Material Safety Data Sheet
Revision Date: 12/16/2004 Issue date: 12/17/2004
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product name: Depend(R) No-Mix Activator Item No. : 8220251
Product type: Activator Region: United States
Company address: Contact Information:
Henkel Corporation Telephone: 860.571.5100
1001 Trout Brook Crossing Emergency telephone: 860.571.5100
Rocky Hill, Connecticut 06067 Internet: www.loctite.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components % ACGIH TLV OSHA PEL OTHER
n-Heptane 30-60 400 ppm TWA 2000 mg/m?TWA None
142-82-5 500 ppm STEL 500 ppm TWA
Isobutane 10-30 1000 ppm TWA listed None None
75-28-5 under aliphatic
hydrocarbon gases alkane
C1-C4
Aldehyde-amine condensate 10-30 None None None
34562-31-7
Isopropyl alcohol 10-30 200 ppm TWA 400 ppm TWA None
67-63-0 400 ppm STEL 980 mg/m?TWA
Substituted dihydropyridines 1-5 None None None
UNKNOWN
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
HMIS:
Physical state: Liquid Aerosol HEALTH: 1*
Color: Amber FLAMMABILITY: 4
Odor: Aliphatic PHYSICAL HAZARD: 0
Personal Protection: See Section 8
WARNING: FLAMMABLE LIQUID AND VAPOR.
CAUSES EYE AND SKIN IRRITATION.
MAY CAUSE RESPIRATORY TRACT IRRITATION.
MAY BE HARMFUL IF SWALLOWED.
Relevant routes of exposure: Skin, Inhalation, Eyes, Ingestion
Potential Health Effects
Inhalation: May cause respiratory tract irritation. Headache, dizziness, nausea, and loss of coordination are
indications of excessive exposure to vapors or spray mists.
Skin contact: Irritating to skin. Solvent action can dry and defat the skin, causing the skin to crack, leading to
dermatitis.
Eye contact: Vapors may irritate eyes. Contact with eyes will cause irritation.
Ingestion: Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspirated material can
enter the lungs and result in pneumonitis.
Item No. : 8220251 Product name: Depend(R) No-Mix Activator
1 of 5
Existing conditions aggravated by Eye, skin, and respiratory disorders. Heart disease.
exposure:
See Section 11 for additional toxicological information.
4. FIRST AID MEASURES
Inhalation: Remove to fresh air. If discomfort persists seek medical attention.
Skin contact: Wash with soap and water.
Eye contact: Flush with copious amounts of water, preferably, lukewarm water for at least 15 minutes, holding
eyelids open all the time.
Ingestion: If conscious, drink plenty of water. Do not induce vomiting. Keep individual calm. Obtain medical
attention.
5. FIRE-FIGHTING MEASURES
Flash point: -3.9癈 (25癋) (Base only) (estimated)
Flashback: This product exhibits flashback when tested for flame extension.
Flame Projection: Greater than 19 cms (48 inches)
Autoignition temperature: Not available
Flammable/Explosive limits-lower %: Not available
Flammable/Explosive limits-upper %: Not available
Extinguishing media: Foam, dry chemical or carbon dioxide.
Special fire fighting procedures: None
Unusual fire or explosion hazards: Vapors may accumulate in low or confined areas, travel considerable distance to source of ignition,
and flash back.
Hazardous combustion products: Oxides of carbon. Oxides of nitrogen. Irritating organic vapors.
6. ACCIDENTAL RELEASE MEASURES
Environmental precautions: Prevent product from entering drains or open waters.
Clean-up methods: Remove all ignition sources. Ensure adequate ventilation. Soak up with inert absorbent. Store in a
closed container until ready for disposal.
7. HANDLING AND STORAGE
Handling: Avoid contact with eyes, skin and clothing. Avoid breathing vapor and mist. Wash thoroughly after
handling. During use and until all vapors are gone: Keep area ventilated - do not smoke; extinguish all
flames, pilot lights, and heaters; turn off stoves, electrical tools and appliances, and any other sources
of ignition.
Storage: Store away from heat, sparks, flames, or other sources of ignition. For safe storage, store at or below
38癈 (100癋).
Incompatible products: Refer to Section 10.
For information on product shelf life contact Henkel Customer Service at (800) 243-4874.
Item No. : 8220251 Product name: Depend(R) No-Mix Activator
2 of 5
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering controls: Use local ventilation if general ventilation is insufficient to maintain vapor concentration below
established exposure limits.
Respiratory protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s).
Skin protection: Chemical resistant, impermeable gloves.
Eye/face protection: Safety goggles or safety glasses with side shields.
See Section 2 for exposure limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Liquid Aerosol
Color: Amber
Odor: Aliphatic
Vapor pressure: 35 mmHg at 20 篊 (68 癋) (Base only)
pH: Not applicable
Boiling point/range: 50癈 (122癋) Approximately 50癈 (122癋) (Base only)
Melting point/range: Not available
Specific gravity: 0.7694 Base only
Vapor density: Not available
Evaporation rate: Not available
Solubility in water: Immiscible
Partition coefficient (n-octanol/water): Not available
VOC content: 83.84%; 645.1 grams/liter (EPA Method 24)
10. STABILITY AND REACTIVITY
Stability: Stable.
Hazardous polymerization: Will not occur.
Hazardous decomposition products: Oxides of carbon. Oxides of nitrogen. Irritating organic vapors.
Incompatability: Strong oxidizers. Strong acids and strong bases. Acid chlorides. Acid anhydrides. Alkali metals
Ammonia Amines.
Conditions to avoid: See "Handling and Storage" (Section 7) and "Incompatabilty" (Section 10).
11. TOXICOLOGICAL INFORMATION
Carcinogen Status
Hazardous components NTP Carcinogen IARC Carcinogen OSHA Carcinogen
n-Heptane No No No
142-82-5
Isobutane No No No
75-28-5
Aldehyde-amine condensate No No No
34562-31-7
Isopropyl alcohol No No No
67-63-0
Substituted dihydropyridines No No No
UNKNOWN
Literature Referenced Target Organ & Other Health Effects
Item No. : 8220251 Product name: Depend(R) No-Mix Activator
3 of 5
Hazardous components Health Effects/Target Organs
n-Heptane Central nervous system, Irritant
142-82-5
Isobutane Cardiac, Central nervous system, Lung
75-28-5
Aldehyde-amine condensate No data
34562-31-7
Isopropyl alcohol Allergen, Blood, Central nervous system, Irritant, Kidney, Liver, Brain, Spleen
67-63-0
Substituted dihydropyridines No data
UNKNOWN
12. ECOLOGICAL INFORMATION
Ecological information: Not available
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal: Dispose of according to Federal, State and local governmental regulations.
EPA hazardous waste number: D001: Ignitable.
14. TRANSPORT INFORMATION
U.S. Department of Transportation Ground (49 CFR):
Proper shipping name: Aerosols, flammable
Hazard class or division: 2.1
Identification number: UN 1950
Packing group: None
Exceptions: Consumer Commodity ORM-D (Not more than 1 Liter)
International Air Transportation (ICAO/IATA):
Proper shipping name: Aerosols, flammable, n.o.s
Hazard class or division: 2.1
Identification number: UN 1950
Packing group: None
Exceptions: May Qualify as Consumer Commodity ID8000 (Not more than 500 ml)
WaterTransportation (IMO/IMDG):
Proper shipping name: Aerosols
Hazard class or division: 2
Identification number: UN1950
Packing group: None
Exceptions: Limited quantity (Not more than 1 L)
Marine pollutant: None
Item No. : 8220251 Product name: Depend(R) No-Mix Activator
4 of 5
15. REGULATORY INFORMATION
United States Regulatory Information
TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory.
TSCA 12 (b) Export Notification: n-Heptane (142-82-5).
CERCLA/SARA Section 302 EHS: None.
CERCLA/SARA Section 311/312: Immediate Health Hazard, Delayed Health Hazard, Fire
CERCLA/SARA 313: None above reporting de minimus.
California Proposition 65: This product contains a chemical known to the State of California to cause cancer and birth defects or
other reproductive harm.
Canada Regulatory Information
CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Domestic Substances List.
WHMIS hazard class: A, B.2, D.2.B
16. OTHER INFORMATION
This material safety data sheet contains changes from the previous version in sections: Expanded chemical information in Section 2 and
related sections.
Prepared by: Kyra Kozak Woods, Health and Regulatory Affairs Specialist
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation
does not assume responsibility for any results obtained by persons over whose methods Henkel Corporation has no control. It is the
user's responsibility to determine the suitability of Henkel's products or any production methods mentioned herein for a particular
purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be
involved in the handling and use of any of Henkel Corporation's products. In light of the foregoing, Henkel Corporation specifically
disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale
or use of Henkel Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of
any kind, including lost profits.
Item No. : 8220251 Product name: Depend(R) No-Mix Activator
5 of 5
Material Safety Data Sheet
Revision Date: 03/14/2005 Issue date: 03/14/2005
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product name: Depend(R) No-Mix Adhesive Item No. : 7500206
Product type: Tough Acrylic Adhesive Region: United States
Company address: Contact Information:
Henkel Corporation Telephone: 860.571.5100
1001 Trout Brook Crossing Emergency telephone: 860.571.5100
Rocky Hill, Connecticut 06067 Internet: www.loctite.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components % ACGIH TLV OSHA PEL OTHER
Tetrahydrofurfuryl methacrylate 30-60 None None None
2455-24-5
Chlorosulphonated polyethylene 10-30 None None None
68037-39-8
Methacrylic acid 5-10 20 ppm TWA None None
79-41-4
Alkyl methacrylate 5-10 None None None
688-84-6
1,3-Butylene glycol dimethacrylate 1-5 None None None
1189-08-8
Talc 0.1-1 2 mg/m?TWA respirable = 20 mppcf TWA 50 ppm
14807-96-6 fraction, particulate matter
containing no asbestos
and < 1% crystalline silica
Carbon tetrachloride 0.1-1 10 ppm STEL 10 ppm TWA None
56-23-5 5 ppm TWA 25 ppm Ceiling
(skin)
Under the Clean Air Act this product is exempted from labeling as an ozone depleting chemical (40 CFR 82.106(b)(1)).
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
HMIS:
Physical state: Liquid HEALTH: 2*
Color: Amber FLAMMABILITY: 2
Odor: Sharp, Irritating PHYSICAL HAZARD: 1
Personal Protection: See Section 8
WARNING: COMBUSTIBLE LIQUID
CAUSES EYE IRRITATION.
MAY CAUSE SKIN IRRITATION.
MAY CAUSE ALLERGIC SKIN REACTION.
MAY CAUSE RESPIRATORY TRACT IRRITATION.
MAY BE HARMFUL IF SWALLOWED.
Relevant routes of exposure: Skin, Inhalation, Eyes
Item No. : 7500206 Product name: Depend(R) No-Mix Adhesive
1 of 5
Potential Health Effects
Inhalation: May cause irritation to nose and throat.
Skin contact: May cause skin irritation. May cause allergic skin reaction.
Eye contact: Vapors may irritate eyes. Contact with eyes will cause irritation.
Ingestion: May be harmful if swallowed. May cause gastrointestinal tract irritation if swallowed.
Existing conditions aggravated by Eye, skin, and respiratory disorders.
exposure:
See Section 11 for additional toxicological information.
4. FIRST AID MEASURES
Inhalation: Remove to fresh air. If symptoms develop and persist, get medical attention.
Skin contact: Wash with soap and water. Remove contaminated clothing and shoes. Wash clothing before reuse.
Get medical attention if symptoms occur.
Eye contact: Flush with copious amounts of water, preferably, lukewarm water for at least 15 minutes, holding
eyelids open all the time. Get medical attention.
Ingestion: Do not induce vomiting. Keep individual calm. Obtain medical attention.
5. FIRE-FIGHTING MEASURES
Flash point: 87癈 (188癋) Tagliabue closed cup
Autoignition temperature: Not available
Flammable/Explosive limits-lower %: Not available
Flammable/Explosive limits-upper %: Not available
Extinguishing media: Foam, dry chemical or carbon dioxide.
Special fire fighting procedures: None
Unusual fire or explosion hazards: None
Hazardous combustion products: Oxides of carbon. Oxides of nitrogen. Toxic chlorides. Irritating organic vapors.
6. ACCIDENTAL RELEASE MEASURES
Environmental precautions: Prevent product from entering drains or open waters.
Clean-up methods: Remove all ignition sources. Ensure adequate ventilation. Soak up with inert absorbent. Store in a
partly filled, closed container until disposal.
Item No. : 7500206 Product name: Depend(R) No-Mix Adhesive
2 of 5
7. HANDLING AND STORAGE
Handling: Keep away from heat, spark and flame. Do not breathe mist or vapors. Avoid contact with eyes, skin
and clothing.
Storage: For safe storage, store at or below 38癈 (100癋). Store away from heat, sparks, flames, or other
sources of ignition.
Incompatible products: Refer to Section 10.
For information on product shelf life contact Henkel Customer Service at (800) 243-4874.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering controls: Use local exhaust ventilation to maintain airborne concentrations below established exposure limits.
Respiratory protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s).
Skin protection: Use impermeable gloves and protective clothing as necessary to prevent skin contact.
Eye/face protection: Safety goggles or safety glasses with side shields.
See Section 2 for exposure limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Liquid
Color: Amber
Odor: Sharp, Irritating
Vapor pressure: Less than 10 mm Hg at 27篊 (80篎)
pH: Not applicable
Boiling point/range: Greater than 149篊 (300篎)
Melting point/range: Not available
Specific gravity: 1.16
Vapor density: Not available
Evaporation rate: Not available
Solubility in water: Slight
Partition coefficient (n-octanol/water): Not available
VOC content: 68.5%; 754 grams/liter (EPA Method 24)
10. STABILITY AND REACTIVITY
Stability: Stable.
Hazardous polymerization: Will not occur.
Hazardous decomposition products: Oxides of carbon. Oxides of sulfur. Toxic chlorides. Irritating organic vapors.
Incompatability: Strong oxidizers.
Conditions to avoid: See "Handling and Storage" (Section 7) and "Incompatabilty" (Section 10).
11. TOXICOLOGICAL INFORMATION
Product toxicity data: Acute oral LD50 greater than 10, 000 mg/kg (rat). Acute LD50 (oral) :Greater than 4000 (rat).
Carcinogen Status
Item No. : 7500206 Product name: Depend(R) No-Mix Adhesive
3 of 5
Hazardous components NTP Carcinogen IARC Carcinogen OSHA Carcinogen
Tetrahydrofurfuryl methacrylate No No No
2455-24-5
Chlorosulphonated polyethylene No No No
68037-39-8
Methacrylic acid No No No
79-41-4
Alkyl methacrylate No No No
688-84-6
1,3-Butylene glycol dimethacrylate No No No
1189-08-8
Talc No No No
14807-96-6
Carbon tetrachloride Suspect Carcinogen Group 2B Yes
56-23-5
Literature Referenced Target Organ & Other Health Effects
Hazardous components Health Effects/Target Organs
Tetrahydrofurfuryl methacrylate Allergen, Irritant
2455-24-5
Chlorosulphonated polyethylene No Target Organs
68037-39-8
Methacrylic acid Allergen, Corrosive, Irritant
79-41-4
Alkyl methacrylate Allergen, Irritant
688-84-6
1,3-Butylene glycol dimethacrylate Allergen, Irritant
1189-08-8
Talc Some evidence of carcinogenicity, Lung, Irritant
14807-96-6
Carbon tetrachloride Cardiac, Central nervous system, Irritant, Kidney, Liver, Some evidence of carcinogenicity
56-23-5
12. ECOLOGICAL INFORMATION
Ecological information: Not available
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal: Dispose of according to Federal, State and local governmental regulations.
EPA hazardous waste number: Waste must be tested to determine the applicable EPA hazardous waste numbers. D019: Carbon
tetrachloride.
14. TRANSPORT INFORMATION
The shipping classifications in this section are for non-bulk packaging only (unless otherwise specified). Shipping classification may be
different for bulk packaging.
U.S. Department of Transportation Ground (49 CFR):
Proper shipping name: Unrestricted
Hazard class or division: None
Identification number: None
Packing group: None
International Air Transportation (ICAO/IATA):
Proper shipping name: Unrestricted
Hazard class or division: None
Identification number: None
Packing group: None
WaterTransportation (IMO/IMDG):
Proper shipping name: Unrestricted
Hazard class or division: None
Identification number: None
Item No. : 7500206 Product name: Depend(R) No-Mix Adhesive
4 of 5
Packing group: None
Marine pollutant: None
15. REGULATORY INFORMATION
United States Regulatory Information
TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory.
TSCA 12 (b) Export Notification: 4-Methoxyphenol (150-76-5).
CERCLA/SARA Section 302 EHS: None above reporting de minimus.
CERCLA/SARA Section 311/312: Immediate Health Hazard, Delayed Health Hazard, Fire
CERCLA/SARA 313: This product contains the following toxic chemicals subject to the reporting requirements of section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372). Carbon
tetrachloride (CAS# 56-23-5).
California Proposition 65: This product contains a chemical known to the State of California to cause cancer and birth defects or
other reproductive harm.
Canada Regulatory Information
CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Domestic Substances List.
WHMIS hazard class: B.3, D.2.A, D.2.B
16. OTHER INFORMATION
This material safety data sheet contains changes from the previous version in sections: This material safety data sheet contains changes
from the previous version in section(s): 2
Prepared by: Kyra Kozak Woods, Health and Regulatory Affairs Specialist
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation
does not assume responsibility for any results obtained by persons over whose methods Henkel Corporation has no control. It is the
user's responsibility to determine the suitability of Henkel's products or any production methods mentioned herein for a particular
purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be
involved in the handling and use of any of Henkel Corporation's products. In light of the foregoing, Henkel Corporation specifically
disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale
or use of Henkel Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of
any kind, including lost profits.
Item No. : 7500206 Product name: Depend(R) No-Mix Adhesive
5 of 5
|