Material Safety Data Sheet SECTION III - PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT: N/A SPECIFIC GRAVITY (H20=1): .8 COEFFICIENT OF WATER/OIL DIST: N/A
ODOR THRESHOLD: N/A VAPOR DENSITY: Heavier than air SOLUBILITY IN WATER: N/A
EVAPORATION RATE: Faster than n-Butyl Acetate APPEARANCE AND ODOR: Opaque Liquid / Solvent Based Odor
FREEZING POINT: N/A pH: N/A
TO: MSDS USERS
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Please find below the material safety data sheet as per your request. FLASH POINT: < 0?F (-18?C) METHOD USED: Estimated FLAMMABLE LIMITS IN AIR BY VOLUME - LOWER: 0.7% UPPER: 13.0%
EXTINGUISHING MEDIA: Foam, Alcohol Foam, CO2, Dry Chemical, Water Fog
The information presented in these forms is believed to be correct and sufficient to meet the requirements of OSHA Hazard Communication
SPECIAL FIRE FIGHTING PROCEDURES: Water spray may be used to cool containers exposed to heat or fire to prevent pressure build up. Self-
standard (29 CFR 1910.1200) concerning worker's right to know. In order for the information contained in the MSDS to be most helpful
contained breathing apparatus should be used if product is involved in fire.
we recommend that these forms be made available to all those who handle or may otherwise be exposed to the product.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Closed containers may rupture due to pressure build up from extreme heat or fire.
The following material safety data sheet covers the hazardous ingredients associated with more than one color aerosol product. As per FLAMMABILITY: Yes - Flammable aerosol under conditions of sparks, flame, or hot surfaces.
29 CFR 1900. 1200 paragraph (g); whenever the hazards associated with similar mixtures are the same, then one MSDS may be prepared SENSITIVITY TO IMPACT: Do not puncture SENSITIVITY TO STATIC DISCHARGE: Primarily vapors
to cover several products.
SECTION V - REACTIVITY DATA
This MSDS covers the following Aervoe aerosol products.
STABILITY: Stable CONDITIONS TO AVOID: High temperatures
Zynolyte Hi-Temp Extreme Heat Enamel INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizing agents
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: Carbon Monoxide and Carbon Dioxide
Z630 Aluminum Z642 Machinery Grey HAZARDOUS POLYMERIZATION: Will not occur
Z635 Black Z645 White
Z638 Almond SECTION VI - HEALTH HAZARD DATA
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: May cause dizziness or nausea.
SECTION I - MANUFACTURER IDENTIFICATION SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: SKIN - May cause irritation or burning sensation.
EYES - Primary irritation.
MANUFACTURER'S NAME: Aervoe Industries Inc. ADDRESS: 1198 Mark Circle, Gardnerville, NV 89410
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: May cause irritation or burning sensation.
INFORMATION PHONE: 775-782-0100 EMERGENCY PHONE: 1-800-424-9300
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: N/A
DATE REVISED: March 11, 2008 REASON REVISED: New
HEALTH HAZARDS (ACUTE AND CHRONIC): INHALATION - Anesthetic. Irritation of the respiratory tract, or nervous system depression (characterized
by headache, dizziness, nausea or possible unconsciousness). SKIN OR EYE CONTACT - Primary irritation. Prolonged or repeated contact to skin may
SECTION II - HAZARDOUS INGREDIENTS / SARA III INFORMATION cause dermatitis - exercise due care.
OCCUPATIONAL EXPOSURE LIMITS CARCINOGENICITY: None known NTP? No IARC MONOGRAPHS? No OSHA REGULATED? No
TERATOGENICITY: N/A MUTAGENICITY: N/A TOXICOLOGICALLY SYNERGISTIC PRODUCT: N/A
WEIGHT LD50 SPECIES LC50 SPECIES
HAZARDOUS MEDICAL CONDITION GENERALLY AGGRAVATED BY EXPOSURE: None known
OSHA PEL ACGIH TLV OTHER
COMPONENTS PERCENT & ROUTE & ROUTE EMERGENCY AND FIRST AID PROCEDURES: INHALATION - Remove from exposure and restore breathing, seek medical attention.
SPLASH - (SKIN) Wash affected area with soap and water, remove contaminated clothing, seek medical attention if any irritation persists.
Hydrocarbon Propellant 1000 ppm 1000 ppm N / AV N / AV
SPLASH - (EYES) Flush immediately with water for 15 minutes, seek medical attention if any irritation persists.
(CAS 68476-86-8) 15 - 40
Z630 & Z635 also Contain:
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Acetone 1000 ppm 500 ppm 5800 mg / kg (Rat-Oral) 21000 ppm / 8 hr (Rat-Inha)
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Remove all sources of ignition - Flames, sparks, static electricity &
(CAS 67-64-1) 10 - 20
electrical. Ventilate area, avoid run off into sewer by diking, and soak up with inert absorbent using non-sparking type tools.
*Xylene 100 ppm 100 ppm 4300 mg / kg (Rat-Oral) 6700 ppm / 4 hr (Rat-Inha)
WASTE DISPOSAL METHOD: Dispose of in accordance with local, state and federal regulations. Do not incinerate closed containers.
(CAS 1330-20-7) 10 - 20
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Do not store above 120?F (49?C). Do not store or use near heat, sparks or flame.
Aliphatic Petroleum Distillates N / AV 300 ppm N / AV N / AV
(CAS 64742-89-8) 10 - 20 OTHER PRECAUTIONS: Do not get in eyes. Do not breathe vapors. Avoid skin contact. Do not take internally. Smoking while using this product
Aliphatic Hydrocarbon 500 ppm 100 ppm N / AV N / AV must be strictly prohibited.
(CAS 8052-41-3) 5 - 10 SECTION VIII - CONTROL MEASURES
Z638 & Z642 also Contain: RESPIRATORY PROTECTION: Outdoors - Recommend an approved mechanical particulate filter to remove any airborne overspray. In restricted
*Methyl Isobutyl Ketone 100 ppm 50 ppm 75 ppm (STEL) 3.73 ml / kg (Rat-Oral) 2000 - 4000 ppm / 4 hr (Rat-Inha)
areas with poor ventilation, use a NIOSH approved Organic Cartridge Respirator. For concentrations above the exposure limit, use a positive air
(CAS 108-10-1) 25 - 35
supplied respirator.
Acetone 1000 ppm 500 ppm 5800 mg / kg (Rat-Oral) 21000 ppm / 8 hr (Rat-Inha)
VENTILATION: All application areas should be adequately ventilated in order to keep the items in SECTION II below their exposure limits.
(CAS 67-64-1) 5 - 10
PROTECTIVE GLOVES: Impervious gloves (natural rubber) are recommended to prevent skin contact.
Aliphatic Hydrocarbon 500 ppm 100 ppm N / AV N / AV
EYE PROTECTION: Safety glasses with side shields are recommended to prevent eye contact.
(CAS 8052-41-3) 3-7
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Impervious apron (natural rubber) is recommended to prevent skin contact. Eye wash fountain
Aliphatic Petroleum Distillates N / AV 300 ppm N / AV N / AV
and safety shower.
(CAS 64742-89-8) 1-5
WORK / HYGIENIC PRACTICES: Avoid prolonged or repeated contact. Do not breathe vapors. Wash contaminated clothing prior to reuse.
Z645 also Contains:
Acetone 1000 ppm 500 ppm 5800 mg / kg (Rat-Oral) 21000 ppm / 8 hr (Rat-Inha)
(CAS 67-64-1) 50 - 60 SECTION IX - DISCLAIMER
*Xylene 100 ppm 100 ppm 4300 mg / kg (Rat-Oral) 6700 ppm / 4 hr (Rat-Inha)
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE BUT IS NOT WARRANTED TO BE SO. NOTHING CONTAINED
(CAS 1330-20-7) 1-5
Z630MA
HEREIN CONSTITUTES A SPECIFICATION NOR IS IT INTENDED TO WARRANT SUITABILITY FOR THE INTENDED USE.
*Indicates toxic chemical(s) subject to the reporting requirements of section 313 of Title III and of 40 CFR 372.
NOTE: N/A applies to not available or not applicable