OxySmart
MATERIAL SAFETY DATA SHEET MSDS NO. 392-2
May be used to comply with OSHA's Hazard Communication Standard,
29CFR 1910. 1200. Standard must be consulted for specific requirements.
Important: Do not leave any blank spaces. If required information is unavailable, unknown, or doesn't apply, so indicate.
*N/A=No information available *N/AP=Not Applicable
Section 1 - Company and Chemical Identification
DAYCON PRODUCTS COMPANY, INC. EMERGENCY PHONE: 800-535-5053
16001 TRADE ZONE AVENUE PHONE: 301-218-7100
UPPER MARLBORO, MD 20774 DATE: SEPTEMBER 7, 2006
PRODUCT USE: OXYGENATED MULTI-SURFACE CLEANER
Section 2 - Ingredients/Identity
Hazardous Component(s) (chemical & common name) OSHA ACGIH Other Exposure % CAS
PEL TLV Limits (optional) No.
Hydrogen Peroxide 1ppm 1ppm <8 7722-84-1
Nonionic/Cationic Surfactant Blend (Non Hazardous)
NPCA-HMIS Rating: Health - 1 Flammability - 0 Reactivity - 1 PPE - H
H = Safety goggles, gloves, apron and a vapor respirator
Section 3 - Health Hazard Identification
Acute: Chronic:
May irritate the eyes. None.
Signs and Symptoms of Exposure:
Irritant to eyes. Whitening of skin from oxygen bubbles 鈥? will go away.
Medical Conditions Generally Aggravated by Exposure:
Irritant to eyes.
Chemical Listed as Carcinogen National Toxicology Yes I.A.R.C Yes OSHA Yes
or Potential Carcinogen Program No X No X No X
Section 4 - First Aid Measures
Routes of Entry and Emergency/First Aid Procedures
1. Inhalation:
Remove to fresh air. If breathing is difficult or discomfort persist, seek medical attention.
2. Eyes:
Flush with water for 15 minutes lifting the upper and lower eyelids intermittently. Seek medical attention
if irritation continues.
3. Skin:
Wash with soap and water.
4. Ingestion:
Rinse mouth out with water. Dilute by giving 1 or 2 glasses of water. Do not induce vomiting. Never
give anything to an unconscious person. If irritation persists, seek medical advice.
Section 5 - Fire Fighting Measures & Data
Flash Point Method Used Flammable Limits LEL UEL
in Air % by Volume Lower Upper
Non Combustible, >200 N/A Non Combustible Non Combustible
OxySmart MSDS NO. 392-1 1
Auto-Ignition Temperature: Extinguisher Media:
N/AP Flood with water
Special Fire Fighting Procedures:
Any tank or container surrounded by fire should be flooded with water for cooling. Wear full protective
clothing and self-contained breathing apparatus.
Unusual Fire and Explosion Hazards:
The level of hydrogen peroxide in this product is less than what is considered an oxidizer.
DOT Hazard Classification:
Not Regulated
Section 6 - Accidental Release Measures
Steps to be Taken in Case Material is Released or Spilled:
Mop up, or pick up with wet vacuum.
Waste Disposal Methods (Consult federal, state, and local regulations):
Dispose of according to methods outlined for wastewater.
Section 7 - Special Precautions, Handling, and Storage
Precautions to be Taken in Handling and Storage:
Never return unused OxySmart to it鈥檚 container.
Other Precautions:
Store in cool areas out of direct sunlight and away from combustibles.
Section 8 - Special Protection Information/Control Measures
Respiratory Protection (Specify Type):
Not needed for typical uses and dilutions.
Ventilation: Local Exhaust: Mechanical (General) : Special: Other:
X or X
Protective Gloves: Eye Protection:
Rubber or neoprene Splashproof safety goggles
Other Protective Clothing or Equipment:
Not applicable.
Work/Hygienic Practices:
Wash hands after use and prior to eating, drinking or smoking.
Section 9 - Physical & Chemical Characteristics
Boiling Point: Specific Gravity (H2O): Vapor Pressure (mm Hg); Vapor Density (Air =
1):
212掳F 1.05@20掳C 23mmHg@30掳C N/A
Solubility in Water : Reactivity in Water: % Volatile
Complete Ni1 100
Appearance and Odor: Melting Point: pH
Odorless, clear, colorless liquid N/AP buffered to pH of 5
Section 10 - Stability and Reactivity
Stability: Unstable Stable Conditions to Avoid:
X Excess heat or contamination could cause product to become unstable.
Incompatibility (Materials to Avoid):
Reducing agents, and combustibles, iron and other heavy metals, copper alloys and caustic.
Hazardous Decomposition Products:
Not applicable.
Hazardous Polymerization: May Occur Will Not Occur Conditions to Avoid:
X N/AP
OxySmart MSDS NO. 392-1 2
|