Series :
# 0 8 55 , # 0 8 56 ,# 0 8 56 / 2 0 ,
Material Safety Data Sheet # 0 8 56 / 3 0 ,# 08 5 6 / 4 0,
# 0 8 56 / 5 0 , #0 8 5 6 / 60 ,
(MSDS) # 0 8 56 / 7 0
( Al l La be l s)
MSDS # 0097 HMIS Rating: 1-1-0
R ev is ion 2
E ME RGE N CY TE LE PH O N E
SECTI O N I
NO.
LIFETIME铮? Brand Adhesive Sealant (918) 825-5744 (24 Hrs.)
TRADE NAME
(IF NONE, PUT CHEMICAL)
Red Devil, Incorporated (918) 825-5744
MANUFACTUR ER'S NAME
AND TELEPHONE NO.
4175 Webb Street, Pryor, Oklahoma 74361
ADDRESS (Number, Street,
City, State, Zip Code)
% TLV PEL U N IT
SECTION II - HAZARDOUS INGREDIENTS S
PRODUCT CONSISTS OF:
Acrylic TerPolymer Emulsion (mixture) <30.0 NE NE
Propylene Glycol (57-55-6) <1.25 400** NE ppm
*
Calcium carbonate** [1317-65-3] (as nuisance particulate, total) <55.0 10 15 mg/m3
Butyl Benzyl Phthalate (85-68-7) <8.00 NE NE
Titanium Dioxide** [13463-67-7] <1.00 10 10 mg/m3
Aqua Ammonia (7664-41-7) <0.25 25 50 ppm
Mineral Spirits (Petro. Dist.) (64742-88-7) <2.0 100 100 ppm
Non-hazardous Ingredients*
<25 NA NA
*Unlisted ingredients are not considered hazardous under the OSHA Hazard
Communication Standard (29 CFR 1910.1200).
**Inhalation of particulates unlikely due to product's physical state
***TWA
VOC: 3.4%/wt. CARB Compliance: YES. Prop 65 Ingredients: NONE
SECTI O N I I I - PHYSI CA L DA T A
210-215 1.6
BOILING POINT (掳F) SPECIFIC GRAVITY (H 2 0=1)
NE <20
VAPOR PRESSURE (MM Hg.) PERCENT VOLATILES
BY VOLUME (%)
>1 7.9 +/- 0.2
VAPOR DENSITY (AIR=1) pH
Soluble before cure >1 (BuAc = 1)
SOLUBILITY IN WATER EVAPORATION RATE
Creamy consistency and mild acrylic odor
APPEARANCE AND ODOR
SECTI O N I V - FI R E A ND EXPLO SI O N HA Z A RD DA T A
>150掳F NE NE NE
FLASH POINT (Method used) FLAMMABLE LIMITS LEL UEL
Carbon dioxide, dry chemical, foam or water fog
EXTINGUISHING MEDIA
Use water spray or fog to cool fire-exposed containers.
SPECIAL FIRE
FIGHTING PROCEDURES
Closed containers may explode when exposed to extreme heat.
UNUSUAL FIRE AND
EXPLOSION HAZARDS
NA - Not Applicable NE - Not Established UN - Unavailable
SECTION V - HEALTH HAZARD INFORMATION
SYMPTOM/EFFECTS OR OVEREXPOSURE
Inhalation of dust generated from dried product may cause respiratory irritation. High vapor
concentrations may produce headache, dizziness and nausea. Prolonged or repeated contact may
cause mild skin and eye irritation.
FIRS T AID
EYES
Immediately flush eyes with large amounts of water while holding the eyelids open. Get medical
attention if irritation persists.
SKIN
Wipe material from skin with cloth or paper towel, then wash exposed area with soap and water. Get
medical help if irritation persists.
INHALATION
Move victim to fresh air and treat symptomatically.
INGESTION
Contact local poison control center or physician IMMEDIATELY!
SECTION VI - REACTIVITY DATA
STABILITY
Normally stable. Avoid extreme heat, open flame.
INCOMPATIB MATERIALS
LE
Strong oxidizers
HAZARDOUS DECOMPOSITION PRODUCTS
Carbon monoxide, carbon dioxide
SECTION VII - SPILL OR LEAK PROCEDURES
PROCEDURES
Clean up with absorbent material.
WASTE DISPOSAL METHOD
Dispose of in accordance with Local, State and Federal regulations.
SECTION VIII - SPECIAL PROTECTION INFORMATION
RESPIRATORY
Not normally required. If TLV is exceeded, or for symptoms of overexposure, wear a NIOSH-approved
respirator for organic vapors.
Wear safety glasses.
EYEWEAR
CLOTHING/GLOVES
Not normally required; in situations of extended skin contact, neoprene or other chemical resistant
gloves are recommended.
VENTILATION
Provide adequate general dilution ventilation.
SECTION IX - SPECIAL PRECAUTIONS
Store in a closed container in cool dry area. Avoid freezing & excessive heat. DOT Proper Shipping Name: Not
Regulated by DOT. DOT Hazard Class: None. DOT UN/NA Number: None. PACKING GROUP: None.
Reviewed By: Larry G. Brandon VP Technology & General Manager June 24,
2004
NAME TITLE DATE
The information contained herein has been developed based upon current available scientific data. New information may be developed from time to time which may
render the conclusions of this report obsolete. Therefore, no warranty is extended as to the applicability of this information to the user's intended purpose or for the
consequences of its use or mis use.
|