MATERIAL SAFETY DATA SHEET
Page: 1
Date Printed: 3/13/2002
Product Code: TWP100-1
Product Name: TWP100 CLEAR (1 GAL)
GEMINI INDUSTRIES, INC., 2300 HOLLOWAY DRIVE, EL RENO, OK 73036
24-hour Emergency Phone: 800-510-8510
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
(SEE TOP OF PAGE)
2. COMPOSITION/INFORMATION ON INGREDIENTS
COMPONENT/EXPOSURE LIMITS CAS#
---------------------------------------------------------------------------
RULE 66 MINERAL SPIRITS 8052-41-3
STODDARD SOLVENT 100ppm TWA
NONANE 200ppm TWA
COBALT ALKONATE MIXTURE
MINERAL SPIRITS 500ppm TWA/OSHA, 100ppm TWA/ACGIH
MIXED MANGANESE CARBOXYLATES
ALIPHATIC PETROLEUM DISTILLATES 008052-41-3
OXOALUMINUM STEARATE 13419-15-3
ADDITIVE PROPRIETARY
FOLPET 133-07-3
XYLENE 1330-20-7
OSHA: 100 PPM PEL-TWA
NIOSH: 100 PPM PEL-TWA
ETHYLBENZENE 100-41-4
1,2,4-TRIMETHYLBENZENE 95-63-6
TOLUENE 108-88-3
3. HAZARDS IDENTIFICATION
FLAMMABLE IN A LIQUID STATE
VAPOR CAUSES EYE BURNS AND SKIN IRRITATION.
POTENTIAL HEALTH EFFECTS
MATERIAL SAFETY DATA SHEET
Page: 2
Date Printed: 3/13/2002
Product Code: TWP100-1
Product Name: TWP100 CLEAR (1 GAL)
GEMINI INDUSTRIES, INC., 2300 HOLLOWAY DRIVE, EL RENO, OK 73036
24-hour Emergency Phone: 800-510-8510
SKIN: Widespread contact with skin for several hours can cause harmful amounts of material to be absorbed.
INGESTION: Excessive inhalation of vapors can cause nasal and respiratory irritation, dizziness,
weakness, fatigue, nausea, headache, possible unconsciousness and even asphyxiation.
INHALATION: High vapor concentrations or prolonged breathing of lower concentrations may result in
damage to the liver, kidneys, lungs and blood forming organs.
4. FIRST AID MEASURES
EYES: Flush with luke warm water for a minimum of 15 minutes. Seek medical attention immediately.
SKIN: Remove contaminated clothing, wash area immediately with soap and water. See physician if irritation
persists.
INGESTION: Remove exposed individual to fresh air and assist breathing if necessary. Seek immediate
medical attention.
INHALATION: Rinse mouth immediately. Drink 1 or 2 glasses of water to dilute. Do NOT induce vomiting.
Contact physician or posion control center immediately.
5. FIRE FIGHTING MEASURES
FLAMMABLE CLASSIFICATION: CLASS 1B
LOWEST FLASH POINT: 105F METHOD: TCC
FLAMMABLE LIMITS:
LOWER FLAMMABLE LIMIT: .5
UPPER FLAMMABLE LIMIT: 6
EXTINGUISHING MEDIA: Alcohol Foam, CO2, Dry
UNUSUAL FIRE AND EXPLOSION HAZARDS
Keep containers tightly closed. Isolate from heat, electrical equipment, sparks and open flame. Closed
containers may explode when exposed to extreme heat. Do not apply to hot surfaces. Never use welding or
cutting torch on or near container (even empty) because product (even residue) may ignite explosively. Liq
and vapor states of this substance are dangerous fire hazards and moderate explosion hazards when exposed t
heat or flame.
FIREFIGHTING INSTRUCTIONS: Clear fire area of unprotected personnel. Do not enter confined space
without helmet, face shield, bunker coat, gloves, rubber boots, and a positive pressure NIOSH-approved self
contained breathing apparatus. A water stream can scatter flames. A spray of water may be used to cool clos
containers to prevent pressure buildup and possible autoignition or explosion when exposed to extreme heat.
water is used, fog nozzles are preferable.
6. ACCIDENTAL RELEASE MEASURES
Stay upwind and away from spill or leak unless wearing appropriate protective equipment. Stop and/or contain
if it may be done safely. Ventilate area of spill. Use non-sparking tools for clean up. Cover with inert
material to reduce fumes. Keep out of drains, sewer or waterways. If large spill occurs, alert spill respo
teams. Contact fire authorities. Notify local health and pollution control agencies.
7. HANDLING AND STORAGE
HANDLING: Bond and ground metal containers when transferring liquid. Avoid free fall of liquid in
excess of a few inches. Personnel should avoid inhalation of vapors. Personal contact with the product shou
avoided. Should contact be made, remove saturated clothing and flush affected skin areas with water. Contai
MATERIAL SAFETY DATA SHEET
Page: 3
Date Printed: 3/13/2002
Product Code: TWP100-1
Product Name: TWP100 CLEAR (1 GAL)
GEMINI INDUSTRIES, INC., 2300 HOLLOWAY DRIVE, EL RENO, OK 73036
24-hour Emergency Phone: 800-510-8510
of this material may be hazardous when emptied. Since emptied containers retain product residues (vapor, li
and/or solid), all hazard precautions given in this sheet must be observed.
Wet down all used wiping rags with water in a covered metal container to prevent spontaneous combustion.
STORAGE: Keep product containers cool, dry and away from sources of ignition. Use and store this product with
adequate ventilation. DO NOT SMOKE in or near storage areas
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
RESPIRATORY PROTECTION: Use local exhaust as required to control vapor concentrations. Avoid
prolonged or repeated breathing of vapors. If exposure exceeds TLV, use NIOSH-approved respirator to preven
overexposure.
SKIN PROTECTION: Required for prolonged or repeated contact. Wear resistant gloves such as natural rubber,
neoprene, buna N or nitrile. An apron should be worn to avoid skin contact.
EYE PROTECTION: Wear splashproof goggles and face shield if there is a likelihood of contact with eyes.
HYGENIC PRACTICES: Wash hands thoroughly before eating or using restroom. Remove contaminated clothing
immediately and do not wear again until it has been properly laundered.
9. PHYSICAL AND CHEMICAL PROPERTIES
BOILING POINT: 300-390F
MELTING POINT: N/A
VAPOR PRESSURE: N/A
VAPOR DENSITY: Heavier Than Air
SOLUBILITY IN WATER: N/A
SPECIFIC GRAVITY: .83
COATING VOC LB/GL: 4.61 lb/gl
COATING VOC GM/LTR: 553 g/l
MATERIAL VOC LB/GL: 4.61 lb/gl
MATERIAL VOC GM/LTR: 553 g/l
% VOLATILE BY VOLUME: 72.47%
EVAPORATION RATE: Faster than Butyl Acetate.
HAPS/GALLON: .1214
LBS HAPS/LBS SOLID: .0532
WEIGHT PER GALLON: 6.89 lb/gl
PH: N/A
ODOR: N/A
APPEARANCE: N/A
10. STABILITY AND REACTIVITY
CHEMICAL STABILITY: Stable Conditions to Avoid: high heat, sparks, flames.
INCOMPATIBILITYMaterials to Avoid: Strong oxidizing agents, strong alkalines, strong mineral acids.
HAZARDOUS DECOMPOSITION PRODUCTS: Oxidation may produce carbon and nitrogen oxides.
HAZARDOUS POLYMERIZATION: Will not occur.
11. TOXICOLOGICAL INFORMATION
CANCER INFORMATION: This product contains no reported carcinogens or suspected carcinogens.
TERATOLOGY (BIRTH DEFECT) INFORMATION: This product contains no reported or suspected teratogens.
REPRODUCTION INFORMATION:
12. ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION: Uncontrolled release of the product may result in contamination of air,
ground, waterways and/or sewers.
MATERIAL SAFETY DATA SHEET
Page: 4
Date Printed: 3/13/2002
Product Code: TWP100-1
Product Name: TWP100 CLEAR (1 GAL)
GEMINI INDUSTRIES, INC., 2300 HOLLOWAY DRIVE, EL RENO, OK 73036
24-hour Emergency Phone: 800-510-8510
13. DISPOSAL CONSIDERATIONS
Dispose in accordance with local, state and federal regulations.
14. TRANSPORT INFORMATION
DOT NUMBER: N/A
15. REGULATORY INFORMATION
HMIS HAZARD INDEX: 4=SEVERE, 3=SERIOUS, 2=MODERATE, 1=SLIGHT, 0=LEAST
HEATLH: 1
FLAMMABILITY: 0
REACTIVITY: 0
PERSONAL PROTECTION: I
SECTION 313: This product contains the following toxic chemicals subject to the reporting requirements
of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and 40 CFR 372(Chemicals l
below constitute the specific percentage of product by weight. Chemicals that do not have a listed percenta
comprise less than 1% of total product weight):
% BY WT
* FOLPET 133-07-3 2
* XYLENE 1330-20-7
* ETHYLBENZENE 100-41-4
* 1,2,4-TRIMETHYLBENZENE 95-63-6
* TOLUENE 108-88-3
16. OTHER INFORMATION:
THE INFORMATION CONTAINED HEREIN IS INFORMATION RECEIVED FROM OUR RAW MATERIAL SUPPLIERS AND OTHER SOURCES AN
BELIEVED TO BE RELIABLE. THIS DATA IS NOT TO BE TAKEN AS A WARRANTY OR REPRESENTATION FROM WHICH GEMINI
INDUSTRIES, INC. ASSUMES LEGAL RESPONSIBILITY.
|