Automotive Formula鈩? MSDS Page 1 of 3
AUTOMOTIVE FORMULA鈩?
MATERIAL SAFETY DATA SHEET
Date of Preparation: January 21, 1999. Emergency Telephone#: (561) 575-4200
Last Revision: July 21, 2006
SECTION I * PRODUCT IDENTIFICATION
Product Name: Automotive Formula鈩?
Product Number: AF4, AF4C, AF12
Product Class: AEROSOL
D.O.T. Shipping Class: Domestic 鈥? ORM-D Consumer Commodity
International (I.M.O.) - Aerosol, Flammable, (each not exceeding 1 L. capacity)
UN# 1950
SECTION II * HAZARDOUS INGREDIENTS
OCCUPATIONAL NFPA
EXPOSURE LIMITS HEALTH
INGREDIENT PERCENT RATING
TLV PEL
Dipropylene glycol methyl ether 60 - 70% N/E N/E 0
acetate
Terpene Solvent 5 - 15% 5mg/M3 100PPM 1
Terpene 1 - 3% N/E N/E 0
Nonionic Surfactant 5 - 10% N/E N/E 1
Propellant A - 70 Hydrocarbon Blend 20 - 25 % 1000PPM 1000PPM 1
45. PSIG @ 70掳F
N/E = Not Established
SECTION III * PHYSICAL DATA
Boiling Range: 400掳 F
Vapor Density: <1
Percentage Volatile by Weight: 99
1 Evaporation Rate: Slow
Weight per gallon: > 1.1 lbs.
Specific Gravity: 0.786 @ 60掳 F
Appearance: Clear Liquid
Odor: Slight ether like odor, citrus
Total VOC % 9%
SECTION IV * FIRE AND SAFETY EXPLOSION HAZARD DATA
Flammability Classification OSHA: Flammable
Shipping Classification D.O.T.: ORM-D
Flash Point: 150掳F
Flammable Levels in Air: Lower: N/A Upper: N/A
Extinguishing Media: Foam, Water Fog, CO2
11924 Forest Hill Boulevard, Suite 22-213, Wellington, FL 33414 * (561) 575-4200 * Fax (561) 828-2339
漏 1999, 2003, 2005 and 2006 DeBond Corporation all rights reserved
See copyright notice at the end of this document.
Automotive Formula鈩? MSDS Page 2 of 3
Unusual Fire and Explosion Hazards: Do not expose to heat or flame or store above 120掳F as
high internal pressure may cause leaking. This material may produce a floating fire hazard.
Special Fire Fighting Procedures: Do not direct a solid stream of water or foam into hot
burning spots may cause frothing and increase fire intensity.
SECTION V * HEALTH HAZARD DATA
PRIMARY ROUTE (S) OF ENTRY: Dermal, Inhalation
EMERGENCY AND FIRST AID PROCEDURE:
EYES: Flush eyes with large quantities of water to speed recovery. Face subject into wind or
forced air source such as fans or air conditioning outlet.
SKIN CONTACT: Wash affected area with soap and water. Use no creams or salves.
INHALATION: No danger exists for asphyxiation. Remove persons to fresh air.
INGESTION: Severe burning heartburn sensation may cause nausea. If swallowed do not induce
vomiting, call poison control, hospital emergency room or your physician immediately.
PHYSIOLOGICAL EFFECTS AND HEALTH INFORMATION
EYE EFFECTS: Tearing and redness may occur. This product has been found to have minor
non persistent eye irritation and to be non toxic.
SECTION VI * REACTIVITY DATA
Stable
STABILITY:
Will Not Occur
HAZARDOUS POLYMERIZATION:
Heat, open flames, electrical and static discharges.
CONDITIONS TO AVOID:
Strong Acids, Alkalies and Oxidizers.
INCOMPATIBILITY (Materials to Avoid):
SECTION VII * SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Ventilate area. Remove all possible sources of ignition. Avoid prolonged breathing of vapors.
Confine spill with inert absorbent. Wear protective equipment during cleanup.
WASTE DISPOSAL: Incinerate in an approved incinerator or dispose of in accordance with
Local, State and Federal Regulations.
SECTION VIII * SAFE HANDLING AND USE INFORMATION
RESPIRATORY PROTECTION: Use NIOSH/MSHA approved Chemical/Mechanical type
filter system to remove a combination or particles, gas and vapor. Use air line if necessary.
VENTILATION: Use adequate ventilation in volume and pattern to keep LEL and TLV's, in
Section II, below recommended level to produce explosion or fire. General mechanical
ventilation should comply with OSHA 1910.94.
PROTECTIVE GLOVES: Use rubber gloves.
EYE PROTECTION: Wear safety glasses or goggles with splash guards or side shields.
OTHER PROTECTIVE EQUIPMENT: Prevent prolonged skin contact to contaminated
clothing.
11924 Forest Hill Boulevard, Suite 22-213, Wellington, FL 33414 * (561) 575-4200 * Fax (561) 828-2339
漏 1999, 2003, 2005 and 2006 DeBond Corporation all rights reserved
See copyright notice at the end of this document.
Automotive Formula鈩? MSDS Page 3 of 3
SECTION IX * SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Store in a cool dry area
away from sources of ignition. When storing large quantities, store in building designed and
protected against fire.
DO NOT STORE IN DIRECT SUNLIGHT OR 120掳 F.
OTHER PRECAUTIONS: Do not take internally. If swallowed do not induce vomiting, call
poison control, hospital emergency room or your physician immediately.
SECTION X * WARRANTIES AND COPYRIGHT
Disclaimer of Warranties: The supplier disclaims all expressed or implied warranties of
merchantability or fitness for a specific use with respect to the product or the information
provided herein, except for conformation to contracted specifications. All information appearing
herein is based upon data obtained from manufacturers and/or recognized technical sources.
While the information is believed to be accurate, we make no representations as to its accuracy or
sufficiency. Conditions of use are beyond our control, and therefore users are responsible for
verifying the data under their own operating conditions to determine whether the product is
suitable for their particular purposes and they assume all risks of their use, handling, and disposal
of the product. Users also assume all risks in regard to the publication or use of, or reliance upon,
information contained herein. This information relates only to the product designated herein, and
does not relate to its use in combination with any other material or process.
Copyright: This document is 漏 1999, 2003, 2005 and 2006 and 2006 by DeBond Corporation all
rights reserved. This document may be copied, and distributed for use in handling the product
described herein. This document may not be altered or abridged in anyway.
11924 Forest Hill Boulevard, Suite 22-213, Wellington, FL 33414 * (561) 575-4200 * Fax (561) 828-2339
漏 1999, 2003, 2005 and 2006 DeBond Corporation all rights reserved
See copyright notice at the end of this document.
|