PRODUCT SAFETY DATA SHEET
Sheet 1 of 3
Date:2010
FLUID FILM?AEROSOL (AS) Revision: 3
1.Identification of the Substance/Preparation & Supplier
Name of Manufacturer/Supplier: Eureka Chemical Company
Address & Phone No. 24 Hour Telephone
234 Lawrence Avenue Chemtrec (800) 424-9300
South San Francisco, CA 94080
USA Tel: (650)761-3536 Fax: (650)589-1943
Product Name: FLUID FILM?AEROSOL (AS)
Product Type: Liquid, Lubricant, Corrosion Inhibitor
HAZARD RATING
N 4 ?EXTREME HEALTH 0
F 3 ?HIGH FIRE 4
P 2 ?MODERATE REACTIVITY 0
A 1 ?SLIGHT SPECIAL
0 ?INSIGNIFICANT
2. Composition/Information on Ingredients
Exposure Limit
Hazardous components: CAS No. ACGIH / OSHA
Liquefied Petroleum Gas 68476-86-8 1000 ppm TLV / PEL
Petroleum Oil 64742-54-7 5 mg/m?TWA (Mist)
Product less propellant contains no solvents or known carcinogens.
3. Hazards Information
Aerosol - Contents under pressure, 70 + 5 PSIG
Eye Contact: May cause mild irritation.
Skin Contact: Prolonged contact could cause irritation.
Inhalation: Exposure in confined areas, without benefit of protective gear, may result in
light-headedness and irritation to respiratory tract.
Ingestion: No information available.
4. First Aid Measures
Eye Contact: Flush with plenty of clean water for at least 15 minutes. If irritation persists,
obtain medical attention.
Skin Contact: Wipe excess material from the skin with a cloth, followed by washing with soap
and water. A waterless skin cleanser is beneficial in removing the material from
the skin.
Inhalation: If respiratory symptoms develop, move victim away from source of exposure
and into fresh air. If symptoms persist, seek medical attention.
Ingestion: If symptoms develop, seek medical attention.
Product Name FLUID FILM?AEROSOL (AS) Sheet 2 of 3
Product Type: Liquid, Lubricant, Corrosion Inhibitor
5. Fire Fighting Measures
Flammability: Flammable.
Extinguishing
Media: Extinguish with dry chemical, CO2 or foam.
Special
Considerations: Aerosol - Contents under pressure, 70 + 5 PSIG. Fire fighters should enter
area wearing positive pressure respiratory protection.
6. Accidental Release Measures
Do not allow product to enter drains or water courses. Transfer bulk of material into another container.
Absorb remaining residue with proper absorbents such as earth or vermiculite. Sweep up and dispose of
as solid waste in accordance with applicable regulations.
7. Handling and Storage
0 - 490C
Storage Temperature:
Storage Precautions: No special requirements. Keep in closed containers.
Handling: Avoid contact with skin and eyes. Observe
good standards of industrial hygiene.
8. Exposure Controls/Personal Protection
Engineering Measures: Provide forced air ventilation in tanks and confined spaces.
Respiratory Protection: Use approved respirator with organic vapor cartridges in
tanks and confined spaces.
Eyes: Use chemical eye goggles in tanks and confined spaces.
Hand: Non-natural, non-butyl rubber gloves are recommended.
Skin: Use protective clothing. Remove contaminated clothing and
wash the affected area with soap and water.
Exposure Limits: Not determined.
9. Typical Physical and Chemical Properties
Appearance: Straw colored liquid. Odor: Mild piney odor (less propellant). Water Solubility: Not
soluble. pH Neat: 7.8 Specific Gravity (250C): 0.880 (less propellant). Freezing Point: Not
determined. Vapor Pressure: Not determined. Boiling Point: Not determined. Flash Point:
Propellant -910C (Closed cup). AS (less propellant) 2070C (COC). VOC: 27% VOC: 237 grams / liter
10. Stability and Reactivity
Stability: Stable under normal conditions. Hazardous polymerization will not occur.
Hazardous Decomposition Products: Combustion can produce a variety of compounds including oxides
of sulfur, oxides of carbon, water vapor and unidentified organic and inorganic compounds, some of which
may be toxic.
Conditions to Avoid: Exposed flames, high temperature sources and strong oxidizers.
Product Name: FLUID FILM?AEROSOL (AS) Sheet 3 of 3
Product Type: Liquid, Lubricant,Corrosion Inhibitor
11. Toxicological Information
LD50 (Animal/Oral): Product less propellant - Greater than 14 Grams/Kilogram
Health Effects:
Eyes: Minimally irritating.
Skin: Prolonged contact could cause skin irritation.
Inhalation: Excessive exposure due to lack of protective gear or proper ventilation could result in pulmo-
nary abnormalities.
Ingestion: Ingestion of this product is not regarded as a significant health hazard likely to arise in normal
use.
12. Ecological Information
No data available.
13. Disposal Recommendations
Product should be disposed of via authorized waste disposal contractors in accordance with all local and
national regulations.
14. Transportation Information
Mode Shipping Name Hazard Class Number
D.O.T. Consumer Commodity ORM-D UN1950
Ground
IMDG Aerosol 2 UN1950
Dangerous Goods in
Limited Quantities
15. Regulatory Information
Safety Phrases: Keep out of reach of children.
16. Other Information
Do not mix with other chemicals.
This data sheet does not constitute an assessment of the workplace risks as required under the
provisions of the Health & Safety at Work act and the Control of Substances Hazardous to Health
(COSHH).
Legal Disclaimer: The information supplied above is based upon the present state of our knowledge of
the product at the time of publication. It is given in good faith and no warranty is implied with respect to
the specification or quality of the product. The user must satisfy himself that the product is entirely
suitable for his purpose.
|