MATERIAL SAFETY DATA SHEET
SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION
Product Name: Carbon Monoxide, Catalyst Revision: 8 June, 2005
Product Part Number: 60507-00, -01, -02
50522-00
10009796
AVOX SYSTEMS INC. CHEMTREC Emergency Telephone Numbers:
225 Erie Street
Lancaster, NY 14086 United States: 800-424-9300
Telephone 716-683-5100 International: 703-527-3887 (collect)
SECTION 2 - INFORMATION ON INGREDIENTS
GENERATOR CAS # WGT. % EXPOSURE LIMITS
Manganese Dioxide 7439-96-5 greater than 50 鈥?03 OSHA PEL TWA (manganese
compounds)=5 mg/m3 ceiling limit
鈥?01 ACGIH TLV/TWA = 0.2 mg/m3
Copper Oxide 7440-50-8 greater than 15 鈥?03 OSHA PEL TWA copper fume (as
copper)=0.1 mg/m3
鈥?01 ACGIH TLV/TWA copper fume = 0.2
mg/m3
Listed as IARC Carcinogen: none
Listed as NTP Carcinogen: none
OSHA Carcinogen: none
SECTION 4 - FIRST AID MEASURES
Eye Contact: Flush eyes with a directed stream of water for at least 15 minutes. Forcibly hold eyelids apart to ensure
complete irrigation of all eyes and lid tissue. Obtain medical attention and bring this MSDS.
Skin Contact: Wash affected area with soap and water. Get medical attention if irritation occurs.
Inhalation: Avoid breathing excessive dust. Remove to fresh air at once.
Ingestion: Obtain medical attention and bring this MSDS.
Avox Systems Inc. Oxygen Generator, Chemical Hopcalite 8 June, 2005 page 1 of 3
SECTION 5 - FIRE FIGHTING MEASURES
Flash Point: not applicable Flash Point Method: not applicable
Flammable Limits: not applicable Autoignition Temperature: not applicable
SECTION 6 - ACCIDENTAL RELEASE MEASURES
Steps To Be Taken In Case Material Is Released Or Spilled: Clean up spill immediately. Product may be wetted down with water t
minimize dusting from a large spill. Sweep up and return to a clean
container. Seal and label container.
SECTION 7 - HANDLING AND STORAGE
Avoid contact with eyes, skin, or clothing. Do not breathe (dust). Wash thoroughly after handling.
Storage Temperature & Pressure: Store in a cool, dry area. Do not break seal of original packaging unnecessarily.
General: Do not store in wet or moist environments. Moisture will deactivate catalyst.
SECTION 8 - EXPOSURE CONTROL / PERSONAL PROTECTION
Personal Protection: Use appropriate engineering controls and personal protective equipment (PPE). Eye protection, gloves
and protective clothing are recommended. Approved air purifying respirator should be used.
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Granular, black, free-flowing powder (dry). pH (10% water solution): approximately 5.3
Vapor Pressure: not applicable Vapor Density: not applicable
Specific Gravity: varies, approx. 1.1 to 1.2 for 10 x 20 mesh Partial Decomposition: not applicable
Odor: none Solubility in Water: 350 鈥? 550 deg. C
Avox Systems Inc. Oxygen Generator, Chemical Hopcalite 8 June, 2005 page 2 of 3
SECTION 10 - STABILITY AND REACTIVITY
Conditions To Avoid: Manganese dioxide is an oxidizing agent; may cause combustible material to ignite more easily.
Incompatibility: Keep away from combustibles (materials that burn).
Hazardous Decomposition Products: None known
Hazardous Polymerization: None known
Stability: Stable
SECTION 11 - TOXICOLOGICAL PROPERTIES
No data available.
SECTION 12 - ECOLOGICAL INFORMATION
No data available.
SECTION 13 - DISPOSAL CONSIDERATIONS
These materials contain chemicals which are listed in 40 CFR 261, RQ 鈥? Section 102, EPCRA 313, and 40 CFR 401.
SECTION 14 - TRANSPORTATION INFORMATION
Not regulated by the U.S. Department of Transportation (DOT).
SECTION 15 - REGULATORY INFORMATION
See Section 13.
SECTION 16 - OTHER INFORMATION
The information contained herein is, to the best of our knowledge and belief, accurate. However, Scott Aviation assumes no
liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any
material is the sole responsibility of the user. All materials may present unknown hazards and should be used with caution.
Although certain hazards are described herein, we cannot guarantee that these are the only hazards which exist. It is the
responsibility of the user to comply with all applicable Federal, State, and Local laws and regulations.
Avox Systems Inc. Oxygen Generator, Chemical Hopcalite 8 June, 2005 page 3 of 3
|