501 W. Algonquin Road
Lapmaster
Mt. Prospect, IL 60056 USA
International
1-224-659-7101
1-224-659-7103 (fax)
www.lapmaster.com
MATERIAL SAFETY DATA SHEET
Date: March 2007
Section #1: PRODUCT AND COMPANY IDENTIFICATION
Lapmaster International, LLC
501 W. Algonquin Road
Mt. Prospect, IL 60056
Telephone: (224) 659-7101 (Office Hours 8:00 a.m. to 5:30 p.m. CST)
Product Identification: Water Soluble Lapping Vehicle #0022
Product Name: Lapmaster #22 Water-Base Lapping Vehicle
Section #2: COMPOSITION INFORMATION ON INGREDIENTS
Ingredient Information: Alcohol, Water, Glycol, Surfactant
Component Percentage CAS OSHA ACGIH
Name % (by weight) Number PEL TWA
Polyalkaline Glycol <8% 9003-11-6 N/E N/E
Triethanolamine <15% 0102-71-6 5mg/m3 N/A
Monoethanolamine <10% 0141-43-5 3ppm 6ppm
Phosphate ester <8% Mixture N/E N/E
Triazine Biocide <5% 4719-04-4 N/E N/E
Octanoic Acid <5% 0124-07-2 N/E N/E
Section #3: HAZARDS INFORMATION
EMERGENCY OVERVIEW: Spill may cause slipping hazard
POTENTIAL HEALTH EFFECTS:
EYE: May cause mild irritation
SKIN: No normal use hazard, may cause irritation
INGESTION: No normal use hazard, may cause irritation
INHALATION: No hazard in normal use
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
None Known
Page 2, March 2007, Formula #22 Water-Base Lapping Vehicle
HEALTH HAZARDS (ACUTE AND CHRONIC):
None Known
SIGNS AND SYMPTOMS OF EXPOSURE:
None Known
CHRONIC / CARCINOGENICITY:
N/A
NTP: N/A
OSHA: N/A
IARC: N/A
Section #4: FIRST AID MEASURES
EYES: Remove Contacts ?Flush eyes w/water for 15 minutes ?Seek Medical Attention
SKIN: Wash with Soap and water for 15 minutes ?If irritated, Seek Medical Attention
INGESTION: Induce vomiting immediately ?Seek Medical Attention
INHALATION: Not probable, remove to fresh air
Section #5: FIRE FIGHTING MEASURES
FIRE FIGHTING: Non Flammable
EXTINGUISHING MEDIA: CO2, Dry Chemical, Foam
HAZARDOUS COMBUSTION PRODUCTS: N/A
CONDITIONS OF FLAMMABILITY: N/A
EXPLOSION DATA:
IMPACT SENSITIVITY: N/A
STATIC DISCHARGE: N/A
Section #6: ACCIDENTAL RELEASE MEASURES
GENERAL: Confine spill, use local and/or federal regulations in the collecting and
disposal of material.
Section #7: HANDLING AND STORAGE
HANDLING: Wear Safety Goggles, Use Protective Gloves
STORAGE: Store between 60 & 90 degrees F. Keep containers sealed until ready for use.
Section #8: EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: N/A
PERSONAL PROTECTION:
EYE/FACE: Wear Safety Goggles
SKIN: Use Gloves
RESPIRATORY: N/A
Page 3, March 2007, Formula #22 Water-Base Lapping Vehicle
Section #9: PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Viscous liquid colored to industry standards
ODOR AND APPEARANCE: No detectable odor, clear liquid
BOILING POINT: 212 Degrees F
MELTING POINT: N/A
pH @ 5%: 9.3
VAPOR PRESSURE (mmHg): <0.1mm Hg
SPECIFIC GRAVITY: 1.0314
WATER SOLUBILITY: Yes
% VOLATILES: N/A
VISCOSITY: <32 SUS
EVAPORATION RATE: Slower than Butyl Alcohol
COEFFICIENT WATER/OIL: N/A
Section #10: STABILITY AND REACTIVITY
STABILITY: Stable
STABILITY CONDITIONS TO AVOID: Extreme Heat or Cold
REACTIVITY: N/A
REACTIVITY CONDITIONS TO AVOID: N/A
Section #11: TOXICOLOGICAL INFORMATION
ACUTE HEALTH HAZARDS:
ACUTE ORAL: N/A
COMPONENTS: N/A
Section #12: ECOLOGICAL INFORMATION
GENERAL: Contains TEA and Glycol
Section #13: DISPOSAL INFORMATION
WASTE DISPOSAL: Comply with State and/or Federal regulations
RCRA HAZARDOUS WASTE: Not RCRA hazardous waste
Section #14: TRANSPORTATION INFORMATION
DOT HAZARD CLASS: Not Regulated
PROPER SHIPPING NAME: Not Regulated
IDENTIFICATION NUMBER: Not Regulated
TDGA: Not Listed
Section #15: REGULATORY INFORMATION
TSCA STATUS: N/A
WHMIS CLASSIFICATION: N/A
Page 4, March 2007, Formula #22 Water-Base Lapping Vehicle
Section #16: ADDITIONAL REGULATORY INFORMATION
U.S. Federal Regulations as follows:
]
OSHA: Hazardous by definition of Hazard Communication Standard (29 CFR 1910.1200)
CERCLA-SARA Hazard Category:
This product has been reviewed according to the EPA `Hazard Categories' promulgated
under Sections 311 and 312 of the Superfund Amendment and Reauthorization Act of 1986
(SARA Title III) and is considered, under applicable definitions, to meet the following
categories:
IMMEDIATE HEALTH HAZARD
SARA Section 313:
This product contains the following substances subject to the reporting
requirements of Section 313 of Title III of Superfund Amendments and
Reauthorization Act of 1986 and 40 CFR Part 372:
CHEMICAL NAME: CAS NUMBER WT/WT% is less than, no SARA Section 313
components exist in this product.
TOXIC SUBSTANCES CONTROL ACT: This product contains the following
chemical substances subject to the reporting requirements of TSCA 12(B) if
exported from the United States: None
Section #17: OTHER INFORMATION
HMIS RATINGS:
Health ? 1
Flammability ?0
Reactivity - 0
The information contained in this Material Safety Data Sheet (MSDS) document is believed
to be accurate and reliable. Because it is impossible to anticipate all conditions of use,
some additional safety precautions may be required. LAPMASTER INTERNATIONAL, LLC,
MAKES NO REPRESENTATION OR WARRANTY, EITHER EXPRESS OR IMPLIED, AS TO
THE MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. Each user should
read and understand the information provided and incorporate it into their individual site
safety programs as required by applicable hazard communication standards & regulations.
ABBREVIATIONS:
American Conference of Governmental Industrial Hygienists
ACGIG
Chemical Abstracts Service
CAS
Environmental Protection Agency
EPA
Permissible Exposure Limit
PEL
Personal Protective Equipment
PPE
Emergency Planning & Community Right-to-Know Act, Section 313
EPRCA 313
Canadian Workplace Hazardous Material Information System
WHIMIS
Occupational Health and Safety Administration
OSHA
|