CHILL-ouT PENETRATING oIL
80-1206
HMIS RATING NFPA 704 RATING 5. HEALTH EFFECTS DATA CoN'T.
Health 2 MATERIAL Health 2
First aid PrOCedures
Flammability 3 SAFETY DATA Flammability 2 eye COntaCt ....................Immediately flush eyes with plenty of water. Obtain
medical attention if irritation persists.
reactivity 0 SHEET reactivity 0
sKin COntaCt ...................Treated burned or frostbitten skin by flushing or
immersing affected areas in lukewarm water. If skin
Kimball-midwest NFPA 30B LEVEL
is burned, keep warm and stimulate circulation with
P.O. bOx 2470
n/a massage. Seek medial attention immediately.
COlumbus, OH 43216-2470
ingestiOn ..........................Obtain medical attention immediately. If swallowed, do
COrPOrate telePHOne: 614-219-6100
not induce vomiting. Give victim two glasses of water.
emergenCy telePHOne: 800-424-9300 Never give anything by mouth to an unconscious
person.
1. PRoDuCT IDENTIFICATIoN
inHalatiOn ........................Remove to fresh air. If not breathing, give artificial
Part number ............................. 80-1206 respiration. If breathing is difficult, give oxygen.
Obtain medical attention immediately.
PrOduCt name ......................... Chill-Out Penetrating Oil
CHemiCal Family....................... 1,1 - difluorethane sPeCial HealtH eFFeCts
dOt sHiPPing ............................. Consumer Commodity ORM-D CARCINOGEN (OSHA Guidelines).............This product does not contain any
chemicals known to the State of California to
2. HAZARDouS INGREDIENTS cause cancer.
SPECIFIC CHEMICAL IDENTITY, CoMMoN NAMES oSHA PEL ACGIH TLV Supplier oEL %
6. REACTIVITY
1,1 - difluorethane (HFC-152a) (75-37-6) NE NE - NE
Dimethylpolysiloxanes (63148-62-9) ne ne - ne stability ............................................................ Stable under normal
*Methyl Isobutyl Ketone (108-10-1) 100ppm 50ppm - ne conditions.
Oleic Acid (68187-99-5) NE NE - ne inCOmPatibilities ............................................ Alkali or alkali earth metals
- (powdered Al, Zn, Be) and
All chemical compounds marked with an asterisk (*) are toxic chemicals subject to the strong oxidizing agents.
reporting of Section 313 of Title III of the Superfund Amendments and Reauthorization Act HaZardOus deCOmPOsitiOn
(SARA) of 1986 and 40 CFR Part 372. You must notify each person to whom this mixture of
PrOduCts ......................................................... C a r b o n d i o x i d e , c a r b o n
trade name product is sold. This statement must not be detached. Any copy or redistribution
monoxide, hydrofluoric acid,
of this Material Safety Data Sheet shall include this statement. **Ceiling
carbonyl fluoride.
HaZardOus POlymeriZatiOn ....................... Will not occur under normal
3. PHYSICAL DATA conditions.
HaZardOus POlymeriZatiOn
BOILING POINT (RANGE) ................................... nd
COnditiOns..... .................................................. None known.
VaPOr Pressure Psig @ 70癋...................... <90
VAPOR DENSITY (AIR = 1) ................................. >1
7. PRECAuTIoNS FoR SAFE HANDLING & uSE
sOlubility in water....................................... negligible
SPECIFIC GRAVITY (H2O = 1)............................ .91 PrOteCtiVe eQuiPment
melting/FreeZing POint............................... n/a reQuirements.................If vapor concentrations exceeds TLV, use respiratory
EVAPORATION RATE (61%=1) ........................... nd approved by NIOSH for organic vapors to be used
VOC content (by weight) ...................................... 100% in a positive pressure mode. Rubber gloves and
aPPearanCe and OdOr ................................. Colorless spray/ faint solvent safety glasses are recommended. Self-contained
odor respiratory should be available for non-routine and
emergency situations.
4. FIRE AND EXPLoSIoN DATA wasH reQuirements .....Soap & water.
sPill Or leaK
FlasH POint ...................................................... n/a
UPPER EXPLOSIVE LIMIT (%) ........................... ne PrOCedures ....................Remove all sources of ignition. Ventilate area to
disperse vapors.
LOWER EXPLOSIVE LIMIT (%) .......................... ne
extinguisHing media .....Dry chemical, CO2, foam. WASTE DISPOSAL METHODS Dump as chemical waste according to local,
state, and federal regulations. Aerosol cans when
sPeCial FireFigHting PrOCedures .......... As in any fire, wear a self-
contained breathing apparatus pressure-demand vented to atmospheric pressure through normal use
(MSHA/NIOSH approved or equivalent) and fill pose no disposal hazard.
protective gear. HANDLING & STORAGE .....Do not puncture or incinerate containers. Wash
Fire and exPlOsiOn HaZards ..................... Aerosol cans may erupt with thoroughly after handling. Keep away from heat,
force at temperatures above 120癋. sparks, and flames. Store below 120oF.
OtHer PreCautiOns ......Avoid breathing vapor, contact with eyes/skin.
5. HEALTH EFFECTS DATA Allow product to reach room temperature before
use.
sHOrt term eFFeCts OF exPOsure
8. ADDITIoNAL INFoRMATIoN
rOute OF entry ..............Inhalation, Skin Contact, Eye Contact, Skin Absorption
and Ingestion Use self-contained breathing apparatus if TLV limits are exceeded. Do not eat
or smoke while using. Wash hands after use. Use positive pressure air supplied
HealtH HaZards
(ACUTE AND CHRONIC) .....Product is an asphyxiant at very high concentrations. respirator if there is potential for uncontrolled release, if exposure levels are
Excessive inhalation of vapors can be harmful unknown, or in any circumstance where air purifying respirators may not provide
and may cause headache, disorientation, rapid adequate protection.
respiration, nausea, anesthetic effects, temporary
CNS depression, and possible unconsciousness.
Vapors are heavier than air and displace oxygen THE INFoRMATIoN GIVEN AND THE RECoMMENDATIoNS MADE HEREIN
required for breathing. High exposures may lead to APPLY To ouR PRoDuCT(S) ALoNE AND ARE NoT CoMBINED WITH
shortness of breath, temporary alteration of cardiac oTHER PRoDuCTS. SuCH INFoRMATIoN IS BASED uPoN ouR RESEARCH
electrical activating with irregular pulse, palpitations AND oN DATA FRoM oTHER RELIABLE SouRCES AND IS BELIEVED
or inadequate circulation.
To BE ACCuRATE. No GuARANTEE oF ACCuRACY IS MADE. IT IS
eye ......................................Avoid contact with eyes: may cause redness and
THE PuRCHASER'S RESPoNSIBILITY BEFoRE uSING ANY PRoDuCT
irritation.
To VERIFY THIS DATA uNDER THEIR oWN oPERATING CoNDITIoNS
inHalatiOn ........................Possible chemical pneumonitis if aspirated into the
AND To DETERMINE WHETHER THE PRoDuCT IS SuITABLE FoR THEIR
lungs.
sKin .....................................May cause frostbite and burns. PuRPoSES.
ingestiOn ..........................Not likely to be ingested.
CoPYRIGHT?1984 KIMBALL MIDWEST uPDATE 9/08
|