Page 1 of 6
Product Description: MATERIAL SAFETY DATA SHEET
RH289
TEXTURE (AP1 - Aerosol Product)
GRAY
SECTION 1: MANUFACTURER IDENTIFICATION
MANUFACTURED BY: FORMULA # 38A075N12A
Custom-Pak Products Inc. Company Phone Number: (262) 251-6180
Germantown, WI 53022 24 Hour Emergency: (800) 688-4005
Foreign Emergency: (01)(262) 236-8130 [USA]
DATE MSDS PRINTED & REVIEWED: 08/15/07
LAST FORMULA REVISION DATE: 01/30/04
MANUFACTURED FOR: (C1584)
C&D TECHNOLOGIES, INC.
BLUE BELL, PA 19422
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
SARA 313 LISTED CARCINOGEN BY:
# COMPONENT CAS# % by WT. LISTED NTP IARC OSHA
1 ACETONE 67-64-1 30-36 N N N N
2 PROPANE 74-98-6 15-21 N N N N
3 XYLENE 1330-20-7 10-16 Y N N N
4 N-BUTANE 106-97-8 5-8 N N N N
5 *ETHYLBENZENE 100-41-4 3-5 Y N Y N
6 AROMATIC-100 64742-95-6 1-3 N N N N
*See Section 15 and Section 11
SECTION 3: HAZARDS IDENTIFICATION
Emergency Overview: DANGER! Extremely Flammable. Contents Under Pressure.
APPEARANCE/ODOR: GRAY ATOMIZED MIST / SOLVENT ODOR
POTENTIAL HEALTH EFFECTS: See Section 11 for more information.
LIKELY ROUTES OF EXPOSURE: Eye contact, skin contact, ingestion, and inhalation
EYE: Contact may cause redness, irritation, tearing, and blurred vision
SKIN: Contact may dry skin causing cracks and irritation
INGESTION: May be harmful if swallowed
INHALATION: Exposure to high concentrations of vapors may cause drowsiness, breathing
difficulty, respiratory irritation, or headaches. Intentional misuse by
deliberately concentrating and inhaling the contents may be harmful or
fatal.
Page 2 of 6
Product Description: MATERIAL SAFETY DATA SHEET
RH289
TEXTURE (AP1 - Aerosol Product)
GRAY
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE:
Asthma and other respiratory ailments.
TARGET ORGANS: Kidney Liver Lung Brain
Reports have associated repeated and prolonged occupational overexposure to solvents
with permanent brain and nervous system damage.
This material is considered hazardous by the OSHA Hazard Communication Standard
(29 CFR 1910.1200).
SECTION 4: FIRST AID MEASURES
EYE CONTACT: Immediately flush eyes with water for at least 15 minutes. If
irritation develops get medical attention.
SKIN CONTACT: Remove contaminated clothing and wash before reuse. Wash skin with soap
and water. Get medical attention if irritation develops.
INHALATION: Move to fresh air. Contact emergency medical support if breathing
stops or is irregular.
INGESTION: Do NOT induce vomiting. Get medical attention immediately.
SECTION 5: FIRE FIGHTING MEASURES
SUITABLE EXTINGUISHING MEDIA: CO2 (Carbon Dioxide), dry chemical, or water fog.
UNSUITABLE EXTINGUISHING MEDIA: Water spray may be unsuitable. However, if water is
used, fog nozzles are preferable. Water may be used to cool closed containers
to prevent pressure build-up and possible explosion when exposed to extreme
heat.
PRODUCTS OF COMBUSTION: These products are carbon oxides (CO,CO2).
PROTECTION OF FIREFIGHTERS: Full protective equipment including self-contained
breathing apparatus should be used.
SECTION 6: ACCIDENTAL RELEASE MEASURES
PERSONAL PRECAUTIONS: Use personal protection recommended in Section 8.
ENVIRONMENTAL PRECAUTIONS: None known.
Page 3 of 6
Product Description: MATERIAL SAFETY DATA SHEET
RH289
TEXTURE (AP1 - Aerosol Product)
GRAY
METHODS OF CONTAINMENT: Absorb spilled liquid in suitable material.
METHODS OF CLEAN-UP: Use spark-proof tools to sweep or scrape up and containerize.
OTHER INFORMATION: Ventilate the area.
SECTION 7: HANDLING AND STORAGE
HANDLING:
Vapors may ignite explosively. Prevent buildup of vapors; use with adequate
ventilation. Keep from sparks, heat, flame or other heat sources. Do not smoke.
Turn off pilot lights, heaters, electric motors and other sources of ignition during
use and until all vapors are gone. Do not puncture or incinerate (burn) container.
STORAGE:
Store in dry, well-ventilated area and in accordance with federal, state, and local
regulations. Do not expose to heat or store at temperatures above 48 C (120 F).
If storing in cold temperatures, allow product to warm to room temperature before use.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
EXPOSURE GUIDELINES
# COMPONENT ACGIH TLV-STEL ACGIH TLV-TWA OSHA PEL-TWA
1 ACETONE 750 ppm 500 ppm 1000 ppm
2 PROPANE 1800 ppm 2500 ppm 1000 ppm
3 XYLENE 150 ppm 100 ppm 100 ppm
4 N-BUTANE N/E 800 ppm 800 ppm
5 *ETHYLBENZENE 125 ppm 100 ppm 100 ppm
6 AROMATIC-100 N/E 100 ppm 100 ppm
*See Section 15 and Section 11
ENGINEERING CONTROLS: Not generally required if product is applied in small quanti-
ties. If product is applied in larger quantities, provide ventilation to keep air
contamination below OSHA permissible exposure limits and ACGIH TLV exposure levels.
EYE/FACE PROTECTION: Wear safety glasses with side shields. Have eye wash facilities
immediately available.
SKIN PROTECTION: Chemical resistant gloves if contact is likely.
RESPIRATORY PROTECTION: Use NIOSH-approved air-purifying respirator with organic
cartridge or canister if exposure cannot be controlled within applicable limits
with ventilation.
GENERAL HYGIENE CONSIDERATIONS: Wash thoroughly after handling.
Page 4 of 6
Product Description: MATERIAL SAFETY DATA SHEET
RH289
TEXTURE (AP1 - Aerosol Product)
GRAY
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Color: see product description
Odor: SOLVENT ODOR
Physical State: Aerosol - Pressurized Liquid
Freezing Point: Not Established (mixture)
Boiling Range: <-18 C to 177 C (<0 F to 350 F)
Flash Point: <-18 C (<0 F)
Evaporation Rate: Faster than ether
Upper Flammability Limit: Not Established (mixture)
Lower Flammability Limit: Not Established (mixture)
Vapor Pressure: Approximately 50 psig @ 10 C (70 F)
Specific Gravity: 0.798 @15 C (60 F)
Solubility (water): Negligible
Percent Volatile, wt. %: 77.89
VOC Percent (CA): 43.89
MIR Number (CA): 1.543
Coating Category (CA): EXACT MATCH FINISH: INDUSTRIAL
SECTION 10: STABILITY AND REACTIVITY
STABILITY: Stable under normal conditions.
CONDITIONS TO AVOID: Keep away from heat, sparks, and flames.
INCOMPATIBLE MATERIALS: Strong oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: by fire - Carbon Dioxide and Carbon Monoxide
POSSIBILITY OF HAZARDOUS REACTIONS: Will not occur.
Page 5 of 6
Product Description: MATERIAL SAFETY DATA SHEET
RH289
TEXTURE (AP1 - Aerosol Product)
GRAY
SECTION 11: TOXICOLOGICAL INFORMATION
# COMPONENT LD50 Oral LD50 Dermal
1 ACETONE 1000 mg/kg 2400 mg/kg
2 PROPANE 1000 mg/kg 1800 mg/kg
3 XYLENE 4300 mg/kg 1700 mg/kg
4 N-BUTANE N/E N/E
5 *ETHYLBENZENE 3500 mg/kg 15400 mg/kg
6 AROMATIC-100 N/E N/E
*See Section 15
See section 3 for other acute effect information.
CHRONIC EFFECTS: Prolonged over-exposure to solvent ingredients in Section 2 may
cause adverse effects to the liver, urinary, cardiovascular and reproductive
systems. Reports have associated the repeated and prolonged occupational OVER-
EXPOSURE to solvents with brain and nervous system damage. The deliberate misuse
by concentrating and inhaling the vapors may be harmful or fatal.
CARCINOGENICITY: See Section 2 for additional information.
* Ethylbenzene has been classified as a (Group 2B) possible human carcinogen based on
tests on laboratory animals by (IARC) The International Agency for Research on
Cancer. There is inadequate evidence for cancer in exposed humans.
SECTION 12: ECOLOGICAL INFORMATION
No data available.
SECTION 13: DISPOSAL CONSIDERATIONS
Do not puncture, incinerate or place container in trash compactor. Dispose of product
in accordance with Federal, State, and Local regulations. Empty containers are 95%
steel; recycle where allowed.
Page 6 of 6
Product Description: MATERIAL SAFETY DATA SHEET
RH289
TEXTURE (AP1 - Aerosol Product)
GRAY
SECTION 14: TRANSPORTATION INFORMATION
US DOT (Ground)
Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D
US DOT (Air)
Proper Shipping Name: CONSUMER COMMODITY
Hazard Class: ORM-D-AIR
IATA/ICAO (International Air)
Proper Shipping Name: AEROSOLS, FLAMMABLE; Class: 2.1; UN1950; Packing
Instruction: Y203; Authorization: LTD. QTY.; FLAMMABLE GAS label required on box.
IMDG/IMO (International Maritime - ocean)
Proper Shipping Name: AEROSOL PRODUCT, LTD QTY, IMDG Class 2, Page 2102, UN1950,
Packing Group II.
No component of this product is listed as a Marine Pollutant (49 CFR 172,101,Appendix
B).
SECTION 15: REGULATORY INFORMATION
International Chemical Inventory
TSCA: United States The components of this product are listed on the TSCA inventory.
DSL: Canada The components of this product are listed on the DSL inventory.
AICS: Australia The components of this product are listed on the AICS inventory.
Section 313 Toxic Chemicals
See section 2. Chemicals marked with a "Y" are subject to the
SARA reporting requirements under 40 cfr 372.45(c)(5).
*California Safe Drinking Water and Toxic Enforcement Act of 1986 (Proposition 65)
This product contains chemicals known to the state of California to cause cancer
and birth defects or other reproductive harm.
SECTION 16: OTHER INFORMATION
HMIS: Hazardous Material Identification System
Health - 2 Fire - 4 Reactivity - 1
0 = minimal hazard, 1 = slight hazard, 2 = moderate hazard, 3 = severe hazard,
4 = extreme hazard
This MSDS is based on information believed to be reliable and accurate. Because of
changing reporting requirements and other variables it is impossible to guarantee
the accuracy of the information contained in this document. It is the responsi-
bility of the user to determine proper personal protection based on the actual
condition of use and to comply with all Federal, State and Local laws and regulations.
|