Material Safety Data Sheet
Product Name: Terroxy?Resin Systems -- Joint Filler, Part A
Section 1: Manufacturer Identification
Manufacturer's Name: Terrazzo & Marble Supply Companies
77 South Wheeling Road, Wheeling, Illinois 60090 USA
Address:
800.424.9300 04/04
Emergency Number: Date Printed:
847.353.8000 W. Gallinaitis
Information Number: Preparer:
Section 2: Hazardous Ingredients
Chemical Name CAS # OSHA PEL ACGIH TLV* WT%
Epoxy Resin 25068-38-6 N/E N/E 55-75
5mg/m3 Respirable Dust 2mg/m3 Respirable Dust
Calcium Carbonate 1317-65-3 15-25
--
15mg/m3 Total Dust
Glycidyl Ether 68609-97-2 N/E N/E 10-20
10mg/m Total Dust 10mg/m Total Dust
Titanium Dioxide 13463-67-7 0-4
3 3
N/E -- Not Established
ALL ingredients are registered on TSCA
*Unless otherwise noted, all PEL and TLV Values are reported as 8 hour time weighted averages (TWA)
The exposure limits established for ingredients of this product apply to nuisance dusts from inert fillers. These fillers are blended
into a liquid and pose no hazard as supplied. Substances listed are present in concentration of 1% or greater, or 0.1% if cited as a
potential Carcinogen in the OSHA Hazards Communication Standard. Where proprietary ingredient is listed, the identity is
available as provided in 29 CFR 1910.1200.
Section 3: Health Hazard Data
Health Risks and Symptoms of Exposure:
Inhalation: Heating can generate vapors that could cause headache, nausea, dizziness and respiratory irritation if inhaled.
Eyes: Direct contact of produce can cause irritation.
Skin: Prolonged or repeated contact of product with skin may cause irritation and could result in dermatitis. May cause sensitization or
other allergic reaction.
Ingestion: Slightly toxic.
Health Hazards (acute and chronic):
Carcinogenicity:
NTP Carcinogen: No IARC Monographs: No OSHA Regulated: No
Medical Conditions Generally Aggravated by Exposure: Skin contact may aggravate existing dermatitis (skin condition). Over exposure to
vapor or mist may aggravate existing respiratory conditions such as asthma, bronchitis or fibrotic respiratory disease.
Emergency and First Aid Procedures:
Eyes: Flush at once with potable water for at least 15 minutes. Get medical attention.
Skin: Wash at once with potable water for at least 15 minutes. Remove contaminated clothes. Wash before reuse. Get medical attention if
swelling and/or irritation occurs.
Ingestion: Give water to dilute stomach contents. DO NOT induce vomiting. If vomiting occurs, give fluids again. Get immediate
medical attention. Do not give anything by mouth to an unconscious or convulsing person.
Inhalation: Remove to fresh air. Get medical attention if effects persist.
Section 4: Control Measures
Health -- 2 Flammability -- 1 Reactivity -- 0 P--B
HMIS Rating:
NIOSH/MSHA approved organic vapor respirator when vapors are generated above the
Respiratory Protection:
permissible limit.
Good general mechanical ventilation and local exhaust.
Ventilation:
Plastic or rubber gloves
Protective Gloves:
Safety glasses with side shields or chemical goggles
Eye Protection:
Body covering clothing. A safety shower and eye wash facility should be available.
Other Protective Clothing/Equipment:
Practice good industrial hygiene. Wash with soap and water before eating, smoking or using the
Work/Hygienic Practices:
restroom.
Section 5: Precautions for Safe Handling and Use
Steps to be Taken in Case Material is Released or Spilled: Soak up with absorbent material or scrape up. Residual can be removed with non-
flammable solvent.
Waste Disposal Method: Burn in adequate incinerator or bury in an approved landfill in accordance with local, state or federal regulations.
Precautions to be Taken in Handling and Storing: Store in a cool, dry, well ventilated area away from excessive heat or open flame.
Other Precautions: Avoid breathing of vapors. Practice good personal hygiene and exercise caution to avoid skin and eye contact.
Section 6: Physical/Chemical Characteristics
Not Established
Boiling Point:
Heavier than air
Vapor Density:
Not Established
Vapor Pressure:
0.00
VOC:
Negligible
Solubility in Water:
Clear Liquid, mild odor
Appearance:
1.29
Specific Gravity (H2O=1):
Slower than N-Butyl Acetate
Evaporation Rate:
Section 7: Fire and Explosion Hazard Data
>200篎
Flash Point:
Closed Cup
Method Used:
Flammable Limits in Air
Not Established
By Volume-Lower:
Not Established
By Volume-Upper:
Water spray, dry chemical, foam, carbon dioxide
Extinguishing Media:
Combustible Liquid, Class III A
OSHA Flammability Class:
Wear self contained breathing equipment and full protective clothing.
Special Fire Fighting Procedures:
May produce hazardous fumes or hazardous decomposition products.
Unusual Fire & Explosion Hazards:
Section 8: Reactivity Data
Stable
Stability:
Not Established
Conditions to Avoid:
Not Established
Incompatibility (materials to avoid):
Carbon Monoxide, Carbon Dioxide
Hazardous Decomposition or By-Products:
Will not occur
Hazardous Polymerization:
Section 9: Regulatory Information
SARA Title III Section 313: Unless shown below, this product does not contain the following toxic chemicals subject to the reporting
requirements of section 313 of the Emergency Planning and Community Right to Know Act of 1986 and of 40 CFR 372:
CAS# Chemical Name Percent by Weight
106-89-8 Epichlorohydrin Trace
PROP 65 (Carcinogen): Unless shown below, this product does not contain the chemicals known to the state of California to cause cancer.
CAS# Chemical Name Percent by Weight
None
PROP 65 (Teratogenic): Unless shown below, this product does not contain the chemicals known to the state of California to cause birth
defects or other reproductive harm.
CAS# Chemical Name Percent by Weight
None
PROP 65 (Carcinogen & Teratogenic): Unless shown below, this product does not contain the chemicals known to the state of California
to cause cancer or birth defects or other reproductive harm.
CAS# Chemical Name Percent by Weight
None
Hazardous Waste Information: Unless shown below, this product is not a hazardous waste according to definitions found in CFR-40.
State of Michigan Critical Materials: Unless shown below, this product does not contain ingredients appearing on the
MSDS--JFiller A (04/04)
State of Michigan Critical Materials List.
CAS# Chemical Name Percent by Weight
None
Department of Transportation
Synthetic Resin Liquid
Proper Shipping Name:
Not Regulated
Hazard Class:
None
UN/NA ID Number:
Section 10: Disclaimer
Data and recommendations presented herein are based upon ours and other researchers and are believed to be accurate. The products discussed
are distributed without warranty (expressed or implied) and the customer shall make his own determination of suitability for his particular
purpose.