QP6
MATERIAL SAFETY DATA SHEET
SIMILAR TO OSHA FORM 174
SECTION I
MANUFACTURER/DISTRIBUTOR INFORMATION
DISTRIBUTOR: Central Wholesalers, Inc.
ADDRESS: 13401 Virginia Manor Road Laurel, MD 20707
EMERGENCY TELEPHONE NUMBER: (215) 830-0722
CHEMICAL NAME AND SYNONYMS: Quaternary Ammonium Compound
TRADE NAME: QP6 PINE ODOR DISINFECTANT
CHEMICAL FAMILY: Quaternary Disinfectant
FORMULA: N/A Blended Product
HMIS HAZARD CODE: HEALTH: 1 FLAMMABILITY: 0 REACTIVITY: 0 OTHER: None
SECTION II
HAZARDOUS INGREDIENTS AND FIVE MAJOR COMPONENTS
% CONCENTRATION HAZARD RATINGS
(RANGE) (TLV/PEL)
%
Octyl decyl dimethyl ammonium chloride 0.57 ND
(CAS #32426-11-2)
Dioctyl dimethyl ammonium chloride 0.285 ND
(CAS #5538-94-3)
Didecyl dimethyl ammonium chloride 0.285 ND
(CAS #7173-51-5)
Alkyl (50%C14,40%C12,10%C16) dimethyl benzyl
ammonium chloride (CAS #68424-85-1) 0.76 ND
Pine Oil (CAS #8002-09-3) 2.0-3.0 ND
Isopropanol (CAS #67-63-0) 8-10. 0 400 ppm
Sodium Sesquicarbonate (CAS #6834-92-0) 0-2.0 ND
Nonionic surfactant (CAS #9016-45-9) 0-5.0 ND
Hampene (CAS #64-02-8) 0-5.0 ND
SECTION III
PHYSICAL DATA
BOILING POINT (oF): 212 SPECIFIC GRAVITY: .994
VAPOR PRESSURE: Not Est. % VOLATILES BY WEIGHT: ND
VAPOR DENSITY: Not Est. EVAPORATION RATE: Not Est.
SOLUBILITY IN WATER: Complete pH: 10.1
APPEARANCE: Clear, Thin Brown Liquid
ODOR: Pine Oil Scented
DATE PREPARED: 05-10-2006 BY: JBR
Page 1
QP6
NOTE: Not Est. = Not Established
Prop. = Proprietary
SECTION IV
FIRE AND EXPLOSION DATA
FLASH POINT (oF): Not Est. FLAMMABLE LIMITS: Not Est.
EXTINGUISHING MEDIA: Water, CO2, Dry Chemical, Foam.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Explosive mixtures can form with air.
Combustion products are toxic. Solvents vapors can travel to an ignition
source and flash back.
SECTION V
HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE: Not Est.
Inhalation: Irritation of mucous membrane can be caused by solvent vapors
or mists of products.
Eye Contact: Corrosive. Severe eye damage can result from direct contact.
Skin Contact: Severe Irritation, Corrosive.
Ingestion: May be fatal. Burning pain in the mouth, throat, abdomen,
severe swelling of the larynx, skeletal muscle paralysis
affecting the ability to breathe, circulatory shock, convulsions.
First Aid:
Skin and eye: In case of contact, immediately flush the eyes and
skin with plenty of water for at least 15 minutes.
Call a physician. Remove and wash contaminated
clothing before reuse.
Ingestion: If swallowed drink promptly, a large quantity of egg
whites, gelatin solution or, if these are not available,
drink large quantities of water. Avoid alcohol.
Call a physician immediately. Note to Physician:
Probable mucosal damage may contraindicate the use of
gastric lavage.
Chemicals Listed as Carcinogen by:
OSHA -NO
I.A.R.C. Monographs -NO
National Toxicology Program -NO
Toxicity information:
Acute Oral LD50 ND
Acute Dermal ND
Primary Skin ND
Primary Eye ND
SECTION VI
REACTIVITY DATA
STABILITY: Stable.
CONDITIONS TO AVOID: Mixing with strong oxidizers or reducing agents
INCOMPATIBILITY: Strong oxidizers or reducing agents
HAZARDOUS POLYMERIZATION: Will not occur.
Page 2
QP6
HAZARDOUS DECOMPOSITION PRODUCTS: Toxic hydrogen chloride fumes, oxides
of carbon and nitrogen.
SECTION VII
SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
Remove ignition sources. Wear respirator. Small spills may be
mopped up, flushed away with water or absorbed on some absorbent
material and incinerated. Large spills should be contained; the
material then moved into containers and disposed of by approved
methods for hazardous wastes.
WASTE DISPOSAL METHOD: Follow local, state and federal guidelines.
SECTION VIII
SPECIAL PROTECTION INFORMATION
VENTILATION: Local (mechanical).
RESPIRATORY PROTECTION: None required if good ventilation is maintained.
For mist or vapor wear NIOSH approved respirator.
PROTECTIVE GLOVES: Rubber or Neoprene Gloves.
EYE PROTECTION: Splashproof safety googles.
OTHER PROTECTIVE EQUIPMENT: Impervious apron,eyewash facility, emergency
shower, faceshield.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Keep from freezing.
Store in tightly closed, original container in a secured area away
from food or feed.
OTHER PRECAUTIONS: KEEP AWAY FROM HEAT AND OPEN FLAME. DO NOT REUSE EMPTY
CONTAINER. KEEP OUT OF REACH OF CHILDREN. FOR SALE TO,
USE AND STORAGE BY SERVICE PERSONNEL ONLY.
THE INFORMATION CONTAINED IN THIS MSDS WAS OBTAINED FROM CURRENT AND RELIABLE
SOURCES, HOWEVER THE DATA IS PROVIDED WITHOUT ANY WARRANTY, EXPRESSED OR
IMPLIED, REGARDING ITS CORRECTNESS OR ACCURACY. SINCE THE CONDITIONS OF
HANDLING, STORAGE AND DISPOSAL OF THIS PRODUCT ARE BEYOND THE CONTROL OF THIS
COMPANY, IT IS NOT RESPONSIBLE FOR LOSS, INJURY AND EXPENSE ARISING
OUT OF THE PRODUCT'S IMPROPER USE. NO WARRANTY, EXPRESSED OR IMPLIED,
REGARDING THE PRODUCT DESCRIBED IN THIS MSDS SHALL BE CREATED OR INFERRED BY
ANY STATEMENTS IN THIS MSDS. VARIOUS GOVERNMENT AGENCIES MAY HAVE SPECIFIC
REGULATIONS REGARDING THE TRANSPORTATION, HANDLING, STORAGE, USE OR DISPOSAL
OF THIS PRODUCT WHICH MAY NOT BE COVERED BY THIS MSDS. THE USER IS
RESPONSIBLE FOR FULL COMPLIANCE.
Page 3
|