MSDS# 2006-A
Product Code: I.GABF
Date of Preparation: 8/24/98 Rev. A
Material Safety Data Sheet
SECTION 1 IDENTIFICATION
Product Name: GOLDEN AMERICAN ?D OT 5 Manufacturer:
Silicone Brake Fluid Intercontinental Lubricants Corp./
Spectro Oils of America
993 Federal Road
Brookfield, CT 06804
(203) 775-1291 Fax: (203) 775-8720
MSDS Date of Preparation: 8/24/98
SECTION 2 PR O DUCT COMPO NENTS
INGREDIENTS CAS#. WT.% EXPOSURE LIMITS
.
2.2 mg/mg 3 TWA (ACGIH)
Tributyl Phosphate 126-73-8 1-5%
5 mg/mg 3 TWA (OSHA)
Non-hazardous Ingredients >1%
Dimethylpolysiloxane 63148-62-9 90-100% None Established
SECTION 3: HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
This product is a purple liquid with no odor. May cause eye and skin irritation. Accidental ingestion of large amounts
may cause gastrointestinal effects with nausea vomiting and diarrhea.
HEALTH HAZARDS:
INHALATION: Vapors are unlikely due to physical properties.
SKIN CONTACT: Skin contact may cause irritation . Tributyl phosphate may be absorbed through the skin.
EYE CONTACT: May cause mild irritation.
INGESTION: Swallowing large amounts may cause gastrointestinal effects including nausea, vomiting and diarrhea.
CHR O NIC EFFECTS OF OVEREXPOSU RE: Prolonged or repeated contact may cause central nervous system injury.
CARCIN OGENICITY: None of the components of this product are listed as a carcinogen or suspected carcinogen by
IARC, NTP or OSHA.
MEDICAL CONDITIONS AGGRAVATED BY EXPO SURE: Available information suggests that overexposure is
unlikely to aggravate existing medical conditions.
SECTION 4 EMERGENCY and FIRST AID PR OCEDURES
EYE CONTACT: Immediately flush eye with water for at least 15 minutes while lifting the upper and lower lids. Get medical
attention if irritation develops.
SKIN CONTACT: Wash thoroughly with soap and water. Remove contaminated clothing and launder before reuse. Get
medical attention if irritation develops.
1
Page 1 of
MSDS# 2006-A
Product Code: I.GABF
Date of Preparation: 8/24/98 Rev. A
SECTION 4 EMERGENCY and FIRST AID PR OCEDURES (continued)
INHALATION: Remove victim to fresh air if ill effects occur and get medical attention.
INGESTION: Rinse mouth out with water. Get medical attention by calling a Poison Control Center or hospital emergency
department.
SECTION 5 FIRE and EXPLOSION HAZARD DATA
FLASH POINT: 400癋/204癈
METHO D: PMCC
FLAMMABLE LIMITS: (vol % in air) Not established
AUTOIGNITION TEMPERATURE: Not determined
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIREFIGHTING PR OCEDURES: Firefighters should wear full emergency equipment and NIOSH approved
positive pressure self-contained breathing apparatus. Cool exposed intact containers with water.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None known.
SECTION 6 ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Wear appropriate protective equipment.
Wipe, scrape or soak up with inert material and place in a container for disposal. Clean slippery residue by washing with mild
detergent and water.
SECTION 7 HANDLING and STORAGE
Avoid eye and contact. Wash thoroughly after handling. Use only with adequate ventilation. Do not eat, drink or
smoke in the work area. Remove contaminated clothing and launder before re-use. Discard contaminated shoes and
other items than cannot be laundered.
Store at room temperature in tightly closed containers.
Empty containers retain product residues. Do not cut, weld, braze, etc. on or near empty containers. Follow all MSDS
precautions in handling empty containers.
SECTION 8 EXPOSURE CONTR OLS and PERSO NAL PR OTECTION
RESPIRATORY PR OTECTION: None needed under normal use conditions . If the TLV is exceeded use a NIOSH
approved respirator with a particulate filter (R or P series). For higher concentrations (greater that 10 times the TLV) a
NIOSH approved supplied air respirator (with escape bottle if required) or self-contained breathing apparatus may be
required. Selection of respiratory protection depends on the contaminant type, form and concentration. Select in
accordance with OSHA 1910.134 and good Industrial Hygiene practice.
VENTILATION: Good general room ventilation (equivalent to outdoors) should be adequate under normal conditions. If
the recommended exposure limit is exceeded increased mechanical ventilation such as local exhaust may be required.
GLOVES: Chemical resistant gloves such as rubber are recommended where prolonged or repeated skin contact is
likely.
EYE PR OTECTION: Safety glasses or goggles recommended.
OTHER PR OTECTIVE EQUIPMENT: Impervious apron, boots and other clothing are recommended if needed to avoid
prolonged/repeated skin contact. Suitable washing facilities should be available.
2
Page 2 of
MSDS# 2006-A
Product Code: I.GABF
Date of Preparation: 8/24/98 Rev. A
SECTION 9 PHYSICAL and CHEMICAL PR OPERTIES
B OILING POINT (@ 760 mmHg): Not applicable MELTING POINT: Not applicable
SPECIFIC GRAVITY (H2O=1): 0.958 VOLATILE: Less than 1%
VAPOR PRESSURE (@ 20 C mm Hg): Negligible (VAPOR DENSITY (AIR=1): Not applicable
EVAPORATION RATE : (But yl Acetate=1): Less than 1 COEFFICIENT OF WATER/OIL: Not available
APPEARANCE AND O D O R: Purple liquid, no odor.
SECTION 10 STABILITY and REACTIVITY
STABILITY: This material is stable.
CONDITIONS TO AVOID: Avoid excessive heat. and open flames
INCOMPATIBILITY: Strong acids, bases and oxidizing agents.
HAZARD O US DECOMPOSITION PR O DUCTS: Thermal decomposition may yield carbon monoxide, carbon dioxide,
formaldehyde.
HAZARD O US POLYMERIZATION: Will not occur.
SECTION 11 TOXICOLOGICAL INFO RMATION
ACUTE TOXICITY VALUES: Tributyl Phosphate: Oral rat LD50 3000 mg/kg
Polydimethylsiloxane: Oral rat LD50 5000 mg/kg
None of the components is listed as a carcinogen or suspect carcinogen by NTP, IARC or OSHA.
None of the components have been found to be mutagenic.
None of the components are known to cause sensitization in animals or humans.
None of the components are known to cause adverse reproductive effects or teratogenic effects in animals or humans.
SECTION 12: ECOLOGICAL INFOR MATION
There is no ecotoxicity data available for this product at this time.
SECTION 13: DISPOSAL INFORMATION
WASTE DISPOSAL METHOD: Dispose in accordance with all local, state and federal regulations.
SECTION 14: TRANSPO RTATION INFORMATION
D OT SHIPPING DESCRIPTION : Not Regulated
D OT HAZARD CLASSIFICATION: None
D OT LABELS REQ UIRED (49CFR172.101): None
UN NUMBER: None
SECTION 15: REGULATORY INFORMATION
O SHA HAZARD CLASSIFICATION: Target organ effects.
EPA SARA 302: This product does not contain chemicals regulated under SARA Section 302.
EPA SARA 311 HAZARD CLASSIFICATION: Chronic health
EPA SARA 313: This product contains the following chemicals that are regulated under SARA Title III, section 313:
None
CERCLA Hazardous Substances (Section 103)/RQ : This product is not subject to CERCLA reporting requirements,
however, many states have more stringent release reporting requirements. Report spills required under federal;, state and
local regulations.
3
Page 3 of
MSDS# 2006-A
Product Code: I.GABF
Date of Preparation: 8/24/98 Rev. A
SECTION 15: REGULATORY INFORMATION (continued)
W H MIS CLASSIFICATION: Class D2, Subdivision B: Toxic material causing other chronic effects.
EU CLASSIFICATION: Not a dangerous preparation.
EU RISK AND SAFETY PHRASES: None
TOXIC SUBSTANCES CONTR OL ACT: All of the components of this product are listed on the TSCA inventory.
CALIFORNIA PR OPOSITION 65: This product is not known to contain any chemicals which are known to the State of
California to cause cancer or reproductive harm.
Canada: All of the components of this product are listed on the Canadian Domestic Substances List (DSL).
EEC EINECS: All of the ingredients are listed on the EINECS inventory.
SECTION 16: OTHER INFOR MATION
NFPA Rating: Health: 1 Fire: 1 Reactivity: 0
4
Page 4 of
|