use water spray, foam, CO2, or dry chemical. For large
fires, use water spray, fog, or alcohol foam.
Special Fire & Unusual Hazards Move containers from area if it can be done without risk. Cool fire-
exposed containers with water from the side. As in any fire, wear
NIOSH/MSHA approved, pressure demand self contained breathing
apparatus and full protective gear.
VI. Accidental Release Measures
Action To Take For Spills/ Leaks: Avoid contact with skin or eyes. Ventilate area, and eliminate all sources
of ignition. Wear appropriate protective gear, contain leak or spill, salvage, clean up residue with
absorbent material.
Waste Disposal Method: Handle disposal of waste material in a manner that complies with local, state,
province and federal regulation. Landfill if solidified, or incineration at agency approved waste-disposal
facilities.
VII. Handling And Storage
Average Shelf Life: Refer to Product Data Sheet
Special Instructions Store in cool, dry well ventilated areas keep away
from flames or sources of sparks.
VIII. Exposure Controls / Personal Protection
Ventilation: Ventilation is recommended. Air movement must be designed to insure turnover at all
locations in work area to avoid build up of heavy vapors.
Personal Protection Equipment: Do NOT wear contact lenses when working with this material. Use
chemical goggles/safety glasses with side shields and impervious gloves. Wear clothing with long sleeves
and pants. Wear respirator protection whenever airborne concentrations exceed TLV or TWA, use
NIOSH/OSHA approved respirators equipped with an organic vapor cartridge. Confined spaces, room, or
tanks are areas where concern for TLV's is especially important. Reference OSHA regulation CFR 29
1910.134 for recommended respiratory protection.
IX. Physical And Chemical Properties
LymTal International, Inc. Iso-Flex 885SG Part B Page 2 of 4
Boiling Point (oC): N/D Water/Oil Distribution N/A
Coefficient:
Percent Volatile: 0% Solubility in Water: Ca 10%
Freezing Point (oC): N/A Specific Gravity @20?C 1.33
Vapor Pressure @ 20o C N/A pH: N/A
Vapor Density >air Evaporation Rate: N/A
Odor Threshold: N/A Odor: Mild
Appearance: pigmented liquid
N/A = Not Available N/D=NOT Determined Ca. = Approximate
X. Stability And Reactivity
HMIS Hazard Rating No. 1
Stability Stable
Incompatibility: Strong acids, oxidizing agents.
Hazardous Decomposition Products Oxides of Carbon. Decomposition and Combustion products may be
toxic.
Conditions To Avoid Strong acids in bulk.
XI. Toxicity Information
HMIS Hazard Rating No. 2
PRIMARY ROUTE OF ENTRY: Inhalation, dermal
Effects Of Overexposure
Inhalation: Vapors can be irritating to nose and mucous membranes. High exposures
may result in dizziness, headache anesthesia, drowsiness, unconsciousness
and other central nervous system effects.
Eyes: Contact can cause mild irritation.
Skin Contact: Frequent or prolonged contact may irritate and cause dermatitis, or aggravate
and existing condition.
Ingestion: Intake can cause gastrointestinal irritation, nausea, vomiting, diarrhea and
headache.
XII. Ecological Information
Marine Pollutant: NL
(NL = Not Listed; P = Moderate; PP = Severe; ND = Not Determined)
XIII. Disposal Considerations
Handle disposal of waste material in a manner that complies with all applicable local, state, provincial and
federal regulations.
XIV. Transport Information
DOT SHIPPING INFORMATON
This product is not regulated by DOT in containers of 119 gallon capacity or less
LymTal International, Inc. Iso-Flex 885SG Part B Page 3 of 4
XV. Regulatory Information
OSHA Hazard Communication Standard Hazardous
(29 CFR 1910.1200)
CERCLA/ Super fund (40 CFR 117,302) N/A
SARA Extremely Hazardous Substances N/A
(40 CFR 355)
SARA Hazard Categories (40 CFR 370) Health : Delayed
Physical: Fire
SARA Toxic Chemicals (40 CFR 372) None
Inventory Status The chemicals in this product are listed on the US
TSCA Chemical Substance Inventory and the
Canadian Domestic Substances List.
XVI. Other Information
THE INFORMATION HEREIN HAS BEEN COMPLIED FROM SOURCES BELIEVED TO BE RELIABLE
AND IS ACCURATE TO THE BEST OF OUR KNOWLEDGE. HOWEVER, LymTal INTERNATIONAL INC.
CANNOT GIVE ANY GUARANTEES REGARDING INFORMATION FROM OTHER SOURCES, AND
EXPRESSLY DOES NOT MAKE ANY WARRANTIES, NOR ASSUMES ANY LIABILITY, FOR ITS USE.
LymTal International, Inc. Iso-Flex 885SG Part B Page 4 of 4
|