1
MF-1210
MATERIAL SAFETY DATA SHEET
I. IDENTIFICATION .
MANUFACTURED BY: Diamond Vogel Paint REVISED: 09/18/2009
1020 Albany Place SE PRINTED: 09/25/2009
Orange City, IA 51041
General Information:
24 Hour Emergency Telephone Mon-Fri 8 AM - 5 PM
CHEMTREC 1-800-424-9300 712-737-4993
TRADE NAME: V-Cote 111 Epoxy W/R White (Part A)
MFG. PRODUCT NUMBER: MF-1210
II. HAZARDOUS INGREDIENTS .
CAS #25068-38-6 Bis A,Epichlorohydrin Epoxy WT %: 5-20
ACGIH TLV: NE ACGIH STEL: NE
OSHA PEL: NE OSHA CEILING: NE OSHA PEAK: NE
VAPOR PRESSURE: .02mmHg@20C LEL%: NA
CAS #14807-96-6 Talc (powder) WT %: 1-5
ACGIH TLV: 2 mg/m3 TWA (resp) ACGIH STEL:
OSHA PEL: 20 mppcf TWA OSHA CEILING: OSHA PEAK:
VAPOR PRESSURE: LEL%:
CAS #14808-60-7 Crystalline Silica WT %: 1-5 Footnote: (2)
ACGIH TLV: 0.025 mg/m3 ACGIH STEL: NE
OSHA PEL: 10/(%SiO2+2) mg/m3 OSHA CEILING: NE OSHA PEAK: NE
VAPOR PRESSURE: NA LEL%: NA
CAS #107-98-2 Propylene Glycol Methyl Ether WT %: 1-5 Footnote: (1)
ACGIH TLV: 100 PPM TWA ACGIH STEL: 150 PPM
OSHA PEL: OSHA CEILING: OSHA PEAK:
VAPOR PRESSURE: 10.9 mm LEL%: 3.0
WARNING MESSAGES:
(1) Reports have associated repeated and prolonged occupational overexposure to solvents
with permanent brain and nervous system damage. Intentional misuse by deliberately
concentrating and inhaling the contents may be harmful or fatal. Chronic exposure may
cause damage to the central nervous system, respiratory system, lung, eye, skin, liver,
gastrointestinal tract, spleen, kidneys, and blood.
(2) International Agency for Research on Cancer (IARC) Monograph Volume 68 (1997) concludes
that Crystalline Silica is "carcinogenic to humans (Group 1)" based on sufficient
evidence in humans and experimental animals.
(3) See Section IX for reportable Hazardous Air Pollutants.
III. PHYSICAL DATA .
BOILING RANGE: 212?F
EVAPORATION RATE: * slower than ether *
PERCENT VOLATILE BY VOLUME: 55.88% WEIGHT PER GALLON: 12.20 LBS
VAPOR DENSITY: * trace amounts of organic vapors will be heavier than air *
ACTUAL VOC (lb/gal): 0.18
2
MF-1210
EPA VOC (lb/gal): 0.39 EPA VOC (g/L): 46.74
IV. FIRE AND EXPLOSION HAZARD DATA .
FLASH POINT: 200+?F 93+?C LEL: Refer to Section II
FLAMMABILITY CLASSIFICATION: * Not Regulated *
HAZARD CLASSIFICATION: *Not Regulated*
EXTINGUISHING MEDIA: Use water spray, dry chemical, foam, or Carbon
Dioxide. Use water spray to cool fire-exposed
containers.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Closed containers may explode when
exposed to extreme heat. (Due to buildup of steam
pressure.)
SPECIAL FIRE FIGHTING PROCEDURES:
In case of fire and/or explosion do not breathe fumes. Use
water spray to reduce vapors. If water pollution occurs,
notify appropriate authorities. Wear NIOSH approved
self-contained breathing apparatus with independent air
supply. Keep containers cool with water spray. Avoid skin
contact.
V. HEALTH HAZARD DATA .
THRESHOLD LIMIT VALUE: See Section II.
EFFECTS OF OVEREXPOSURE:
Acute- Moderately irritating to the eyes and skin. Vapors may be
mildly irritating to the nose, throat and respiratory tract
and may be slightly toxic and harmful if inhaled or ingested.
Chronic- Repeated contact can result in defatting and drying of
the skin which may result in skin irritation and dermatitis.
Prolonged inhalation may result in central nervous system
depression which may be evidenced by giddiness, headache,
dizziness and nausea: in extreme cases, unconsciousness and
death may occur.
This product contains crystalline silica which is classified
as a Group 1 carcinogen by the International Agency for
Research on Cancer (IARC). This category is used when there
is sufficient evidence of carcinogenicity in humans.
Crystalline silica may also cause delayed respiratory
disease (silicosis) if inhaled over a long period of time.
Avoid breathing dust. Use NIOSH/ MSHA approved respirator
when TLV for crystalline silica may be exceeded.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
3
MF-1210
Eye disease, Skin disorders and Allergies
PRIMARY ROUTE(S) OF ENTRY: Ingestion, Skin Absorption, Inhalation
EMERGENCY AND FIRST AID PROCEDURES:
INHALATION: Remove to fresh air. Restore breathing. Treat
symptomatically. Consult a physician.
EYES: Flush immediately with large amounts of water for at least
15 minutes. Talk to a physician for medical treatment.
SKIN: Wipe off with towel. Wash with soap and water. Remove
contaminated clothing.
INGESTION: If swallowed, call a physician immediately. Remove
stomach contents by gastric suction or induce vomiting only
as directed by a medical personnel. Never give anything by
mouth to an unconscious person.
VI. REACTIVITY DATA .
STABILITY: *stable* HAZARDOUS POLYMERIZATION: *will not occur*
INCOMPATIBILITY: * unknown *
HAZARDOUS DECOMPOSITION PRODUCTS: Fire, burning and welding may
generate carbon monoxide, aldehydes, acids and other
organic substances.
CONDITIONS TO AVOID: Avoid acid contamination and skin contact.
Keep containers tightly closed. No smoking
or eating in handling area.
VII. SPILL OR LEAK PROCEDURES .
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Remove all sources of ignition (flames, hot surfaces and
electrical, static or frictional sparks). Avoid breathing
vapors. Ventilate area. Use non-sparking tools. Remove with
inert absorbant.
WASTE DISPOSAL METHOD: Dispose of in accordance with local, state, and
federal regulations.
VIII. SPECIAL PROTECTION INFORMATION .
RESPIRATORY PROTECTION: In confined areas of poor ventilation, use chemical
cartridge respirator or self-contained breathing
apparatus.
VENTILATION: Provide general dilution or local exhaust ventilation in
volume and pattern to keep TLV and LEL of most hazardous
ingredient in Section II, below acceptable limit.
PROTECTIVE GLOVES: Impermeable gloves to prevent skin contact.
4
MF-1210
EYE PROTECTION:
Splash proof eye goggles. In emergency situations, use eye
goggles with a full face shield.
OTHER PROTECTIVE EQUIPMENT:
Wear suitable clothing. Long sleeved clothing.
HYGIENIC PRACTICES: See Section V
IX. SPECIAL PRECAUTIONS .
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Do not store near heat,
sparks, flame, strong oxidizing agents or strong acids
OTHER PRECAUTIONS: Eye wash station and safety shower
should be available
This product contains no reportable Hazardous Air Pollutants.
_____________________________________________________________________________
|