Material Safety Data Sheet
I. PRODUCT IDENTITY Ingestion: Low ingestion hazard in normal use. Low single dose
toxicity; LD50 (rat, rabbit, guinea pig) is greater than 5g/kg.
PRECISE?HOSPITAL FOAM CLEANER DISINFECTANT Inhalation: No significant effect expected from a single short-term
exposure. Considered low in toxicity.
Item Number Carcinogenicity: Not listed as carcinogen by NTP, OSHA or IARC.
40510 . . . . . . . . . . . . . . . . . . . . 6 oz Spray Can CALIFORNIA PROP 65: . . . WARNING . . . This product contains a
40513 . . . . . . . . . . . . . . . . . . . . 20 oz Spray Can chemical (o-Phenylphenol) known to the State of California to cause
cancer.
Manufactured by: Caltech Industries, Inc.
4520 E. Ashman Road, Midland, MI 48642-8911 VIII. FIRST AID
Eyes: If in eyes, hold eye open and rinse slowly and gently with water
II. KEY COMPONENTS for 15-20 minutes. Remove contact lenses, if present, after the first
Component CAS# Percent five minutes, then continue rinsing eyes. Seek medical attention if
irritation persists.
Methanol* 67-56-1 <3.0
Skin: No first aid should be needed.
o-Phenylphenol 90-43-7 <1.0
Ingestion: Not likely to be ingested.
*Exposure Limits - OSHA PEL 200 ppm and ACGIH TLV 200 ppm
Inhalation: If inhalation causes effects, remove to fresh air. If not
III. PHYSICAL DATA breathing, give artificial respiration. If breathing is difficult, give
oxygen. Consult medical personnel.
Boiling Point. . . . . . . . . . . . . . Approximately 64癈
Vapor Pressure. . . . . . . . . . . . 19.0 mmHg at 20癈
IX. SPECIAL HANDLING INFORMATION
Vapor Density . . . . . . . . . . . . . (air=1): Not applicable
Appearance. . . . . . . . . . . . . . . White foam which yields pale yellow
Ventilation: Good room ventilation usually adequate for most
liquid upon foam break
operations.
Solubility in Water . . . . . . . . Soluble
Respiratory Protection: A respiratory protection program that
Specific Gravity . . . . . . . . . . . 1.010-1.020 (25?25癈)
meets OSHA's 29 CFR 1910.134 or ANSI Z88.2 requirements must be
pH . . . . . . . . . . . . . . . . . . . . . . . 10.1-10.3
followed whenever workplace conditions warrant respirator use.
Odor . . . . . . . . . . . . . . . . . . . . . Floral
Protective Clothing: No precautions other than clean body-
IV. FIRE & EXPLOSION HAZARD DATA covering clothing should be needed.
Eye Protection: Use safety glasses or equivalent protection to avoid
NFPA Hazard Rating: . . . . . . 2
eye contact.
Flash Point . . . . . . . . . . . . . . . 155癋 TCC for concentrate
Flame Extension. . . . . . . . . . . No flame extension on CSMA test
X. SPILL, LEAK & DISPOSAL PROCEDURES
Flammable Limits . . . . . . . . . LFL - No ignition on CSMA closed drum
test. UFL - No ignition on CSMA closed Action to take for spills/leaks: Eliminate all sources of ignition.
drum test.
Stop leak if without risk. Absorb spill with inert material (vermiculite,
Extinguishing Media . . . . . . . Water fog, carbon dioxide, and dry
earth, or sand). Dispose of saturated absorbent materials
chemical
appropriately since spontaneous heating may occur.
Special Fire Fighting Equipment & Hazards: Isobutane only
Disposal Method: Landfill in accordance with local, state, and
flammable portion. If flame is introduced immediately after foam is
federal regulations.
sprayed, foam will burn for 1 to 2 seconds. If flame is not present
immediately, isobutane dissipates and no burning occurs.
XI. SPECIAL PRECAUTIONS & ADDITIONAL
INFORMATION
V. REACTIVITY DATA
Precautions to be taken in handling and storage: Do not
NFPA Hazard Rating: 0
puncture, incinerate, store in heat or sun as container may burst
Stability: Stable
above 130癋. Avoid contact with food. Flammable. Do not use near
Incompatibility (Specific Materials to Avoid): Acid. Material is basic
fire, sparks, or flame. Do not spray in eyes. Contents under pressure.
and will neutralize in acid.
Keep out of reach of children. STORE AS LEVEL 1 AEROSOL (NFPA
Hazardous Decomposition Products: None known.
30B).
Hazardous Polymerization: Will not occur.
Emergency Phone 989.496.3110
VI. SPECIFIC HAZARDS
NFPA Hazard Rating: No NFPA Specific Hazard warnings are
required for this product.
VII. HEALTH HAZARD DATA
NFPA Hazard Rating: 0
Eye: May cause slight conjunctival irritation, iritis and transient
corneal injury.
Skin Contact: Essentially non-irritating.
0 = NONE
Fl
1 = SLIGHT
am
2 = MODERATE
m
ab
2 3 = HIGH
ilit
4 = EXTREME
y
th
l
ea
?br>
H
0 0
The information herein is given in good faith but no warranty, expressed or
ity
tiv
implied is made.
c
800.234.7700
ea
R
Caltech and PRECISE are registered trademarks of Caltech Industries, Inc.
Sp
e
caltechind.com
NFPA
MSDS safety information last revised 25Nov03
ci
fi c
|