MATERIAL SAFETY DATA SHEET
MULTI PURPOSE NON-DRIP ADHESIVES & PINCHWELD PRIMER
6/21/05
PRODUCTS COVERED: BG-A, TA-B, TG-A & BP-P
SECTION I MANUFACTURER
Crest Industries, Inc., 1337 King Road, Trenton, MI 48183 Phone: (734) 479-4141 FAX: (734) 479-4040
24 HOUR EMERGENCY TELEPHONE (CHEMTEL): (800) 255-3924 INTERNATIONAL CALLS: (813) 248-0585
SECTION II PRODUCTS
Hazardous HMIS
Stock Ingredients RATING Solubility Volatile
Number Product Name on Label in Products* H F R Appearance and Odor % in Water Volume %
BG-A Clear Tack Multi Purpose
Non Drip Adhesive 1,2,3,5 2* 3 0 Clear paste, aromatic solvent <1 55-60
TA-B Black Tack Multi Purpose
Non Drip Adhesive 1,2,3,5 2* 3 0 Black paste, aromatic solvent <1 55-60
TG-A Clear Tack Multi Purpose
Non Drip Adhesive 1,2,3,5 2* 3 0 Clear paste, aromatic solvent <1 55-60
BP-P Pinchweld Primer 1,2,3,4 2* 3 0 Black liquid, aromatic solvent <1 65-70
SECTION III HAZARDOUS INGREDIENTS
Exposure Limits* Flash Vapor Pres.- Evap. Rate Boiling Flammable Autoigni-
CAS in ppm (parts Point sure (mm Hg (n-Butyl Point Limits in % tion Pt.
Ingredients Number Per million) 癋 癈 at 20癈) Acetate=1) 癋 癈 Lower Upper 癋 癈
1. n-Hexane 110-54-3 50 A, 500 O** -7 -22 140 8.1 156 69 1.2 7.4 437 225
2. Methylcyclo-
pentane 96-37-7 500 A -20 -29 140 8E 161 72 1.2 7.5 496 258
3. Methylpentane Mixture 500 A -20 -29 140 8E 140 60 1.2 7.5 507 264
4. Toluene 108-88-3 50 A Skin, 200 O 45 7 38 1.5 230 110 1.2 7.0 896 480
5. Xylene
(Mixed Isomers) 1330-20-7 100 A, 80 27 10 0.8 281 138 1.0 6.4 810 432
*A means ACGIH TLV, O means OSHA PEL, E means Estimated. Other abbreviations: > means greater than, < means less than,
Unk means Unknown, NE means Not Established, NA means Not Applicable. **See NOTES in SECTION VI.
SECTION IV PHYSICAL DATA prolonged occupational overexposure to solvent vapors with
Evaporation Rate: See SECTIONS II, II. Vapor Density: Heav- permanent brain and nervous system damage. Symptoms in-
ier than air. Solubility in Water (Wt%): See SECTION II. Volatile clude loss of memory, loss of intellectual ability and loss of coor-
Volume %: See SECTION II. Approximate Boiling Point: See dination. NOTE: Prolonged and/or repeated overexposure to 1.
SECTIONS II, III. Flammable Limits Volume %: See SECTION n-Hexane may cause Peripheral Neuropathy (damage to nerve
II. Product Density (water = 1): Less than 1. Appearance and tissue of the arms or legs) resulting in muscular weakness and
Odor: See SECTION II. loss of sensation in some or all of the following: fingers, hands,
SECTION V FIRE AND EXPLOSION DATA arms, toes, feet or legs. NOTE: INTENTIONAL MISUSE BY DE-
Flammability Class: Flammable Liquid. LIBERATELY CONCENTRATING AND INHALING ANY SOL-
Flash Point (Tag Closed Cup Method): See SECTIONS II, III. VENT VAPORS MAY BE HARMFUL OR FATAL!
Approximate Flammable Limits: See SECTIONS II, III. SKIN CONTACT:
Autoignition Temperature: See SECTIONS II, III. Acute Exposure: Repeated or prolonged skin contact
Extinguishing Media: Foam, carbon dioxide, dry chemical. with solvents can result in dry, defatted and cracked skin causing
Special Fire Fighting Procedures: Full protective equipment, increased susceptibility to infection. Skin irritation may develop
including self-contained breathing apparatus, is recommended into contact dermatitis.
because highly toxic gasses may be generated by combustion or Chronic Exposure: Exposure to small amounts of solvent
thermal decomposition. Water from fog nozzles may be used to over long periods may cause some or all of the symptoms as in
cool closed containers to prevent pressure build up (containers acute exposure to solvents.
may leak or burst when heated). EYE CONTACT:
Unusual Fire and Explosion Hazards: Vapors are heavier than Acute Exposure: Irritation of the eyes with itching, burning,
air and may travel along the ground or be moved by ventilation redness and even permanent tissue damage if applied directly to
and ignited by pilot lights, other flames, sparks, heaters, electric the eyes and not flushed out immediately.
motors, smoking or other ignition sources at locations far from Chronic Exposure: Irritation of the eyes with itching, burning,
material handling point. At elevated temperatures [130癋 (54癈) redness.
or over] containers may vent, rupture or burst. INGESTION:
SECTION VI HEALTH HAZARD DATA Acute Exposure: (Not likely) Irritation to the mouth, and if
PRIMARY ROUTES OF EXPOSURE: Inhalation, Skin contact, swallowed, to the esophagus, stomach tissue and digestive tract.
Eye contact. Chronic Exposure: Unknown.
SIGNS AND SYMPTOMS OF EXPOSURE: MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE:
INHALATION: (See NOTEs) None specifically known to Crest Industries, Inc.
Acute Exposure: Solvent vapors at concentrations above the but it is possible that eye, respiratory tract, skin, liver, kidney,
TLV can irritate the respiratory tract (nose, throat, lungs) causing blood cell formation, nervous system and brain diseases may be
a burning sensation, runny nose, sore throat, coughing, chest aggravated by overexposure to the products on this MSDS.
discomfort (tightness). May cause central nervous system de- CARCINOGENICITY: Products not listed by NTP, IARC or
pression with the following progressive symptoms: headache, OSHA.
SECTION VII EMERGENCY AND FIRST
dizziness, nausea, staggering gait, confusion, unconsciousness,
AID PROCEDURES
cessation of breathing and death.
EYE CONTACT: Flush with clean, lukewarm water (low pres-
Chronic Exposure: Reports have associated repeated and
Multi Purpose Non Drip Adhesive 6/21/05 page 2
sure) for at least 15 minutes while lifting eyelids. Refer person to ucts. Follow all label instructions.
physician for immediate attention. SECTION IX REACTIVITY DATA
SKIN CONTACT: Remove contaminated clothing immediately. STABILITY: Stable under normal room conditions.
Clean affected areas thoroughly with waterless hand cleaner and HAZARDOUS POLYMERIZATION: Will not occur.
wash with soap and water. Dry clean contaminated clothing thor- INCOMPATIBILITY (Materials to Avoid): Strong oxidizers
oughly before reuse. Seek medical attention if irritation develops HAZARDOUS DECOMPOSITION PRODUCTS: By high heat
or persists. and fire: carbon dioxide, carbon monoxide, hydrocarbon vapors,
INHALATION: Move to an area free from risk of further expo- smoke.
sure. Administer oxygen or artificial respiration as needed. Obtain SECTION X SPILL OR LEAK PROCEDURES
medical attention. STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR
INGESTION: Induce vomiting. Consult physician, hospital SPILLED: Put on protective equipment including respiratory pro-
emergency room or poison control center immediately. Have list tection. Prevent further spillage. Evacuate nonessential per-
of ingredients available. sonnel. Remove all sources of ignition and ventilate the area.
NOTES TO PHYSICIAN: Keep spill from reaching sewers and waterways. Cover the spill
Eyes: May cause conjunctivitis. Stain for evidence of corneal with sawdust, vermiculite, Fuller's Earth or other absorbent mate-
injury. rial. Collect material with non-sparking tools and put in a tightly
Skin: Treat as any contact dermatitis. sealed container. Remove container to a safe place.
Inhalation: Treat as for solvent vapor inhalation. Broncho- WASTE DISPOSAL METHOD: Follow all federal, state and
dilators, expectorants and antitussives may help. local environmental control regulations. Incineration is the pre-
Ingestion: Induce vomiting. Treat symptomatically. ferred method. Containers must be handled with care due to
SECTION VIII EMPLOYEE PROTECTION flammable and toxic residue.
RECOMMENDATIONS RCRA STATUS: Since these products contain ignitable and
EYE PROTECTION: Wear safety glasses. toxic chemicals, they are hazardous when discarded.
SKIN PROTECTION: Cover as much of the skin as possible SECTION XI SPECIAL PRECAUTIONS &
with appropriate clothing. Wear solvent resistant gloves. STORAGE DATA
VENTILATION AND RESPIRATORY PROTECTION: If exhaust STORAGE TEMPERATURE
ventilation sufficient to keep the airborne concentrations of sol- MINIMUM / MAXIMUM: 50癋 (10癈) / 120癋 (49癈)
vents below their respective TLV's is not possible, an RECOMMENDED SHELF LIFE: One year
OSHA/MSHA approved TC23C Respirator or TC19C Air Sup- PRECAUTIONS TO BE TAKEN IN HANDLING, STORAGE
plied Respirator must be used. Observe OSHA regulations AND USE: Keep away from heat, sparks and open flame. Do
(29 CFR 1910.134) for respirator use. not store in temperatures above 120癋 (49癈) or in direct
NOTE: THERE MUST ALWAYS BE ENOUGH VENTILATION sunlight. Do not inhale vapors. Avoid contact with skin and eyes.
TO KEEP VAPOR CONCENTRATION BELOW THE LOWER Wash hands after use and before eating, drinking, smoking or
FLAMMABLE LIMIT! using the toilet. Employee education and training in the safe use
OTHER PROTECTIVE MEASURES: Eyewash stations should and handling of these materials are required under the OSHA
be available. Educate and train employees in safe use of prod- Hazard Communication Standard (29CFR 1910.1200).
KEEP OUT OF THE REACH OF CHILDREN!
SECTION XII FEDERAL EPA REGULATION COMPLIANCE INFORMATION
EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT of 1986
1) Section 313 Supplier Notification: Chemicals marked with an * in the following tables are subject to the Toxic Chemical Re-
lease Inventory Reporting Requirements using EPA FORM R (40 CFR Part 372).
2) Section 312: All the chemicals listed are subject to Emergency and Hazardous Chemical Inventory Forms and Community Right-
to-Know Reporting Requirements: Tier I and Tier II Reports (40 CFR Part 370).
NOTE: This information should be included in all MSDSs that are copied and distributed for materials covered by this MSDS.
HAZARDOUS INGREDIENTS IN MULTI PURPOSE NON-DRIP ADHESIVES & PINCHWELD PRIMER
APPROXIMATE PERCENTAGES BY WEIGHT
Ingredients (Chemicals) CAS Number BGA TAB TGA BPP
*1. n-Hexane 110-54-3 25-35 25-35 25-35 20-25
2. Methylcyclopentane 96-37-7 3-5 3-5 3-5 3-5
*3. Methylpentane Mixture 10-20 10-20 10-20 10-15
*4. Toluene 108-88-3 25-30
5. Xylene (Mixed Isomers) 1330-20-7 10-12 10-12 10-12
Physical Hazard-Fire 48-72 48-72 48-72 58-75
Physical Hazard-Pressure Release NOT A HAZARD
Health Hazard-Acute 48-72 48-72 48-72 58-75
Health Hazard-Chronic 25-35 25-35 25-35 20-25
Physical Hazard-Reactivity NOT A HAZARD
SECTION XIII VOLATILE ORGANIC COMPOUND
(V.O.C.) CONTENT ACCORDING TO Enforcement Act (PROPOSITION 65) "No person in the course of
THE FEDERAL EPA doing business shall knowingly and intentionally expose any individ-
BGA, TAB, TGA BPP ual to a chemical known to the state of California to cause cancer,
Percent by Weight 49.8 67.2 birth defects or reproductive toxicity without first giving clear and
Pounds per Gallon: 3.48 4.60 reasonable warning to such individuals of such an exposure".
Grams per Liter: 417 550 The following warnings apply: NONE
Pounds per Container 0.218 0.575 SECTION XV OZONE DEPLETION IN
SECTION XIV CALIFORNIA PROPOSITION 65 THE UPPER ATMOSPHERE
WARNINGS None of the products on this MSDS contains Upper Atmosphere
ozone depleting substances.
According to the California Safe Drinking Water and Toxic
DISCLAIMER: The information contained in this MSDS is believed to be accurate and reliable as of the date indicated. Crest Industries,
Inc. assumes no legal responsibility and makes no representation, warranty or guarantee, expressed or implied, as to the completeness or
accuracy of the information. It is offered solely for your consideration, investigation and verification. The user is ultimately responsible for the
safe use of the material in accordance with applicable federal, state, provincial and local laws and regulations.
|