Material Safety Data Sheet
(MSDS-TNT)
PRODUCT IDENTIFICATION
TNT
Product Name
2,4,6 Trinitrotoluene
Trade Names and Synonyms
Various
Manufacturer/Distributor
Transportation Emergency 800-255-3924 (24 hrs -- CHEM 鈥? TEL)
PREVENTION OF ACCIDENTS IN THE USE OF EXPLOSIVES
The prevention of accidents in the use of explosives is a result of careful planning and observance of the
best known practices. The explosives user must remember that he is dealing with a powerful force and
that various devices and methods have been developed to assist him in directing this force. He should
realize that this force, if misdirected, may either kill or injure both him and his fellow workers.
WARNING
All explosives are dangerous and must be carefully handled and used following approved
safety procedures either by or under the direction of competent, experienced persons in accordance
with all applicable federal, state, and local laws, regulations, or ordinances. If you have any questions or
doubts as to how to use any explosive product, DO NOT USE IT before consulting with your
supervisor, or the manufacturer, if you do not have a supervisor. If your supervisor has any questions or
doubts, he should consult the manufacturer before use.
MSDS-TNT PAGE 1 Issued 04/30/97
Reviewed 2/22/06
HAZARDOUS COMPONENTS
Material or Component CAS No. TLV PEL
3 3
38082-89-2 1.5 MG/M .5 MG/M
TNT
(Trinitrotoluene)
N/A = Not assigned NE = Not established
PHYSICAL DATA
464掳 F
Boiling Point
.057 MPa @ 179掳 F
Vapor Pressure
N/A
Vapor Density
Insoluble
Solubility in Water
1.5 - 1.6
Specific Gravity
176掳F
Melting Point
N/A
Evaporation Rate
Yellow Flakes, with bitter almond odor.
Appearance and Odor
HAZARDOUS REACTIVITY
Stable
Instability
No data applicable
Incompatibility
Nitrous Oxide
Hazardous decomposition
Polymerization will not occur
Polymerization
FIRE AND EXPLOSION DATA
Not applicable
Flashpoint
None
Extinguishing media
Special fire fighting procedures ALL EXPLOSIVES: DO NOT FIGHT EXPLOSIVES FIRES. Try to keep
fire from reaching explosives. Isolate area. Guard against intruders.
Division 1.1 Explosives: Evacuate the area for 5000 feet (1 mile). Consult the 2000
Emergency Response Guidebook, Guide 112 for further details.
Will detonate if suitably primed by heat or flame.
Unusual fire and explosion hazards
MSDS-TNT PAGE 2 Issued 04/30/97
Reviewed 2/22/06
HEALTH HAZARDS
General
TNT is a Division 1.1 explosive, and detonation may cause severe physical injury,
including death. All explosives are dangerous and must be handled carefully and used
following approved safety procedures under the direction of competent, experienced
persons in accordance with all applicable federal, state, and local laws, regulations, and
ordinances.
Inhalation of explosives powders may cause nervous system irregularities including
headaches and dizziness.
Nitrogen oxides generated during use are skin, eye, and respiratory tract irritants.
None of the components of TNT are listed as a carcinogen by NTP, IARC, or OSHA.
Carcinogenicity
FIRST AID
If detonation fumes are inhaled, remove to fresh air. If not breathing, give artificial
Inhalation
respiration, preferably mouth to mouth. If breathing is difficult, give oxygen and call a
physician.
Flush eyes with water. Wash skin with soap and water.
Eye and skin contact
Induce vomiting immediately by giving two glasses of water and sticking finger down
Ingestion
throat.
Seek prompt medical attention.
Injury from detonation
SPILL OR LEAK PROCEDURES
Review fire and explosion hazards before proceeding with clean up. Remove all ignition
Spill/leak response
sources. Wear protective equipment during clean up. Mop up with water.
Dispose of in compliance with federal regulations under the authority of the Resource
Waste disposal
Conservation and Recovery Act (40 CFR Parts 260-271).
SPECIAL PROTECTION INFORMATION
General ventilation with local exhaust in operation area.
Ventilation
Wear fitted NIOSH approved respirator, avoid dusting by keeping wet when possible .
Respiratory
Chemical goggles.
Eye
Cotton or leather gloves
Gloves
Flame proof coveralls and conductive boots.
Other
SPECIAL PRECAUTIONS
Refer to manufacturer鈥檚 instructions and warnings supplied with product.
STORAGE CONDITIONS
Store in accordance with the requirements of Subpart K, ATF: Explosives Law and Regulations (27 CFR 55.201-55.219).
MSDS-TNT PAGE 3 Issued 04/30/97
Reviewed 2/22/06
SHIPPING INFORMATION
TNT
Proper shipping name
1.1D
Hazard class
UN0209 (1.1D)
UN Number
DOT Label EXPLOSIVE 1.1D
DOT Label & Placard
DOT Placard EXPLOSIVES 1.1
The information contained in this Material Safety Data Sheet is based upon available data and believed to be correct;
however, as such has been obtained from various sources, including the manufacturer and independent laboratories, it is
given without warranty or representation that it is complete, accurate, and can be relied upon. OWEN COMPLIANCE SERVICES,
INC. has not attempted to conceal in any manner the deleterious aspects of the product listed herein, but makes no
warranty as to such. Further, OWEN COMPLIANCE SERVICES, INC. cannot anticipate nor control the many situations in which
the product or this information may be used; there is no guarantee that the health and safety precautions suggested will be
proper under all conditions. It is the sole responsibility of each user of the product to determine and comply with the
requirements of all applicable laws and regulations regarding its use. This information is given solely for the purposes of
safety to persons and property. Any other use of this information is expressly prohibited.
David W. Boston, President
For further information contact:
OWEN COMPLIANCE SERVICES, INC.
12001 County Road 1000
P.O. Box 765
Godley, TX 76044
Telephone number: 817-551-0660
FAX number: 817-396-4584
Johnny R. Rodriguez, Compliance Specialist
MSDS prepared by:
Original publication date: 04/30/97
Review date: 2/22/06
12/03/03
MSDS-TNT PAGE 4 Issued 04/30/97
Reviewed 2/22/06
|