Material Safety Data Sheet
The information presented in these forms is believed to be correct and sufficient to meet the requirements of OSHA Hazard Communication
standard (29 CFR 1910.1200) concerning worker's right to know. In order for the information contained in the MSDS to be most helpful
we recommend that these forms be made available to all those who handle or may otherwise be exposed to the product.
This MSDS covers the following Aervoe aerosol product.
PRODUCT NAME: 884 INSECT REPELLENT PRODUCT CODE: 884A HMIS CODES: H F R P
141
SECTION I - MANUFACTURER/DISTRIBUTOR IDENTIFICATION
MANUFACTURER'S/DISTRIBUTORS NAME: Aervoe Industries Inc. ADDRESS: 1198 Mark Circle, Gardnerville, NV 89410
INFORMATION PHONE: 775-782-0100 EMERGENCY PHONE: 1-800-424-9300
DATE REVISED: 11-02-04 REASON REVISED: Updated
SECTION II - HAZARDOUS INGREDIENTS / SARA III INFORMATION
OCCUPATIONAL EXPOSURE LIMITS
HAZARDOUS LC50 SPECIES
ACGIH
WEIGHT OSHA
COMPONENTS & ROUTE
TLV
PERCENT PEL
DEET (N,N Diethyl-m-toluamide) 25 None None N/A
(CAS 134-62-3)
MGK?264 (N-Octyl Bicycloheptene Dicarboximide) 5 None None N/A
(CAS 113-48-4)
*MGK?Repellent 326 (Di-n-Propyl Isocinchomeronate) 2.5 None None N/A
(CAS 136-45-8)
*Isopropyl Alcohol 37.5 400 ppm 980 mg/m3 400 ppm 983 mg/m3
(CAS 67-63-0)
Liquefied Petroleum Gas 20-25 1000 ppm 1000 ppm
(CAS 68476-86-8)
Di-methyl Ketone 1-5 1000 ppm 2400 mg/m3 500 ppm 1188 mg/m3
(CAS 67-64-1)
SECTION III - PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT: N/A SPECIFIC GRAVITY (H20=1): .889 (concentrate only) VAPOR DENSITY: Heavier
SOLUBILITY IN WATER: Insoluble EVAPORATION RATE: N/A FREEZING POINT: N/A pH: N/A
APPEARANCE AND ODOR: Clear colorless liquid. Odor of Isopropanol and Diethyltoluamide.
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLAMMABLE CLASS: This aerosol is classified as EXTREMELY FLAMMABLE by the flame extension test method described in 16 CFR 1500.45.
EXTINGUISHING MEDIA: Foam, carbon dioxide or dry chemical.
HAZARDOUS COMBUSTION PRODUCTS: Under fire conditions this product will support combustion and may decompose to give off toxic gases such as
carbon monoxide, carbon dioxide and nitrogen oxides.
EXPLOSION HAZARDS: Contents under pressure. Exposure to temperatures above 130癋 / 54.4癈 can cause bursting.
FIRE FIGHTING PROCEDURES: Treat as an oil fire. Use a full-faced self-contained breathing apparatus along with full protective gear. Keep nearby
containers and equipment cool with a water stream.
SECTION V - REACTIVITY DATA
STABILITY: Stable HAZARDOUS POLYMERIZATION: No
CONDITIONS TO AVOID: Not compatible with strong acids or bases. Not compatible with strong oxidizers.
*Indicates toxic chemical(s) subject to the reporting requirements of section 313 of Title III and of 40 CFR 372.
NOTE: N / AP = Not Applicable N / AV = Not Available
SECTION VI - HEALTH HAZARD DATA
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Excessive inhalation can cause nasal and respiratory irritation, nausea and nervous
system disorders, such as fatigue, dizziness, headaches, lack of coordination, tremors and unconsciousness.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: SKIN - Can cause skin irritation. EYES - Causes substantial but
temporary eye injury.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: Can cause stomach irritation, resulting in nausea, cramps and vomiting. Can cause
nervous system disorders, such as fatigue, dizziness, headaches, lack of coordination, tremors and unconsciousness.
CHRONIC: Not established
EMERGENCY AND FIRST AID PROCEDURES: EMERGENCY OVERVIEW - IMMEDIATE CONCERNS: WARNING. EXTREMELY FLAMMABLE.
Contents under pressure. Harmful if swallowed. Do not get in eyes. Causes substantial but temporary eye injury. Avoid swallowing or inhaling vapors
and/or spray mists of this product. Take prudent precautions to avoid contact with skin, eyes, and clothing. Keep away from heat, sparks, and open
flame. Do not expose to temperatures above 130癋/ 54.4癈 as bursting may occur. DO NOT puncture or incinerate container.
FIRST AID: Inhalation: Remove affected person to fresh air. If breathing has stopped, administer artificial respiration and seek medical attention
immediately. Eye Contact: Remove contact lenses and immediately flush eyes with large amounts of water for at least 15 minutes, while periodically
lifting the upper and lower eyelids. If irritation persists, get medical attention. Skin Contact: Remove contaminated clothing and wash affected areas
with large amounts of soap and water. If irritation persists, get medical attention. Wash clothing separately before reuse. Ingestion: If swallowed call a
physician or poison control center and seek medical attention immediately. DO NOT induce vomiting. Never give anything by mouth to an unconscious
person. NOTES TO PHYSICIAN: Probable mucosal damage may contraindicate the use of gastric lavage.
TOXICOLOGICAL INFORMATION: ACUTE - ORAL LD50: 3.87 gm/kg EYE EFFECTS - Produced conjunctival irritation in 6/6 albino rabbit eyes. No
conjunctival irritation was observed in 2/6 animals by 4 days, in 5/6 animals by 7 days and 6/6 animals by 15 days. Corneal opacity was noted for 6/6
animals. No corneal opacity was observed for 2/6 animals by 72 hours, for 4/6 animals by 7 days, for 5/6 animals by 8 days and for 6/6 animals by 15
days. No iritis was observed during the study. SKIN EFFECTS - Produced a primary skin irritation index of 0.17 in albino rabbits.
SENSITIZATION - When applied dermally to albino guinea pigs, this product appears to be a dermal sensitizer. COMMENTS - None of the components
present in this material at concentrations equal to or greater than 0.1% are listed by IARC, NTP, OSHA or ACGIH as being carcinogens.
ECOTOXICOLOGICAL INFORMATION: Not Available.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: SMALL SPILL - Shut off ignition sources. Stop release, if possible without
risk. Dike or contain release, if possible, and if immediate response can prevent further damage or danger. Isolate and control access to the release
area. Take actions to reduce vapors. Absorb with appropriate absorbent. Clean spill area of residues and absorbent. LARGE SPILL - Shut off ignition
sources. Stop release, if possible without risk. Dike or contain release, if possible, and if immediate response can prevent further damage or danger.
Isolate and control access to the release area. Take actions to reduce vapors. Collect product into drums, etc. via drains, pumps, etc. Absorb with
appropriate absorbent. Clean spill area of residues and absorbent. GENERAL PROCEDURES - Contaminated absorbent and wash water should be
disposed of according to local state/provincial and federal/national regulations.
WASTE DISPOSAL METHOD: DISPOSAL METHOD: IF EMPTY - Do not reuse this container. Place in trash or offer for recycling if available. IF
PARTIALLY FILLED - Call your local solid waste agency or 1-800-CLEAN-UP for disposal instructions. Never place unused product down any indoor or
outdoor drain. EMPTY CONTAINER - Do not puncture or incinerate! RCRA/EPA WASTE INFORMATION - None of the ingredients in this product
appear on the RCRA lists (40 CFR 261.24, 40CFR 251.33) or CERCLA Hazardous Substance list (40 CFR Part 302 Table 302.4)
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: GENERAL PROCEDURES - Do not use near heat, open flame, or any other ignition
source. HANDLING - Contents under pressure; Do not puncture or incinerate. Do not use or store near heat, sparks, or open flame. Take prudent
precautions to avoid contact with skin, eyes, and clothing, and also to avoid breathing vapors and/ or spray mists of this product. Mechanical ventilation
should be used when handling this product in enclosed spaces. Wearing a respirator is not normally required when handling this product, but
recommended in the absence of proper ventilation. Do not contaminate water, feed or food by storage, handling, or disposal. Read and observe all
precautions and instructions on the label. STORAGE - Store in a cool, dry, well-ventilated, preferably locked storage area. Exposure to temperatures
above 130癋 / 54.4癈 may cause bursting. Store containers upright and closed. Keep away from heat, ignition sources, and strong oxidizers. Emptied
containers may retain product residues. KEEP OUT OF REACH OF CHILDREN. STORAGE TEMPERATURE: 4.44癈 (40癋) minimum to 37.8癈
(100癋) maximum.
SECTION VIII - CONTROL MEASURES
RESPIRATORY PROTECTION: Wearing a respirator is not normally required when handling this product. Use in well ventilated areas. Take prudent
precautions to avoid breathing vapors and/ or spray mists of this product
EYES AND FACE: Take prudent precautions to avoid contact with eyes.
SKIN: Take prudent precautions to avoid contact with skin and clothing.
SECTION IX - DISCLAIMER
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE BUT IS NOT WARRANTED TO BE SO. NOTHING CONTAINED
HEREIN CONSTITUTES A SPECIFICATION NOR IS IT INTENDED TO WARRANT SUITABILITY FOR THE INTENDED USE.
|