MATERIAL SAFETY DATA SHEET
SECTION 1. PRODUCT/MANUFACTURER'S IDENTITY
PRODUCT NAME: ATHLETIC KOTE PRODUCT I.D. NUMBER (PIN): N.A.
H.M.I.S.
PRODUCT NUMBER: NA D2B
WHMIS CLASS: HAZARD RATING
HEALTH
1
PRODUCT USE: Wood floor finish DOT HAZARD CLASS: Non-Regulated
FIRE 4 = Extreme
0
COMPANY: 3 = High
REACTIVITY 2 = Moderate
0
HESCO, INC. DOT SHIPPING NAME: 1 = Slight
6633 NORTH MILWAUKEE AVE. MAXIMUM PERSONAL
N.A. 0 = Insignificant
B
NILES, IL 60714-4416 PROTECTION
800-424-9300
EMERGENCY PHONE: A = Goggles B = Goggles & Gloves C = Goggles, Gloves & Apron
ABBREVIATION KEY: N.A. - Not Applicable N.E. = Not Established N.D. = Not Determined
SECTION 2 - HAZARDOUS INGREDIENTS INFORMATION
% PEL TLV LD50 LC50
HAZARDOUS CHEMICAL IDENTITY CAS NO.
Water 7732-18-5 10-30 N.E. N.E. N.D. N.D.
2-Butoxyethanol 111-76-2 1 25ppm 25ppm 450mg/kg 700ppm 7hr
Diethylene glycol monobutyl ether 112-34-5 4 N.E. N.E. 7292mg/kg N.D.
n-Methyl-2-pyrrolidone 872-50-4 3 N.E. N.E. 4200mg/kg N.D.
Acrylic polymer N.A. 40-70 N.E. N.E. N.D. N.D.
Urethane polymer N.A. 10-30 N.E. N.E. N.D. N.D.
This mixture contains 1% 2-Butoxyethanol, 4% Diethylene glycol monobutyl ether and 3% n-Methyl-2-pyrrolidone which are subject to the reporting requirements of Section 313
of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR, Part 372.
SECTION 3 - PHYSICAL DATA
Color: Light Yellow Boiling Point: pH: 7.0 - 8.0
100癈 (212癋) Vapor Pressure: <30 mm of Hg
Odor: Bland Vapor Density (Air=1): <1 1% pH: N.A.
Freezing Point: 0癈 (32癋)
Physical State: Liquid Water/Oil Distribution: N.E. Evaporation Rate (Water=1): N.E. Specific Gravity: 1.03 gm/ml
Weight per Gallon: 8.60 lbs./gal.
Solubility in Water: Miscible Odor Threshold: N.E. VOC Content: 9.5%
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
Flash Point and Method: Autoignition Temperature: N.A. Extinguishing Media:
N.A. Use dry chemical or CO2.
LEL: N.A. UEL: N.A. Special Fire Fighting Procedures:
Flammable Limits: N.A. None.
Hazardous Combustion Products: Unusual Fire and Explosion Hazards:
N.A. None.
SECTION 5 - REACTIVITY DATA
Chemical Stability: Hazardous decomposition of By-Products:
Stable. None known.
Incompatibility (Materials to Avoid): Hazardous Polymerization:
None known. Will not occur.
SECTION 6 - TOXICOLOGICAL PROPERTIES
Routes of Entry: Ingestion. Inhalation. Skin contact. Eye contact. Toxicologically Synergistic Products: None known.
Sensitization: No. Medical Conditions Aggravated by Exposure: None known.
EFFECTS OF OVEREXPOSURE (Acute and/or Chronic):
Carcinogenic Effects: NO carcinogenic effect.
Eyes: Direct contact may cause irritation.
NO mutagenic effect.
Skin: Prolonged or repeated contact may cause irritation. May be absorbed through skin with Mutagenic Effects:
prolonged or repeated contact.
Teratogenic Effects: NO teratogenic effect.
Ingestion: May cause gastrointestinal irritation, nausea, diarrhea.
Reproductive Toxicity: NO reproductive toxicity effect.
Inhalation: Prolonged exposure in poorly ventilated area may cause respiratory irritation.
SECTION 7 - PREVENTATIVE AND CONTROL MEASURES
Respiratory Protection: Ventilation: Local Exhaust: Acceptable Mechanical: Recommended
None normally required with adequate ventilation.
Protective Gloves: Rubber for prolonged exposure. Eye Protection: Safety glasses if splashing is likely.
Protective Clothing and Equipment: As needed to prevent wetting of skin. Work and Hygienic After handling, always wash hands thoroughly with soap
Practices: and water.
Storage Requirements: Store in cool, dry area. Follow good housekeeping
practices. Other Requirements: Keep out of reach of children.
Steps to be Taken if Material Collect and reuse if possible. Flush to sewer with large quantities of water if permitted by regulatory authorities or absorb on inert material (sand,
is Spilled or Released: clay, etc.) and place into container for proper disposal. Do not allow runoff into public waterways.
Waste Disposal: Dispose of as permitted by all federal, provincial, state and local regulatory authorities.
SECTION 8 - EMERGENCY FIRST AID PROCEDURES
FIRST AID - NOTES TO PHYSICIAN:
Eyes: Flush with a large amount of water for 15 minutes holding eyelids open.
Skin: Wash with mild soap and water.
Ingestion: Give 2-3 large glasses of water. Seek medical attention.
Inhalation:Remove to fresh air and rest.
No additional information.
Note to Physician:
SECTION 9 - PREPARATION INFORMATION
Regulatory Affairs Department 847-647-6700
Prepared By: Phone: Date of Preparation: 10/24/2005.