Page: 1
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: POLYPRIMER SURFACER GRAY HMIS CODES: H F R P
PRODUCT CODE: 901 2*3 1
================== SECTION I - MANUFACTURER IDENTIFICATION =================
MANUFACTURER'S NAME: PCL
ADDRESS : 3150 E. PICO BLVD.
LOS ANGELES, CA 90023-3683
EMERGENCY PHONE(CHEMTREC) : (800) 424-9300 DATE PRINTED : 4/30/2009
INFORMATION PHONE : (800) 672-4900 NAME OF PREPARER :
========= SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ==========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mmHG @TEMP(F) PERCENT
--------------------------------------------------------------------------------
~ STYRENE 100-42-5 4.5 68 18.31
OSHA PEL: 100 PPM, ACGIH TLV: 50 PPM
ACETONE 67-64-1 185.5 68 7
OSHA PEL: 1000 ppm; 2,400 mg/m3
OSHA TWA: 750 ppm; 1,800 mg/m3
OSHA STEL: 1000 ppm; 2,400 mg/m3
ACGIH TWA: 500 ppm, STEL: 750 ppm
~ SOLVENT NAPHTHA(PETROLEUM),LT. ALIPHATIC 64742-89-8 41.4 68 2.34
OSHA PEL: 400 ppm, ACGIH TLV: 400 ppm
~ METHYL ISOBUTYL KETONE 108-10-1 14.5 68 2.31
OSHA PEL: 100 ppm, ACGIH TLV: 50 ppm
~ METHYL ETHYL KETONE 78-93-3 70.9 68 2.31
OSHA PEL: 200 ppm, ACGIH TLV: 200 ppm
n-BUTYL ACETATE 123-86-4 8.4 68 2
ACGIH TLV: 150 ppm
~Indicates toxic chemical(s) subject to the reporting requirements of section
313 of Title III and of 40 CFR 372.
============== SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS =============
BOILING RANGE (Deg F): 133 - 295 DENSITY: 11.14 lb/gal
VAPOR DENSITY: HEAVIER THAN AIR SPECIFIC GRAVITY (H2O=1): 1.34
ACTUAL CATALYZED COATING V.O.C.: 1.67 lbs/gal; 200 gm/L
ACTUAL CATALYZED MATERIAL V.O.C.: 1.54 lbs/gal; 185 gm/L
SOLUBILITY IN WATER: Negligible EVAPORATION RATE: SLOWER THAN ETHER
APPEARANCE AND ODOR: Gray liquid with mild odor
================ SECTION IV - FIRE AND EXPLOSION HAZARD DATA ===============
FLASH POINT (Deg F): 1 METHOD USED: TOC
FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: 1 UPPER: 12.8
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL, WATER FOG, OTHER
MATERIAL SAFETY DATA SHEET
901 Page: 2
SPECIAL FIREFIGHTING PROCEDURES
Use approved self-contained breathing apparatus. Do not use direct stream of
water.
UNUSUAL FIRE AND EXPLOSION HAZARDS
Fire-exposed containers should be cooled with water to prevent pressure build-up
which could result in container rupture.
======================= SECTION V - REACTIVITY DATA =======================
STABILITY: STABLE
CONDITIONS TO AVOID
Excessive heat, sparks or open flames.
INCOMPATIBILITY (MATERIALS TO AVOID)
Strong oxidizing agents
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
Thermal decomposition may yield carbon dioxide and/or carbon monoxide.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
==================== SECTION VI - HEALTH HAZARD DATA =======================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Inhalation: May cause nasal and respiratory irritation, dizziness, weakness,
fatigue, nausea and headache. High concentrations may result in narcosis.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Eye contact: May cause severe irritation, redness, tearing and blurred vision.
Skin contact: May cause moderate irritation.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Skin absorption: May cause irritation, de-fatting and dermatitis.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Ingestion: May cause gastrointestinal irritation, nausea, vomiting and diarrhea.
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: May cause eye, nose, respiratory tract and skin irritation, headache,
drowsiness and nausea. Ingestion may result in vomiting; aspiration (breathing
in) into the lungs may result in aspiration pneumonitis. Chronic: Long term
exposure may lead to central nervous system depression, dermatitis and liver and
kidney damage.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: Yes OSHA REGULATED: No
This material contains a cobalt compound, which is classified as a possible
carcinogen for humans (2B) by IARC. This material contains styrene, which is
classified as a possible carcinogen for humans (2B) by IARC.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
Pre-existing eye, skin and respiratory disorders may be aggravated.
MATERIAL SAFETY DATA SHEET
901 Page: 3
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: MOVE PERSON TO FRESH AIR. PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN
IF BREATHING IS DIFFICULT. EYE & SKIN CONTACT: FLUSH EYES IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. WASH AFFECTED AREAS WITH SOAP
AND WATER IMMEDIATELY. REMOVE CONTAMINATED CLOTHING. INGESTION: IF SWALLOWED,
DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
=========== SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE ============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
PROVIDE VENTILATION. LARGE SPILLS MAY BE SCOOPED UP. SMALL SPILLS MAY BE PICKED
UP WITH ABSORBENT MATERIALS.
WASTE DISPOSAL METHOD
Place in tightly closed containers and dispose of in accordance with local,
state and federal regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Store away from high temperatures and open flames. Keep containers tightly
closed. Use with adequate ventilation.
OTHER PRECAUTIONS
Do not take internally. Avoid prolonged contact. Ground equipment to prevent
accumulation of static charge.
===================== SECTION VIII - CONTROL MEASURES ======================
RESPIRATORY PROTECTION
Use self-contained breathing apparatus where vapor concentration may be above
TLV limits. Where vapor does not exceed TLV limits, use NIOSH/MSHA approved
respirator.
VENTILATION
Adequate volume and pattern to keep air contaminant concentration below current
applicable OSHA or ACGIH TLV limits.
PROTECTIVE GLOVES
Chemical resistant gloves
EYE PROTECTION
Chemical goggles, safety glasses
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Eye bath and safety shower
WORK/HYGIENIC PRACTICES
Wash hands thoroughly before eating or using the washroom. Smoke in smoking
areas only.
=================== SECTION IX - TRANSPORT INFORMATION ====================
DOT (GROUND)
1.3 gallons (5 liters) or less:
MATERIAL SAFETY DATA SHEET
901 Page: 4
UN1263,Paint,3,PGII, "Ltd. Qty."
Greater than 1.3 gallons (5 liters):
UN1263, Paint,3,PGII
AIR
UN1263,Paint,3,PGII
=================== SECTION X - REGULATORY INFORMATION ====================
CALIFORNIA PROPOSITION 65
None
======================== SECTION XI - DISCLAIMER =======================
The information contained herein is based on the data available to us and is
believed to be correct. However, PCL makes no warranty expressed or implied
regarding the accuracy of these data or the results to be obtained from the use
thereof. PCL assumes no responsibility for injury from the use of the product
described herein.
|