MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA'S HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
SECTION I ?PRODUCT IDENTIFICATION
Product Name: TRAFFIC LANE BLUE
Traffic Stripe Marking Paint (Handicap Blue) Formula: Proprietary HMIS Rating (Based on Aerosol Conc.):
Date Prepared: 04/28/04 0-Minimal 1- Slight 2- Moderate
Product Type: AEROSOL Emergency Phone: (800) 325-4869 3- Serious 4- Extreme
Supplier's Name: CONTINENTAL RESEARCH Information Phone: (800) 325-4869 HEALTH: 1 FIRE: 3 REACTIVITY: 3
Supplier's Address: P.O. Box 15204, ST. LOUIS, MO. 63110 Personal Protection: G
D.O.T. Hazard Class: CONSUMER COMMODITY ?ORM-D
SECTION II ?INGREDIENTS
CHEMICAL NAME CAS # %WT 313/Chem Skin Carcinogen PEL TWA/TLV
VM&P Naphtha 64742-89-8 10-20 NO NO NO 100 ppm 100 ppm
Propane 74-98-6 10-20 NO NO NO 1000 ppm 1000 ppm
*Toluene 108-88-3 10-20 YES NO NO 200 ppm 50 ppm
n-Butane 106-97-8 01-10 NO NO NO 800 ppm 800 ppm
3 3
Barium Sulfate, natural 7727-43-7 01-10 NO NO NO 5 mg/m 10 mg/m
Calcium Carbonate 1317-65-3 01-10 NO NO NO N/A N/A
3 3
Titanium Dioxide 13463-67-7 01-10 NO NO NO 5 mg/m 10 mg/m
PM Acetate 108-65-6 01-10 NO NO NO 250 ppm 275 ppm
Mineral Spirits 64742-47-8 01-10 NO NO NO 100 ppm 100 ppm
*Warning: This product contains a chemical known to the state of California to cause birth defects or other reproductive harm.
SECTION III ?PHYSICAL DATA
Boiling Point: -47?F
pH: N/A VOC % by weight: 52.5%
Solubility In Water: Miscible VOC Content: 0.53 kg/l
Appearance/Odor: Blue Coating / Solvent Odor Water Content: 19.5%
Vapor Pressure @ 68癋: 8300.0 hPa (6226 mm Hg) Solids Content: 24.9%
Vapor Density(Air=1): >1
Specific Gravity (H2O=1) @75癋: 0.77-0.90
SECTION IV ?FIRE AND EXPLOSION DATA
Flash Point (of Concentrate Only): -2癋 Flammability (as per USA Flame Projection Test): Extremely Flammable Spray
Extinguishing Media: CO2, sand, extinguishing powder or water spray
Special Fire Fighting Procedures: Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
Unusual Fire and Explosion Hazards: Exposure to temperature above 120?F may cause bursting.
SECTION V ?REACTIVITY DATA
Stability: Stable. Hazardous Polymerization: Will not occur.
Incompatibility: Avoid contact with strong oxidizing agents
Hazardous Decomposition Products: Carbon Dioxide, Carbon Monoxide
SECTION VI ?STORAGE AND HANDLING
KEEP OUT OF REACH OF CHILDREN.
For Industrial and Institutional use only.
Store in a cool, dry area away from heat or open flame.
Do not store at temperatures above 120?F. NFPA Code 30B Rating: Level 3 Aerosol.
SECTION VII ?HEALTH AND FIRST AID
PRIMARY ROUTES OF ENTRY & EFFECTS OF OVER EXPOSURE:
Eyes: Irritating effect.
Skin: Frequent or prolonged contact may cause irritation.
Inhalation: Inhalation of mist can cause irritation of nasal and respiratory passages. Abusive or excessive inhalation may cause irritation to the upper respiratory tract,
dizziness, nausea and other central nervous system effects.
Ingestion: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspiration of material into the lungs can cause chemical pneumonitis.
FIRST AID PROCEDURES:
Eyes: Flush with large amounts of cool running water for at least 15 minutes while holding upper and lower lids open. If irritation persists get medical attention immediately.
Skin: Wash with soap and water. If irritation persists seek medical attention.
Inhalation: Remove to fresh air. Seek medical attention immediately. If breathing stops give artificial respiration.
Ingestion: Do not induce vomiting. Seek medical attention immediately.
SECTION VIII ?SPECIAL PROTECTION DATA
Respiratory Protection: If ventilation is not adequate to reduce vapors below Threshold Limit Value (TLV) levels, use a NIOSH/MSHA approved air-purifying respirator
equipped with an organic vapor cartridge.
Ventilation: Provide local exhaust to keep TLV of Section II ingredients below acceptable limits.
Protective Gloves: Use chemical resistant gloves if hand contact will be made.
Eye Protection: Wear chemical proof goggles.
SECTION IX ?SPILL OR LEAK PROTECTION
STEPS TO BE TAKEN IN CASE OF SPILL OR LEAK: Allow propellant to evaporate. Maintain local exhaust and adequate ventilation. No smoking. Keep sparks, heat
sources and open flame far away from spill or leak. Cover with absorbent material and sweep up. Wash area to prevent slipping. Dispose of soaked absorbent material in
accordance with Federal, State and local laws.
WASTE DISPOSAL METHOD: Aerosol cans, when emptied and depressurized through normal use, pose no disposal hazard and should be recycled. Consult Federal, State
and local authorities for approved procedures.
N/A= NOT APPLICABLE ?N/E=NOT ESTABLISHED ?N/D=NOT DETERMINED ?<=LESS THAN ?>=MORE THAN
NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of the date of publication. It is not necessarily all inclusive nor fully adequate in every circumstance. The
suggestions should not be confused with, nor followed in violation of applicable laws, regulations, rules or insurance requirements. No warranty, express or implied, of merchantability, fitness, accuracy of
data, or the results to be obtained from the use thereof is made. The vendor assumes no responsibility for injury or damages resulting from the inappropriate use of this product.
Continental Research Corporation
Traffic Lane White
Manufacturer MSDS Number: CPA001-93250
SECTION 1 : Chemical Product and Company Identification
MSDS Name: Traffic Lane White
Manufacturer Name:Continental Research Corporation
Manufacturer MSDS Revision Date:
03/25/04
Chemical Formula: Proprietary
HMIS
Health Hazard: 1
Fire Hazard: 3
Reactivity: 3
Personal Protection: G
Distributor Name: Continental Research Corporation
Distributor Address:
PO BOX 15204
St. Louis, MO. 63110
Emergency Phone: 1-800-325-4869
Distributor Telephone: 1-800-325-4869
MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA'S HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
HMIS RATING (Based on Aerosol Conc.):
0 - Minimal
1 - Slight
2 - Moderate
3 - Serious
4 - Extreme
NFPA Code 30B Rating: Level 3 Aerosol.
SECTION 2 : Hazardous Ingredients/Identity Information
Chemical Name CAS# % Weight
VMPNaphtha 64742-89-8 10 - 20%
OSHA PEL TWA: 100 ppm
ACGIH TLV TWA: 100 ppm
Carcinogen Paragraph:
NO
SARA Section 313: No
SKIN: NO
Chemical Name CAS# % Weight
Propane 74-98-6 10 - 20%
1
OSHA PEL TWA: 1000 ppm
ACGIH TLV TWA: 1000 ppm
Carcinogen Paragraph:
NO
SARA Section 313: No
SKIN: NO
Chemical Name CAS# % Weight
Toluene 108-88-3 10 - 20%
OSHA PEL TWA: 200 ppm
ACGIH TLV TWA: 50 ppm
Carcinogen Paragraph:
NO
SARA Section 313: Yes
SKIN: NO
Chemical Name CAS# % Weight
n-Butane 106-97-8 05 - 10%
OSHA PEL TWA: 800 ppm
ACGIH TLV TWA: 800 ppm
Carcinogen Paragraph:
NO
SARA Section 313: No
SKIN: NO
Chemical Name CAS# % Weight
Titanium Dioxide 13463-67-7 05 - 10%
OSHA PEL TWA: Not Applicable
ACGIH TLV TWA: Not Applicable
Carcinogen Paragraph:
NO
SARA Section 313: No
SKIN: NO
Chemical Name CAS# % Weight
Barium Sulphate, natural 7727-43-7 05 - 10%
OSHA PEL TWA: Not Applicable
ACGIH TLV TWA: Not Applicable
Carcinogen Paragraph:
NO
SARA Section 313: No
SKIN: NO
Chemical Name CAS# % Weight
Calcium Carbonate 1317-65-3 05 - 10%
OSHA PEL TWA: Not Applicable
ACGIH TLV TWA: Not Applicable
Carcinogen Paragraph:
NO
2
SARA Section 313: No
SKIN: NO
Chemical Name CAS# % Weight
Isobutyl Acetate 110-19-0 05 - 10%
OSHA PEL TWA: 150 ppm
ACGIH TLV TWA: 150 ppm
Carcinogen Paragraph:
NO
SARA Section 313: No
SKIN: NO
Chemical Name CAS# % Weight
Mineral Spirits 64742-47-8 05 - 10%
OSHA PEL TWA: 100 ppm
ACGIH TLV TWA: 100 ppm
Carcinogen Paragraph:
NO
SARA Section 313: No
SKIN: NO
SECTION 3 : Physical And Chemical Characteristics
Physical State/Appearance:
Coating
Color:
White
Odor:
Solvent odor
pH:
Not Applicable
Vapor Pressure:
@ 68 deg F: 8300.0 hPa (6226 mmHg)
Vapor Density:
(Air = 1): > 1
Boiling Point:
-47 deg F
Solubility:
In Water: Miscible
Specific Gravity:
(H2O = 1) @ 75 deg F: 0.77 - 0.90
Volatile Organic Compound Content:
VOC % by weight: 52%
VOC Content: 0.52 kg/l
FlashPoint:
(Of Concentrate): -2 deg F
Water Content: 19%
Solids Content: 26%
SECTION 4 : Fire And Explosion Hazards
3
Fire:
Flammability (as per USA Flame Projection Test): Flammable Spray
Flash Point:
(Of Concentrate): -2 deg F
Extinguishing Media:
CO2, Sand, Dry Media or Water Spray
Fire Fighting Instructions:
Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
Unusual Fire Hazards:
Exposure to temperature above 120 deg F may cause bursting.
SECTION 5 : Health Hazards
Applies to All Ingredients:
Route of Exposure:
Eyes, Skin, Inhalation, Ingestion
Potential Health Effects:
Eye Contact:
Irritating effect.
Skin Contact:
Frequent or prolonged contact may cause irritation.
Inhalation:
Inhalation of mist can cause irritation of nasal and respiratory passages. Abusive or excessive inhalation may cause
irritation to the upper respiratory tract, dizziness, nausea and other central nervous system effects.
Ingestion:
Can cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspiration of material into the lungs can cause
chemical pneumonitis.
SECTION 6 : Emergency And First Aid Procedures
Eye Contact:
Flush with large amounts of cool running water for at least 15 minutes while holding upper and lower lids open. If
irritation persists get medical attention immediately.
Skin Contact:
Wash with soap and water. If irritation persists seek medical attention.
Inhalation:
Remove to fresh air. Seek medical attention immediately. If breathing stops give artificial respiration.
Ingestion:
Do not induce vomiting. Seek medical attention immediately.
SECTION 7 : Reactivity Data
Chemical Stability:
Material Stable.
Incompatibilities with Other Materials:
Avoid contact with strong oxidizing agents
Hazardous Polymerization:
Will not occur.
Hazardous Decomposition Products:
Carbon Dioxide, Carbon Monoxide.
SECTION 8 : Precautions For Safe Handling
Spill Cleanup Measures:
4
Allow propellant to evaporate. Maintain local exhaust and adequate ventilation. No smoking. Keep sparks, heat,
sources and open flame far away from spill or leak. Cover with absorbent material and sweep up. Wash area to
prevent slipping. Dispose of soaked absorbent material in accordance with Federal, State and local laws.
Handling:
KEEP OUT OF REACH OF CHILDREN.
For industrial and institutional use only.
Storage:
Store in a cool, dry area away from heat or open flame.
Do not store at temperatures above 120 deg F.
NFPA Code 30B Rating: Level 3 Aerosol.
Waste Disposal:
Aerosol cans, when emptied and depressurized through normal use, pose no disposal hazard and should be
recycled. Consult Federal, State and local authorities for approved procedures.
SECTION 9 : Control Measures
Ventilation System:
Provide local exhaust to keep TLV of Section 2 ingredients below acceptable limits.
Hand Protection Description:
Protective Gloves: Use chemical resistant gloves if hand contact will be made.
Eye/Face Protection:
Wear chemical proof goggles.
Respiratory Protection:
If ventilation is not adequate to reduce vapors below Threshold Limit Value (TLV) levels, use a NIOSH/MSHA
approved air-purifying respirator equipped with an organic vapor cartridge.
SECTION 10 : Other Information
Applies to All Ingredients:
OSHA 29 CFR 1200:
COMPLIES WITH OSHA'S HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
VMPNaphtha:
Section 313 Toxic Release Form (Yes/No): No
Propane:
Section 313 Toxic Release Form (Yes/No): No
Toluene:
Section 313 Toxic Release Form (Yes/No): Yes
n-Butane:
Section 313 Toxic Release Form (Yes/No): No
Titanium Dioxide:
Section 313 Toxic Release Form (Yes/No): No
Barium Sulphate, natural:
Section 313 Toxic Release Form (Yes/No): No
Calcium Carbonate:
Section 313 Toxic Release Form (Yes/No): No
Isobutyl Acetate:
Section 313 Toxic Release Form (Yes/No): No
Mineral Spirits:
Section 313 Toxic Release Form (Yes/No): No
HMIS:
5
Health Hazard: 1 - Slight
Fire Hazard: 3 - Serious
Reactivity: 3 - Serious
Personal Protection: G
MSDS Revision Date:
03/25/04
Disclaimer:
NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of the date of
publication. It is not necessarily all inclusive nor fully adequate in every circumstance. The suggestions should not be
confused with, nor followed in violation of applicable laws, regulations, rules or insurance requirements. No warranty,
express or implied, of merchantability, fitness, accuracy of data, or the results to be obtained from the use thereof is
made. The vendor assumes no responsibility for injury or damages resulting from the inappropriate use of this
product.
HMIS RATING (Based on Aerosol Conc.):
0 - Minimal
1 - Slight
2 - Moderate
3 - Serious
4 - Extreme
NFPA Code 30B Rating: Level 3 Aerosol.
Abbreviations:
Not Applicable = NOT APPLICABLE
Not Established = NOT ESTABLISHED
Not Determined = NOT DETERMINED
< = LESS THAN
> = GREATER THAN
Copyright?1996-2003 Actio Software Corporation. All Rights Reserved.
6
MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA'S HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
SECTION I ?PRODUCT IDENTIFICATION
Product Name: TRAFFIC LANE YELLOW
Traffic Stripe Marking Paint (Traffic Yellow) Formula: Proprietary HMIS Rating (Based on Aerosol Conc.):
Product Paint Date Prepared: 04/08/04 0-Minimal 1- Slight 2- Moderate
Product Type: AEROSOL Emergency Phone: (800) 325-4869 3- Serious 4- Extreme
Supplier's Name: Continental Research Information Phone: (800)325-4869 HEALTH: 1 FIRE: 3 REACTIVITY: 3
Supplier's Address: P.O. Box 15204, St.Louis, Mo.63110 Personal Protection: G
D.O.T. Hazard Class: CONSUMER COMMODITY ?ORM-D
SECTION II ?INGREDIENTS
CHEMICAL NAME CAS # %WT 313/Chem Skin Carcinogen PEL TWA/TLV
VM&P Naphtha 64742-89-8 15-25 NO NO NO 100 ppm 100 ppm
Calcium Carbonate 1317-65-3 10-20 NO NO NO N/A N/A
Propane 74-98-6 10-20 NO NO NO 1000 ppm 1000 ppm
n-Butane 106-97-8 01-10 NO NO NO 800 ppm 800 ppm
Mineral Spirits 64742-47-8 01-10 NO NO NO 100 ppm 100 ppm
SECTION III ?PHYSICAL DATA
Boiling Point: -47?F
pH: N/A Vapor Density(Air=1): >1
Solubility In Water: Miscible Specific Gravity (H2O=1) @75癋: 0.77-0.90
Appearance/Odor: Yellow Coating / Solvent Odor
Vapor Pressure @ 68癋: 40 PSI (2750 hPa)
VOC % by weight: 48.2%
VOC Content: 0.48 kg/l
Water Content: 19.3%
Solids Content: 32.5%
SECTION IV ?FIRE AND EXPLOSION DATA
Flash Point (of Concentrate Only): -2癋 Flammability (as per USA Flame Projection Test): Extremely Flammable Spray
Extinguishing Media: CO2, sand, extinguishing powder or water spray
Special Fire Fighting Procedures: Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
Unusual Fire and Explosion Hazards: Exposure to temperature above 120?F may cause bursting.
SECTION V ?REACTIVITY DATA
Stability: Stable. Hazardous Polymerization: Will not occur.
Incompatibility: Avoid contact with strong oxidizing agents
Hazardous Decomposition Products: Carbon Dioxide, Carbon Monoxide
SECTION VI ?STORAGE AND HANDLING
KEEP OUT OF REACH OF CHILDREN.
For Industrial and Institutional use only.
Store in a cool, dry area away from heat or open flame.
Do not store at temperatures above 120?F. NFPA Code 30B Rating: Level 3 Aerosol.
SECTION VII ?HEALTH AND FIRST AID
PRIMARY ROUTES OF ENTRY & EFFECTS OF OVER EXPOSURE:
Eyes: Irritating effect.
Skin: Frequent or prolonged contact may cause irritation.
Inhalation: Inhalation of mist can cause irritation of nasal and respiratory passages. Abusive or excessive inhalation may cause irritation to the upper respiratory tract,
dizziness, nausea and other central nervous system effects.
Ingestion: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspiration of material into the lungs can cause chemical pneumonitis.
FIRST AID PROCEDURES:
Eyes: Flush with large amounts of cool running water for at least 15 minutes while holding upper and lower lids open. If irritation persists get medical attention immediately.
Skin: Wash with soap and water. If irritation persists seek medical attention.
Inhalation: Remove to fresh air. Seek medical attention immediately. If breathing stops give artificial respiration.
Ingestion: Do not induce vomiting. Seek medical attention immediately.
SECTION VIII ?SPECIAL PROTECTION DATA
Respiratory Protection: If ventilation is not adequate to reduce vapors below Threshold Limit Value (TLV) levels, use a NIOSH/MSHA approved air-purifying respirator
equipped with an organic vapor cartridge.
Ventilation: Provide local exhaust to keep TLV of Section II ingredients below acceptable limits.
Protective Gloves: Use chemical resistant gloves if hand contact will be made.
Eye Protection: Wear chemical proof goggles.
SECTION IX ?SPILL OR LEAK PROTECTION
STEPS TO BE TAKEN IN CASE OF SPILL OR LEAK: Allow propellant to evaporate. Maintain local exhaust and adequate ventilation. No smoking. Keep sparks, heat
sources and open flame far away from spill or leak. Cover with absorbent material and sweep up. Wash area to prevent slipping. Dispose of soaked absorbent material in
accordance with Federal, State and local laws.
WASTE DISPOSAL METHOD: Aerosol cans, when emptied and depressurized through normal use, pose no disposal hazard and should be recycled. Consult Federal, State
and local authorities for approved procedures.
N/A= NOT APPLICABLE ?N/E=NOT ESTABLISHED ?N/D=NOT DETERMINED ?<=LESS THAN ?>=MORE THAN
NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of the date of publication. It is not necessarily all inclusive nor fully adequate in every circumstance. The
suggestions should not be confused with, nor followed in violation of applicable laws, regulations, rules or insurance requirements. No warranty, express or implied, of merchantability, fitness, accuracy of
data, or the results to be obtained from the use thereof is made. The vendor assumes no responsibility for injury or damages resulting from the inappropriate use of this product.
|