#168
MATERIAL SAFETY DATA SHEET
NFPA RATING: Health = 3 Flammability = 0 Reactivity = 0
HMIS RATING: Health = 3 Flammability = 1 Reactivity = 0
SECTION I -- IDENTITY AND MANUFACTURER'S INFORMATION (1102A)
Manufacturer's Name: HILLYARD INDUSTRIES Product Name: VINDICATOR+
Address: 302 North Fourth Street Date Prepared: January 18, 2006
St. Joseph, MO 64501 Prepared by: Regulatory Affairs Department
Emergency Telephone No.: (800) 424-9300 (Only in the event of chemical emergency involving a spill, leak, fire, exposure or
accident involving chemicals.) Other information calls: (816) 233-1321 (Ext. 8285)
http://www.hillyard.com
SECTION II -- INGREDIENTS/IDENTITY INFORMATION
Components
(Specific Chemical Identity: ACGIH OTHER LIMITS
Common Name(s) CAS# OSHA PEL TLV RECOMMENDED %
Didecyl dimethyl ammonium chloride 7173-51-5 not established N/A N/A 10.14
n-Alkyl (C14 50%, C12 40%, C16 10%) 8001-54-5 not established N/A N/A 6.76
dimethyl benzyl ammonium chloride
Ethylenediamine tetraacetic acid 60-00-4 not established N/A N/A 1-5
Ethanol 64-17-5 1000ppm 1000ppm N/A 1-4
Deionized water 7732-18-5 none N/A N/A ---
Nonionic surfactant 68439-46-3 Not established N/A N/A ---
SECTION III -- PHYSICAL / CHEMICAL CHARACTERISTICS
204掳F Specific Gravity (H2O = 1): 25掳C = 0.99 & 39掳C = 0.99
Boiling Point:
Vapor Pressure (mm Hg.): 18.17 77.59
Percent Volatile by Volume (%):
0.7 Evaporation Rate (ethyl ether = 1): slower than 1
Vapor Density (AIR = 1):
complete Appearance and Odor: clear, yellow liquid; fresh odor
Solubility in Water:
pH of concentrate: 7.2-8.2
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
Flash point: >200潞F (Tag Closed Cup) Flammable Limits: LEL = Not applicable UEL = Not applicable
Extinguishing Media: Foam, Alcohol foam, carbon dioxide, dry chemical, water
Special Fire Fighting Procedures: Must wear NIOSH/MSHA approved self-contained breathing apparatus and protective
clothing. Cool fire鈥揺xposed containers with water spray.
Unusual Fire and Explosion Hazards: Products of combustion are toxic.
SECTION V -- PHYSICAL HAZARDS
Stable N/A
Stability: Conditions to Avoid:
Incompatibility (Materials to Avoid): Strong oxidizing and reducing agents.
Hazardous Decomposition Products or Byproducts: Thermal decomposition may produce toxic vapors/fumes of
hydrogen chloride, amines, and other organic materials, and oxides of carbon and nitrogen.
will not occur Conditions to Avoid: None known by Hillyard
Hazardous Polymerization:
SECTION VI -- HEALTH HAZARD DATA
Routes of entry: Inhalation? yes Skin? yes Eye? Yes Ingestion? yes
HEALTH HAZARDS (1. Acute and 2. Chronic)
1. Causes irreversible eye damage and skin burns. Harmful if swallowed. Do not get in eyes, on skin or on clothing. When
handling product, protect eyes by wearing goggles or face shield and protect skin by wearing rubber gloves. Inhalation of
fine fog mist can cause irritation of mucous membranes. Fine fog mist application is not recommended. LD50 Rat = 1650
mg/kg; dermal LD50 (rabbit) 1870 mg./kg.; eye irritation (rabbit) = Severe irritant; skin irritation (rabbit) = severe irritant on
similar alkaline formulation containing 10.8% active quat. 2. None known to Hillyard.
Chemical listed as Carcinogen or Potential Carcinogen:
National Toxicology Program = No No OSHA = No
I.A.R.C. Monographs =
Signs and Symptoms of Exposure Causes irreversible eye damage. Do not get in eyes or on clothing. Wear protective
eyewear (goggles, face shield, or safety glasses). Avoid contact with skin. Harmful if inhaled. Avoid breathing spray mist.
Wash thoroughly with soap and water after handling. Remove contaminated clothing and wash clothing before reuse.
page 2 of #168 鈥? Vindicator+
SECTION VI -- HEALTH HAZARD DATA continued:
Medical Conditions Generally Aggravated by Exposure: None known to manufacturer.
Emergency and First Aid Procedures: If in eyes: Hold eye open and rinse slowly and gently with water for at least 15-20 minutes.
Remove contact lenses, if present, after the first 5 minutes, then continue rinsing eye. If on skin or clothing: Take off contaminated
clothing. Rinse skin immediately with plenty of water for 15-20 minutes. If swallowed: Call a poison control center or doctor
immediately for treatment advice. Have person sip a glass of water if able to swallow. Do not induce vomiting unless told to do so by
the poison control center or doctor. Do not give anything by mouth to an unconscious person. If inhaled: Move person to fresh air. If
person is not breathing, call 911 or an ambulance, then give artificial respiration, preferably by mouth-to-mouth, if possible. Call a
poison control center or doctor for treatment advice. Have the product container or label with you when calling a poison control center
or doctor or going for treatment. NOTE TO PHYSICIAN: Probable mucosal damage may contraindicate the use of gastric lavage.
Measures against circulatory shock, respiratory depression and convulsion may be needed.
SECTION VII -- PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken In Case Material Is Released Or Spilled: Caution. Floors may become slippery. Wear appropriate protective
gear and respiratory protection where mist or vapors of unknown concentrations may be generated (self-contained breathing apparatus
preferred). Dike and contain spill with inert material (sand, earth, etc.) and transfer the liquid and solid separately to containers for
recovery or disposal. Keep spill out of sewers and open bodies of water.
Waste Disposal Method: Dispose of in compliance with all Federal, State and local laws and regulations. Incineration is the
preferred method.
Precautions To Be Taken In Handling And Storing: Keep away from children.
Other Precautions Store in original container in areas inaccessible to children. Open dumping is prohibited Do not reuse empty
container. Wrap and discard in trash or recycle. This product contains no reportable quantities of toxic chemicals subject to reporting
requirements of Section 313 of SARA Title III Emergency Planning & Community Right to Know Act of 1986 and 40 CFR Part 372.
SECTION VIII -- CONTROL MEASURES
Ventilation: In processes where mists or vapors may be generated, proper ventilation must be provided in accordance with good
ventilation practices.
Respiratory Protection (Specify Type): In processes where mists or vapors may be generated, a NIOSH/MSHA jointly approved
respirator is advised in the absence of proper environmental controls.
Protective Gloves: Rubber or neoprene, when needed, to prevent skin contact with concentrate.
Eye Protection: Wear chemical splash goggles where there is a potential for eye contact. Use safety glasses with side shields under
normal use conditions.
Other Protective Clothing or Equipment: Eye wash; safety shower; protective clothing (long sleeves, coveralls or other, as
appropriate), when needed to prevent skin contact with concentrate.
Storage and Handling: Store at temperatures below 140潞F. Keep container closed until used. Do not contaminate drinking water,
food or feed by storage or disposal. Work / Hygienic Practices: Wash hands thoroughly after handling.
SECTION IX - TRANSPORTATION INFORMATION
Applicable regulations: DOT = Yes; IMCO = Yes; IATA = Yes
Proper shipping name (Gallon Boxes) for U.S. Highway: Consumer Commodity ORM-D
Proper shipping name (5 & 55 Gallon Drums) for U.S. Highway: Disinfectants, Corrosive Liquid, N.O.S. (Didecyl dimethyl
ammonium chloride, N-alkyl dimethyl benzyl ammonium chloride), 8, UN 1903, PG III
UN No.: UN1903 Limited Qty.: not applicable Hazard Class: 8
Label required: Not required on gallon boxes by highway; 5 & 55 gallon drum = Corrosive Label
DOT Exception: Not applicable
EPA Hazardous waste/number code: Not listed
Hazardous waste characteristics:
Ignitability = Not applicable; Corrosivity = Not applicable; Reactivity = Not applicable
DISCLAIMER OF WARRANTIES
NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE, OR OF ANY NATURE ARE MADE WITH RESPECT TO THE PRODUCT(S) OR
INFORMATION CONTAINED IN THIS MATERIAL SAFETY DATA SHEET. The information and recommendations
contained in this Material Safety Data Sheet are supplied pursuant to 29 CFR 1910.1200 of the Occupational Safety and
Health Standards Hazard Communication Rule. All information contained herein is presented in good faith and is believed to
be appropriate and accurate. THE BUYER OR USER ASSUMES ALL RISKS ASSOCIATED WITH THE USE, MISUSE
OR DISPOSAL OF THIS PRODUCT. THE BUYER OR USER IS RESPONSIBLE TO COMPLY WITH ALL FEDERAL,
STATE OR LOCAL REGULATIONS CONCERNING THE USE, MISUSE OR DISPOSAL OF THESE PRODUCTS.
|