Material Safety Data Sheet
(MSDS-TRM)
PRODUCT IDENTIFICATION
KOS-APRV-001 TRM鈩? Motor Fuel Modules
Product Name
Truly Reloadable Motors, Reloadable Model/Hobby Rocket Motor Fuel Modules,
Trade Names and Synonyms
Model/Hobby Rocket Motor Propellant Grains
Kosdon Enterprises
Manufacturer/Distributor
316 Carol Drive
Ventura, CA 93003
Tel: 805-642-1559
Transportation Emergency 800-255-3924 (24 hrs -- CHEM 鈥? TEL)
HAZARDOUS COMPONENTS
Material or Component CAS No. TLV (ACGIH) PEL (OSHA)
N/A NE NE
Ammonium perchlorate/Binder*
N/A = Not assigned NE = Not established
*The specific ingredients of this product have been classified as a trade secret. Inquiries concerning toxicity or hazardous nature
of this product should be directed to Kosdon Enterprises at 805-642-1559. All inquiries must adhere to the provisions set out in 29
CFR 1910.1200.
PHYSICAL DATA
Paper tubes containing solid, rubberized compound. Slight rubber odor.
HAZARDOUS REACTIVITY
Stable compound
Instability
Acids and alkalis
Incompatibility
Burning produces smoke and gases. Gases produced may contain carbon monoxide
Hazardous decomposition
and hydrogen chloride.
Polymerization will not occur
Polymerization
MSDS-TRM PAGE 1 Issued 07/26/94
Reviewed 2/22/06
FIRE AND EXPLOSION DATA
Not applicable
Flashpoint
鈾? Small fires: Dry chemical, sand, earth, water spray, or regular foam
Extinguishing media
鈾? Large fires: Water spray, fog, or regular foam
鈾? Move container from fire area if you can do it without risk.
Special fire fighting procedures
鈾? Stay upwind; keep out of low areas.
鈾? Keep unnecessary people away; isolate hazard area and deny entry.
鈾? Positive pressure SCBA and structural firefighters鈥? protective clothing will provide
limited protection.
鈾? Flammable/combustible material; may be ignited by heat, sparks, or flames.
Unusual fire and explosion hazards
鈾? May burn rapidly with flare-burning effect.
鈾? Fire may produce irritating or poisonous gases.
鈾? Runoff from fire control or dilution water may cause pollution.
鈾? Consult the 2000 Emergency Response Guidebook, Guide 133 for further details.
HEALTH HAZARDS
General
TRM鈩? Motor Fuel Modules do not present health hazards in normal handling and use;
however, the products are Class 4.1 Flammable Solids, and ignition may cause severe
burns or injury due to inhalation of irritating or hot gases. All flammable solids are
dangerous and must be handled carefully and used following approved safety
procedures under the direction of competent, experienced persons in accordance with
all applicable federal, state, and local laws, regulations, and ordinances.
Products of combustion are skin, eye, and respiratory tract irritants.
Contact may cause burns to skin and eyes.
None of the components of TRM鈩? Motor Fuel Modules are listed as a carcinogen by
Carcinogenicity
NTP, IARC, or OSHA.
FIRST AID
Not a likely route of exposure. If inhaled in enclosed spaces, combustion products can
Inhalation
cause severe injury.
鈾? Not a likely route of exposure; however, if contact occurs, immediately flush skin or
Eye and skin contact
eyes with running water for at least 15 minutes.
鈾? Removal of solidified molten material from skin requires medical assistance.
鈾? Remove and isolate contaminated clothing and shoes at the site.
Not a likely route of exposure.
Ingestion
Seek prompt medical attention.
Injury from combustion
SPILL OR LEAK PROCEDURES
鈾? Shut off ignition sources; no flares, smoking, or flames in hazard area.
Spill/leak response
鈾? Do not touch or walk through spilled material.
鈾? Small spills: With clean shovel, place material into clean, dry container and cover
loosely. Move containers from spill area.
鈾? Large spills: Wet down with water and dike for later disposal.
Dispose of in compliance with federal regulations under the authority of the Resource
Waste disposal
Conservation and Recovery Act (40 CFR Parts 260-271).
MSDS-TRM PAGE 2 Issued 07/26/94
Reviewed 2/22/06
SPECIAL PROTECTION INFORMATION
Use out-of-doors only
Ventilation
None
Respiratory
Safety glasses or goggles
Eye
None
Gloves
None
Other
SPECIAL PRECAUTIONS
Keep away from ignition sources, friction, heat, sparks, and fire. Do not consume food, drink, or tobacco in areas where they may
become contaminated with these materials.
STORAGE CONDITIONS
Store in a cool, dry locker or cabinet.
SHIPPING INFORMATION
Flammable solid, organic, n.o.s. (ammonium perchlorate mixture)
Proper shipping name
4.1
Hazard class
UN1325
UN Number
None (modules 鈮?1000 grams, except air freight)
DOT Label
DOT Label & Placard
Flammable solid (modules >1000 grams and air freight (any size)
DOT Placard Flammable solids or Dangerous (when required)
The information contained in this Material Safety Data Sheet is based upon available data and believed to be correct;
however, as such has been obtained from various sources, including the manufacturer and independent laboratories, it is
given without warranty or representation that it is complete, accurate, and can be relied upon. OWEN COMPLIANCE SERVICES,
INC. has not attempted to conceal in any manner the deleterious aspects of the product listed herein, but makes no
warranty as to such. Further, OWEN COMPLIANCE SERVICES, INC. cannot anticipate nor control the many situations in which
the product or this information may be used; there is no guarantee that the health and safety precautions suggested will be
proper under all conditions. It is the sole responsibility of each user of the product to determine and comply with the
requirements of all applicable laws and regulations regarding its use. This information is given solely for the purposes of
safety to persons and property. Any other use of this information is expressly prohibited.
David W. Boston, President
For further information contact:
OWEN COMPLIANCE SERVICES, INC.
12001 County Road 1000
P.O. Box 765
Godley, TX 76044
Telephone number: 817-551-0660
FAX number: 817-396-4584
David W. Boston
MSDS prepared by:
Original publication date: 07/26/94
Review date: 2/22/06
12/03/03
MSDS-TRM PAGE 3 Issued 07/26/94
Reviewed 2/22/06
|