Epoxy.com
Material Safety Data Sheet
OSHA's Hazard Communication Standard,
29 CFR 1910.1200.
IDENTITY: Epoxy.com Product #412 "A" Component
SECTION I
Manufacturer: Epox Emergency Number:800-633-8253
y Systems, Inc.
Address: Telephone Number:352-489-1666
20774 West Pennsylvania Ave
Date Printed: 12/2008
Dunnellon,FL34431
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Components CAS # OSHA PEL A CHIH TLV Hazar d Limits
%
Saturated Polyester Resins N/E
Propylene Glycol Monomethyl Ether Acetate 108-65-6 N/E
Xylene 1330-20-7 100ppm
Titanium Dioxide 13463-67-7
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: Specific Gravity (H20 =1): 1. 43
N/E
Vapor Pressure (mm Hg.): N/E Melting Point: N/A
Vapor Density (AIR = 1): Evaporation Rate:
N/D N/E
Solubility in Water: (Butyl Acetate = 1)
Insoluble in water
Appearance and Odor: Viscous liquid; fruity, ester-like odor
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 108?F - 136篎 Setaflash Flammable Limits: LEL N/ UEL N/
E E
Extinguishing Media: Foam, CO2, dry chemical, water, foam
Special Fire Fighting Procedures: Full emergency equipment with self-contained breathing apparatus. Irritating
and or toxic gases and smoke may be present from decomposition/combustion. Isolate from heat sparks, and open
flame.
Unusual Fire and Explosion Hazards: Closed container may explode if exposed to extreme heat ?use cold water
spray to minimize risk of rupture. Solvent vapors may be heavier than air and travel along the ground to an ignition
source, resulting in a flashback to the source of vapors.
SECTION V - REACTIVITY DATA
Stability: Stable Conditions to Avoid: Relatively non-reactive
Incompatibility: This product contains trimethylol propane and should not be combined with phosphorus ?br>
contained materials. Also avoid oxidants.
Hazardous Decomposition or Byproducts: CO, CO? Fire
Hazardous Polymerization: Will Not Occur Conditions to Avoid: None known
(OVER)
#412 "A" Comp
SECTION VI - HEALTH HAZARD DATA
Route(s) of Entry: I nhalation? Yes Skin? No Ingestion? Yes
Health Hazards (Acute and Chronic):.
Carcinogenicity: NTP? N/L IARC Monographs? N/L OSHA Regulated? Not regulated
Signs and Symptoms of Exposure: Eyes: Slight transient injury and irritation.
Skin: Slight irritation and scaling.
Medical Conditions Generally Aggravated by Exposure: In short term, repeated inhalation exposure to nearly
saturated vapor (4000PPM), test animals experienced a slight effect on kidney function. Skin sensitization tests in
guinea pigs were negative.
Emergency and First Aid Procedures: Eyes: Flush with water for at least 15 minutes. Skin: Wash thoroughly
with soap and water. Inhalation: Remove to fresh air & treat for effects of solvent. Consult a physician
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to Be Taken in Case Material Is Released or Spilled: Cover with absorbent material such as sand,
sweeping compound or diatomaceous earth; collect material and handle as normal waste. Remove all sources of
ignition.
Waste Disposal Method: Material is hygroscopic and containers should be tightly closed to prevent contamination
with foreign materials and moisture.
Precautions to Be Taken in Handling and Storing: Material is hygroscopic and containers should be tightly
closed to prevent contamination with foreign materials and moisture.
Other Precautions: Wash after handling.
SECTION VIII - CONTROL MEASURES
Respiratory Protection: Respirator approved for used with organic solvents. Observe OSHA regulations for
respirator use (29 CFR 1910-134)
Ventilation: Mechanical (General)
Protective Gloves: Chemically resistant gloves Eye Protection: As required to maintain air
Concentration below 100PPM
Other Protective Clothing or Equipment:
Work/Hygienic Practices: Follow practices of good industrial hygiene.
N/A = Not Applicable N/D = Not Determined N/E = Not Established
Epoxy.com
Material Safety Data Sheet
OSHA's Hazard Communication Standard,
29 CFR 1910.1200.
IDENTITY: Epoxy.com Product #412 "B" Component
SECTION I
Manufacturer: Epox Emergency Number: 1-800-633-8253
y Systems'TM
Address: Telephone Number: 352-489-1666
20774 West Pennsylvania Ave
Date Printed: 12/2008
Dunnellon,FL34431
SECTION II - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
Hazardous Components CAS # O SHA PEL A CHIH TLV Hazar d Limits
%
Homopolymer of HDI 28182-81-2 N/E 75
Xylene 1330- 20-7 100 ppm 12.5
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: Specific Gravity (H20 =1):
163篎 1.06
Vapor Pressure (mm Hg.): 7.5 x 10/5 Melting Point: N/A
Vapor Density (AIR = 1): Evaporation Rate:
N/E N/E
Solubility in Water: (Butyl Acetate = 1)
Insoluble; reacts with water
Appearance and Odor: Clear, pale yellow liquid with solvent door
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 91癋(33篎) PMCC Flammable Limits: % Volume Xylene LEL1.0 UEL 7. 0
Extinguishing Media: Foam, CO2, dry chemical
Special Fire Fighting Procedures: Full emergency equipment with self-contained breathing apparatus should be
worn. Irritating and/or toxic gases and smoke may be present from decomposition or combustion. Isolate from heat,
open flame, and sparks.
Unusual Fire and Explosion Hazards: Closed container may explode if exposed to extreme heat. Use cold water
spray to minimize risk of rupture. Solvent vapors may be heavier than air and travel along the ground to an ignition
source, resulting in a flashback to the source of vapors.
SECTION V - REACTIVITY DATA
Stability: Stable Conditions to Avoid: Contact with moisture and other materials
which react with isocyanates. Temperature above maximum
storage temperature
Incompatibility: Contact with water, alcohols, amines, strong bases, metal compounds or surface active materials.
Hazardous Decomposition or Byproducts: By fire: CO2, CO, Oxides of Nitrogen, Traces of HCN or HDI
Hazardous Polymerization: Will Not Occur Conditions to Avoid: None known
(OVER)
#412 "B" Comp
SECTION VI - HEALTH HAZARD DATA
Route(s) of Entry: I nhalation? Yes Skin? Yes Ingestion? Yes
Health Hazards (Acute and Chronic): Can cause irritation to skin, eyes and respiratory tract (nose, throat, lungs).
Allerigic skin or respiratory reaction may occur.
Carcinogenicity: NTP? Not Listed IARC Monographs? Not Listed OSHA Regulated? Not Listed
Signs and Symptoms of Exposure: Watering of eyes, dryness of throat, coughing, headache, tightness in chest or
burning sensation. Respiratory sensitivity results in asthma-like symptoms on subsequent exposure even below the
TLV.
Medical Conditions Generally Aggravated by Exposure: Skin sensitivity results in allergic dermatitis which may
include rash, itching, hives and swelling of extremities. Headach, dizziness or nausea are possible.
Emergency and First Aid Procedures: Eyes: Flush immediately for at least 15 minutes. Consult physician. Skin:
Wash with soap and water. Inhalation: Remove victim to fresh air. Administer oxygen or artificial respirator. Get
medical attention. Ingestion: Get medical attention.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to Be Taken in Case Material Is Released or Spilled: Remove all sources of ignition. Ventilate area. Cover
spill with absorbent material such as sand, sweeping compound or diatomaceous earth. Pour liquid decontaminant
over spillage. Allow to react at least 10 minutes. Collect material in open containers.
Waste Disposal Method: Waste materials must be disposed of in accordance with Federal, State, and Local
regulations. Do no heat or cut empty containers with electric or gas torch.
Precautions to Be Taken in Handling and Storing: Keep containers closed. Keep away from heat, sparks and
open flame. Protect from moisture and foreign materials. Ideal storage temperature in 50?- 80?F.
Other Precautions: Wash thoroughly after handling.
SECTION VIII - CONTROL MEASURES
Respiratory Protection: MSA Catalog #CR-84306 (GMA chemical cartridge plus particulate filters).
Ventilation: Mechanical (General) Ventilation needed where vapors are present.
Protective Gloves: Chemical Resistant Gloves Eye Protection: Safety Glasses, splash goggles or face
shield.
Other Protective Clothing or Equipment: In confined areas, the use of a positive pressure supplied air respirator
is mandatory.
Work/Hygienic Practices: Follow practices of good industrial hygiene.
N/A = Not Applicable N/D = Not Determined N/E = Not Established
|