Material Safety Data Sheet
1. Chemical Product & Company Data
Product Name: Microban X-580 Institutional Spray Plus (California Version)
Manufacturer: Supplier:
ProRestore Products
4660 Elizabeth Street
Coraopolis, PA 15108
Telephone: 1-412-264-8340
2. Ingredients
Name CAS # UN # % by volume
2-propanol 67-63-0 10-30
Octylphenoxypolyethoxyethanol (nonionic surfactant) 9036-19-5 1-5
Active Ingredients:
.22
o-Phenylphenol 90-43-7
.70
Diisobutylphenoxyethoxy ethyl dimethyl benzyl ammonium chloride monohydrate 121-54-0
.33
N-octyl bicycloheptene dicarboximide 113-48-4
.20
Piperonyl butoxide technical 51-03-6
.10
Pyrethrins 51-92
3. Hazards Identifcation
Emergency Overview
Flammable liquid. Skin and eye irritant.
NOTE: Hazard information is based on the characteristics of the components of this mixture.
Ingestion - May cause abdominal discomfort, nausea, vomiting and diarrhea. Drowsiness or unconsciousness may occur.
Inhalation - Low concentration of the vapor may cause irritation of the respiratory tract with possible chest pain and coughing. High concentrations
may cause headache and drowsiness.
Eye Contact - Causes eye irritation and possible corneal injury.
Skin Contact - Prolonged contact may cause discomfort, redness, drying and defatting of the skin.
4. First Aid
Ingestion - If swallowed, promptly drink large quantities of water. Do not induce vomiting. Do not administer water to an unconscious person
Inhalation - Remove to fresh air. Administer artificial respiration if not breathing.
Eye Contact - Flush eyes with water for at least 15 minutes. If irritation persists, seek medical attention.
Skin Contact - Remove contaminated clothing. Wash skin with soap and water.
Microban X-580 Institutional Spray Plus (California Version)
5. Fire Fighting Measures
Flammability If yes, under which condi- Flammable liquid. Potential fire hazard when exposed to excessive
tions? heat, flame or other souces of ignition.
X
Yes No
Flashpoint: Upper flammable limit Lower flammable limit
77 癋 (25 癈) % by volume n. av. % by volume n. av.
Autoignition temperature Hazardous combustion products Explosion data
n. av. Carbon monoxide and/or carbon dioxide n. ap.
Means of extinction: Apply alcohol type or all purpose foam for large fires. Use dry chemical media or carbon dioxide
extinguishers for small fires. SCBA and bunker gear for fire department personnel
6. Accidental Release Measures
Eliminate all sources of ignition.
Wear personal protective equipment.
Do not allow spill to reach watercourse or sewers.
Contain spill with absorbent mats or booms or inert materials such as sand. Material should be readily available in the
workplace.
Collect and store waste materials in suitable containers for disposal i.e. metal drums.
7. Handling & Storage
Store in a cool dry place.
Keep containers closed and away from heat or flame.
Do not use or store near open flame.
8. Exposure Controls & Personal Protection
Personal Protective Equipment
Gloves Respirator Eye
Natural Rubber In processes where mists or vapors may be Goggles or full face respirator
generated, a NIOSH/MSHA jointly approved
respirator is advised in the absence of proper
environmental controls.
Footwear Clothing Other
n. ap. Coveralls or equivalent n. ap.
Exposure Guidelines
*none established for product*
OSHA ACGIH
TWA STEL TWA STEL
2-propanol 400 ppm 500 ppm 400 ppm 500 ppm
Microban X-580 Institutional Spray Plus (California Version)
9. Physical and Chemical Properties
Physical state Odor and appearance
Liquid Light yellow liquid, faint mint odor
Odor threshold (ppm) Vapor pressure (mm Hg) Vapor density (Air=1)
n. av. n. av. n. av.
Evaporation Boiling point Freezing point
(butyl acetate = 1) n.av. 215.6 癋 (102 癈) n. av.
pH Specific gravity Coefficient water/oil distribution
6.5 - 7.5 0.9 n. av.
Solubility in water Viscosity % Volatiles (by weight)
100% n. av. 25%
10. Stability and Reactivity
Chemical Stability If no, under
X which conditions?
Yes No
Incompatibility with other substances If yes, under Avoid strong oxidizing agents.
X which conditions?
Yes No
Reactivity, and under Stable under normal conditions.
what conditions?
Hazardous decomposition Carbon monoxide and/or carbon dioxide as combustion by-products.
products?
11. Toxicological Information
Route of Entry
X X X X
Skin Contact Skin Absorption Eye Contact Inhalation Ingestion
Oral LD50 (rat): >5,000 mg/kg
Dermal LD50 (rabbit): >5,000 mg/kg
Inhalation LC50 (rat): 2.88 mg/L
Eye Irritation (rabbit): Severe Irritant
Skin Irritation (rabbit): Slight Irritant
Dermal Sensitization (guinea pig): Not a dermal sensitizer
Carcinogenicity Mutagenicity Teratogenicity Reproductive toxicity
No No No No
Synergistic products Sensitization Neurotoxicity Target organs
No No No Eyes and Skin
12. Ecological Information
Octylphenoxypolyethoxyethanol (CAS # 9036-19-5) Aquatic effects 96 hr. Fathead Minnow LC50 8.9mg./L
Microban X-580 Institutional Spray Plus (California Version)
13. Disposal Considerations
Disposal for household/residential containers, 1 gallon or smaller container:
If empty: Do not reuse the container. Place in trash or offer for recycling if available.
If partly filled: Call your local solid waste agency or 1-800-CLEANUP for disposal instructions. Never place unused product down any indoor or outdoor
drain.
Disposal for nonresidential, nonhousehold containers, 5 gallon pails, 55 gallon drums:
Do not contaminate water, food or feed by storage or disposal.
Pesticide storage: Keep from freezing. Store in ventilated areas.
Pesticide disposal: Wastes resulting from the use of this product may be disposed of on site or at an approved waste disposal facility.
Container disposal: Triple rinse (or equivalent). Then offer for recycling or reconditioning, or puncture and dispose or in a sanitary landfill, or
incineration, or, of allowed by state and local authorities, by burning. If burned stay out of smoke.
14. Transport Information
Shipping Name: FLAMMABLE LIQUIDS, N.O.S. (Contains: 2-Propanol)
Hazard Class: 3 (Packing Group III)
UN Identification #: UN1993
US Domestic shipments up to 5 liters (1.3 gallons) per bottle
Consumer Commodity ORM-D for ground shipments, quarts and gallons only.
Consumer Commodity ORM-D-AIR for air shipments, quarts and gallons only.
15. Regulatory Information
This material safety data sheet has been prepared in accordance with the requirements of the OSHA Hazard Communication Standard (29 CFR
1910.1200) and the Hazardous Products Act (Can.) and the Controlled Products Regulations (Can.) This product has been classified in accordance
with the hazard criteria of the CPR (Can.) and the MSDS contains all the information required by the CPR (Can.).
Federal Level Regulations: This is an EPA FIFRA registered pesticide (EPA Registration No. 70385-3). This material can only be used commercially in
the EPA registered application(s) noted on the product label.
This product is classed as a flammable liquid and as a skin and eye irritant - 29 CFR 1910.1200 and Controlled Products Regulations (Can.)
WHMIS classification B2 D2B
This product is not subject to the reporting requirement of Section 313 of Title III of Superfund Amendments and Reauthorization Act (SARA) 1986 and
40 CFR part 372.
California Proposition 65:
Warning! This product contains chemical(s) known to the state of California to be Carcinogenic.
Weight% Components CAS No.
.22% o-Phenylphenol 90-43-7
Carcinogenic Effects
For Component: o-Phenylphenol
Ortho-phenylphenol and Sodium ortho-phenylphenol were tested in accordance with the EPA Final Guidance for Carcinogenic Risk. OPP and Na-
OPP were classified as "Not Likely to be Carcinogenic to Humans" based on no evidence of carcinogenic effects at the defined dose range of 200
mg/kg/day. At doses greater than 200 mg/kg/day, OPP and Na-OPP were classified as "Likely to be Carcinogenic to Humans" based on the presence
of urinary bladder tumors in rats and the presence of liver tumors in mice.
Carcinogenicty:
No Carcinogenic substances as defined by IARC, NTP and/or OSHA.
Microban X-580 Institutional Spray Plus (California Version)
16. Other Information
HMIS (U.S.A.) National Fire Protection
Association (U.S.A.)
Fire Hazard
Health Hazard 1
3
Health Reactivity
Fire Hazard 3
0
1
Reactivity 0
Personal Protection c Specific Hazard
This product is a disinfectant, insecticide and deodorant.
For chemical emergency during transportation call INFOTRAC (US) 1-800-535-5053 (INT'L) 1-352-323-3500
Prepared by: ProRestore Products, Coraopolis, PA / Cliff Zlotnik Phone No: 1-412-264-8340 Date: October 22, 2009
Abbreviations:
n. av. = not available n. ap. = not applicable ppm = parts per million
mm Hg = millimeters of Mercury PMCC = Pensky Martens Closed Cup TCC = Tagliabue Closed Cup
COC = Cleveland Open Cup TWA = Time Weighted Average STEL = Short Term Exposure Limit
LD = Lethal Dose LC = Lethal Concentration
This information is furnished without warranty, expressed or implied except that it is accurate to the best knowledge of ProRestore Products. The data and information on this sheet relates only to the specific material designated herein. ProRestore
Products assumes no legal responsibility for use or reliance upon this data.
GENERAL METHOD OF APPLICATION
PRECAUTIONARY STATEMENTS: Surfaces and objects must be cleaned of gross filth with suitable detergent before treatment. Spray surfaces and articles until thoroughly wet, use enough so
HAZARDS TO HUMANS AND DOMESTIC ANIMALS that treated surfaces and objects remain wet for at least 10 minutes. May be applied with a sponge to pre-cleaned, hard non-porous surfaces, allowing to dry for
WARNING: May be harmful if swallowed (inhaled or absorbed through the skin). Do not breathe vapors (dust or spray mist). Causes eye 10 minutes. Heavily treated spaces should be adequately ventilated and not re-entered for at least one hour after treatment.
(and skin) irritation. Do not get in eyes, on skin or on clothing.
AS A DISINFECTANT: In hospitals, operating rooms, emergency rooms, lobbies, hallways, patient rooms, wards, washrooms, scrub stations, mop
FIRST AID rooms, morgues, pathology labs, nurse's stations, laboratories, veterinary clinics and other health care facilities; in schools, hotels, motels,
IF IN EYES: Hold eye open and rinse slowly and gently with water for 15-20 minutes. Remove contact lenses, if present, after the first 5 restaurants, offices, homes and industrial buildings. For use on pre-cleaned hard non-porous surfaces such as glazed tiled porcelain, waste receptacles,
minutes, then continue rinsing. Call a poison control center or doctor for treatment advice. compactors, on, in and around rest room fixtures, toilet seats, locker rooms, telephones, door knobs, hospital apparatus and equipment, furniture and empty
IF ON SKIN OR CLOTHING: Take off contaminated clothing. Rinse skin immediately with plenty of water for 15-20 minutes. Call a poison containerized storage units.
control center or doctor for treatment advice.
TEST FABRIC OR SURFACE IN AN INCONSPICUOUS AREA
IF SWALLOWED: Call a poison control center or doctor immediately for treatment advice. Have person sip a glass of water if able to
swallow. Do not induce vomiting unless told to do so by a poison control center or doctor. Do not give anything by mouth to an AS A DEODORIZING AGENT
FOR COLOR FASTNESS OR ADVERSE REACTION.
unconscious person. For use as a deodorizing agent on carpeting found in schools, hotels, motels, homes, shelters, commercial, industrial and public buildings. Apply full strength
DISINFECTANT - INSECTICIDE - DEODORANT
IF INHALED: Move person to fresh air. If person is not breathing, call 911 or an ambulance, then give artificial respiration, preferably with sprayer until moist to carpet nap and rake or brush in. Allow to remain dry. For best results, carpets should be cleaned before application.
SHAKE WELL BEFORE AND DURING USE.
mouth-to-mouth if possible. Call a poison control center or doctor for further treatment advice.
Have the product container or label with you when calling a poison control center or doctor, or going for treatment. This product is not to be used as a terminal sterilant/high level disinfectant on any surface or instrument that (1) is introduced directly into the human body, either into or
FOR INSTITUTIONAL, HOUSEHOLD, FARM PREMISE USES AND ANIMAL QUARTERS in contact with the bloodstream or normally sterile areas of the body, or (2) contacts intact mucous membranes but which does not ordinarily penetrate the blood barrier
DIRECTIONS FOR USE or otherwise enter normally sterile areas of the body. This product may be used to preclean or decontaminate critical or semi-critical medical devices prior to sterilization
or high level disinfection.
It is a violation of Federal Law to use this product in a manner inconsistent with its labeling.
Microban Formula X-580 Institutional Spray Plus is a Disinfectant
Microban Formula X-580 Institutional Spray Plus should be applied with hand or power operated sprayers, automated metering systems or
and is also effective in controlling insects and odors.
gravity drip dispensers as an insecticide, and deodorizing agent, to previously cleaned surfaces. Spray areas until thoroughly moist, giving
TO DISINFECT FARM PREMISES, POULTRY HOUSES, ANIMAL PENS AND VEHICLES
special attention to cracks and crevices. Allow ten to twenty minutes for drying. It is not necessary to wipe the sprayed surface. Microban
Remove all animals and feed from premises, vehicles and enclosures. Remove all litter and manure from floors, walls and surfaces of barns, pens, stalls, chutes and
Formula X-580 Institutional Spray Plus should not stain those materials not stained by water. Remove pets, birds, and cover fish aquariums
ACTIVE INGREDIENTS other facilities and fixtures occupied or traversed by animals. Empty all troughs, racks and other feeding and watering appliances. Thoroughly clean all surfaces with
before spraying.
0.22%
o-Phenylphenol soap or detergent and rinse with water. Saturate all surfaces with the recommended disinfecting solution for a period of 10 minutes. Immerse all halters, ropes and other
Direct and repeat spraying of Ants, Roaches, Bedbugs, Silverfish and other harmful insects and in the cracks, crevices and hidden surfaces
Diisobutylphenoxyethoxy ethyl dimethyl types of equipment used in handling and restraining animals, as well as forks, shovels and scrapers used for removing litter and manure. Ventilate buildings, cars, boats
where they hide are necessary for control. Apply every 28 days or as often as needed.
0.70%
benzyl ammonium chloride monohydrate and other closed spaces. Do not house livestock or employ equipment until treatment has been absorbed, set or dried. Thoroughly scrub all treated feed racks, mangers,
To Kill Fleas and Ticks: Remove and destroy old animal bedding. Spray sleeping quarters of animals, floor areas, around baseboards, window
0.33%
N-octyl bicycloheptene dicarboximide troughs, automatic feeders, fountains and waterers, with soap or detergent and rinse with potable water before reuse. Apply Microban Formula X-580 Institutional Spray
and door frames, cracks, crevices and wherever the presence of these insects are suspected. Repeat as necessary. Thoroughly vacuum rugs and
0.20%
Piperonyl butoxide technical Plus full strength as directed in general method of application until thoroughly wet. Allow all surfaces to dry thoroughly, ventilate enclosed spaces adequately. Do not
carpets prior to application. Do not spray animals. Put fresh bedding in animal quarters after spray has dried. Treat animals with a registered flea and tick
0.10%
Pyrethrins house animals in treated areas until thoroughly dry and free from odors.
control product before allowing them to enter treated area.
98.45%
INERT INGREDIENTS
To Kill Sowbugs, Centipedes, Firebrats and Mites: Contact as many insects as possible with the spray. Also thoroughly spray all parts of the
TOTAL.....................................................................100%
room suspected of harboring these pests. Special attention should be paid to cracks, crevices, hidden surfaces under sinks, basement and
[ equivalent to (butylcarbityl) (6-propyl piperonyl) ether: 0.16% and related compounds: 0.04% ]
utility rooms, floors, doorjams, behind and under stoves and refrigerators.
PHYSICAL AND CHEMICAL HAZARDS
To Kill Flies, Mosquitoes, Gnats and Wasps: Close all doors and windows and spray upward into center of room with a slow sweeping motion.
Flammable. Keep away from heat and open flame.
Spray 5-10 seconds for average room. Keep room closed for 15 minutes after spraying. Ventilate room thoroughly before re-entry. Sweep up
E.P.A. Reg. No. 70385-3
STORAGE AND DISPOSAL (for containers larger than one gallon)
and destroy fallen insects. Before spraying cover exposed food and utensils.
E.P.A. EST. No. 70385-PA-001
To Kill Carpet Beetles, Lice and Moths: Clean all articles prior to application. Thoroughly spray top and undersides of rugs and carpets. Do not contaminate water, food or feed by storage and disposal.
Thoroughly spray the interiors of lockers, trunks, closets, cupboards and other storage areas. Spray directly on restroom fixtures. When treating PESTICIDE STORAGE: Keep from freezing. Store in ventilated areas.
upholstered furniture and mattresses thoroughly spray exterior, paying particular attention to seams and folds. Interior should be treated to
KEEP OUT OF REACH OF CHILDREN PESTICIDE DISPOSAL: Wastes resulting from the use of this product may be disposed of on site or at an approved waste disposal facility.
eliminate hidden infestations. CONTAINER DISPOSAL: Triple rinse (or equivalent). Then offer for recycling or reconditioning, or puncture and dispose of in a sanitary landfill, or
WARNING incineration, or, if allowed by state and local authorities, by burning. If burned, stay out of smoke.
Microban Formula X-580 Institutional Spray Plus when used as directed is effective in decontaminating the treated exposed surfaces of
bedding, mattresses, textiles, drapes, upholstered furniture, rugs, carpets and in storage areas to control insects and odors wherever they are
SEE PRECAUTIONS ON SIDE PANEL STORAGE AND DISPOSAL (for household/residential containers)
a problem.
?Pest Control Service ?Trash Chutes and Garbage Rooms ?Movie booths IF EMPTY: Do not reuse this container. Place in trash or offer for recycling if available.
Net Contents: 8 OZ. (0.237) Litres 1 PT. (0.473) Litres 1 QT. (0.946) Litres
?Odor Control Service ?Waste Compactors ?Bowling alleys IF PARTLY FILLED: Call your local solid waste agency or 1-800-CLEANUP for disposal instructions. Never place unused product down any indoor or
1 GAL. (3.785) Litres 5 GAL. (18.925) Litres 55 GAL. (208.175) Litres
?Carpet Cleaning Service ?Storage areas and Basements ?Exercise rooms outdoor drain.
Mfg by: PRORESTORE PRODUCTS, 4660 Elizabeth Street, Coraopolis, PA. 15108
?Disinfection Service ?Condensation collection and Drainage areas ?Veterinaries
SHAKE WELL BEFORE AND DURING USE
?Waste-Removal Service ?Refuse trucks ?Laundry receiving stations
U.S. Patent No. 3,458,629
?Shoes and boots ?Antique shops ?2008 PRORESTORE PRODUCTS
?Upholsterers shops
|