Magna Reducers SafeCoat 747
COATINGS
Magna Coatings is a proud member
MATERIAL SAFETY DATA SHEET
of the Quantum Group of companies.
Section 01: Chemical Product and Company Identification
Manufacturer Magna Coatings Technology Inc.
14601 - 134 Avenue, Edmonton Alberta, T5L 4S9
(780) 451-2211
Prepared by Quantum Technical Services Ltd.
Preparation Date May 01, 2006
Reducer SafeCoat 747
Product Name
Material Use Diluent for SafeCoat 747
24 Hour Emergency Number (613) 996-6666 Canutec
Section 02: Composition/ Information on Ingredients
Hazardous Ingredients/CAS % T.L.V. LD/50 (Route, Species) LC/50
2-Butoxy-ethanol/ 40-60 TWA: 25 ppm 2436 mg/kg (oral, rat) 450ppm/4H rat
111-76-2
1-Methyl-2-pyrrolidone 40-60 not determined 3600 mg/kg (oral, rat) not determined
872-50-4
Section 03: Hazards Identification
Route of Entry Eye Contact, Skin Contact, Inhalation
Eye Contact Severe irritant
Skin Contact Irritant.
Skin Absorption Moderately toxic.
Inhalation (Acute) Irritant.
Ingestion Moderately toxic.
Effects of Chronic Exposure Not determined.
Section 04: First Aid Measures
Eye Contact In case of contact, immediately flush eyes with plenty of water for least
20 minutes. Consult a physician immediately.
Skin Contact In case of contact, immediately flush skin with plenty of soap and water.
Remove contaminated clothing. Wash clothing before reuse.
Inhalation If inhaled, remove to fresh air. If not breathing, give artificial respiration.
If breathing is difficult, give oxygen. Obtain medical attention.
Ingestion If ingested, consult a physician immediately. Do not induce vomiting.
Do not give liquids.
Additional Information Not available.
Section 05: Fire Fighting Measures
Flash Point Approximately 75C
Auto Ignition Temperature (C) Not determined
Upper Explosive Limit(% Vol.) 10.6
Lower Explosive Limit(% Vol.) 1.1
Extinguishing Media Water, Carbon Dioxide, Dry chemical, Foam.
Hazardous Combustion Products By fire: protect against potentially toxic and irritating fumes.
Sensitivity to Mechanical Impact Not Available
Sensitivity to Static Discharge Not Available
Special Fire Fighting Procedures Firefighter should be equipped with self-contained breathing apparatus to
protect against potentially toxic and irritating fumes.
Page 1
Reducers SafeCoat 747
Section 06: Accidental Release Measures
Leak/Spill Dike area to prevent spreading. Spills should be taken up with suitable
absorbent and placed in containers. Spill area can be washed with water.
Collect wash water for approved disposal. Utilize recommended protective
clothing. Eliminate all sources of ignition.
Section 07: Handling and Storage
Handling Procedures Avoid skin and eye contact. A void breathing dust. Remove
contaminated clothing before reuse. Maintain a good personal hygiene.
Storage Needs Store in a cool well ventilated location. Store in tightly sealed container and
keep away from all sources of ignition. Keep container closed when not in use.
Section 08: Exposure Controls / Personal Protection
Protective equipment
Eye/Type Liquid chemical goggles. Contact lenses should not be worn.
Respiratory/Type Wear MSHA/NIOSH approved respirator when ventilation is inadequate.
Gloves/Type Rubber or plastic impervious gloves. Wash thoroughly before handling any
food.
Clothing/Type Wear adequate protective clothes.
Footwear/Type Not applicable.
Other/Type Eyewash fountain. Emergency shower should be in close proximity.
Ventilation Requirements Provide exhaust ventilation to keep airborne vapour concentration below
threshold limit value.
Section 09: Physical and Chemical Properties
Physical State Liquid
Odor Slight
Specific Gravity .99
Odor Threshold(ppm) Not applicable
Vapor Pressure (mm Hg) Not available
Vapor Density (Air=1) Not available
Evaporation Rate Not available
Boiling Point Approx. 175 C
pH Not available
Solubility in water Partial
Coefficient of water/oil
distribution Not determined
Freezing Point (deg C) Not determined
Page 2
Reducers SafeCoat 747
Section 10: Stability and Reactivity
Incompatibility None known
Reactivity Conditions Highly reactive with oxidizing and reducing agents. Slightly reactive to
organic acids and alkalis.
Hazardous products of
Decomposition Not available.
Section 11: Toxicological Information
Irritancy of material Irritant
Sensitizing Capability of
Material Not available
Carcinogenity of Material Not available
Teratogenicity Not available
Mutanagenity Not available
Synergistic Materials Not available
Section 12: Ecological Information
Fish Toxicity Not available
Biodegradability Not available
Section 13: Disposal Considerations
Waste Disposal In accordance with municipal, provincial and federal regulations.
Empty containers must be handled with care due to protect residue.
Section 14: Transport Information
T.D.G. Classification Ethylene glycol monobutyl ether, Class 6.1, UN 2369, Packing Group III
Section 15: Regulatory Information
WHMIS Classification B-3, D-2b, D-1a.
This product has been classified in accordance with the hazard criteria of the
controlled products regulations and the MSDS contains all the information
required by the controlled products regulations.
Section 16: Other Information
Note This information is furnished without warranty, expressed or implied,
except that it is accurate to the best knowledge of Magna Coatings
Technology Inc. The data on this sheet relates only to the specific
material designated herein. Magna Coatings Technology Inc. assumes
no legal responsibility for use or reliance upon these data.
Contact us by telephone, fax or email:
Toll Free: 1-877- 454-9166
Magna Telephone: 1-780-451-2211
Facsimile: 1-780-451-8011
COATINGS
Email: info@magnacoatings.com
Magna Coatings is a proud member
of the Quantum Group of companies.
Page 3
|