Exceed Plus Page 1 of 2
Material Safety Data Sheet Quick Identifier:
Exceed Plus
Section l ~ 鈻? ~ 鈻犫??
Metro-chem, Inc. Emergency Phone No. 800-424-9300
24 Pennsylvania Avenue Other Information 973-589-2800
Kearny, NJ 07032 Date Prepared: May 12, 1997
Last Revision: December 13, 2004
Section 2 Hazardous Ingredients\identity
HAZARDOUS COMPONENT, CHEMICAL/COMMON NAME: Alkyphenol Ethoxylate, 9.2 mole CAS NO. 9016-45-9
HAZARDOUS COMPONENT, CHEMICAL/COMMON NAME: Sodium Percarbonate CAS NO. 15630-89-4
HAZARDOUS COMPONENT, CHEMICAL/COMMON NAME: Disodium Trioxosilicate CAS NO. 6834-92-0
HAZARDOUS COMPONENT, CHEMICAL/COMMON NAME: Subtilisin CAS NO. 9014-01-1
HAZARDOUS COMPONENT, CHEMICAL/COMMON NAME: A-Amylase CAS NO. 9000-90-2
HAZARDOUS COMPONENT, CHEMICAL/COMMON NAME: Triaclglycerol CAS NO. 9001-62-1
OSHA PEL: none ACGIH TLV: none OTHER EXPOSURE LIMITS: none
dot shipping information: Corrosive solid, Basic Inorganic, N.O.S., (Disodium Trioxosilicate Anhydrous),
8, UN3262, PGII
Section 3 Physical & Chemical Characteristics
BOILING POINT: n/a SPECIFIC GRAVITY (H2O=1): n/a VAPOR PRESSURE (mm Hg): n/a
VAPOR DENSITY (Air=l): n/a SOLUBILITY IN WATER: complete REACTIVITY IN WATER: n/a
APPEARANCE AND ODOR: off white powder, MELTING POINT: n/a
Section 4 Fire and Explosion Hazard Data
FLASH POINT: n/a METHOD USED: n/a
FLAMMABLE LIMITS IN AIR % BY VOLUME: LEL LOWER: n/a UEL UPPER: n/a
AUTO-IGNITION TEMPERATURE: n/a
EXTINGUISHER MEDIA: non-flammable mixture: water spray, carbon dioxide, other suffocating
agents
SPECIAL FIRE FIGHTING PROCEDURES: standard fire fighting techniques.
UNUSUAL FIRE AND EXPLOSION HAZARDS: There is a possibility of wet mixture forming hydrogen
when in contact with aluminum and/or zinc.
Section S Physical Hazards (reactivity data)
STABILITY: Normally Stable CONDITIONS TO AVOID: Moist hot atmospheres.
INCOMPATIBILITY (MATERIALS TO AVOID): Prolonged contact with zinc or aluminum when wet.
HAZARDOUS DECOMPOSITION PRODUCTS: Hydrogen due to it's flammability.
HAZARDOUS POLYMERIZATION: Will Not Occur CONDITIONS TO AVOID: constant contact with
zinc or aluminum.
Exceed Plus Page 2 of 2
Section 6 Health Hazards
1. ACUTE (Immediate): acute hazard to eyes
2. CHRONIC (Delayed Effect): may cause primary irritant dermatitis
SIGNS AND SYMPTOMS OF EXPOSURE: skin irritation
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: over exposure may cause damage to
respiratory tract.
CHEMICAL LISTED AS CARCINOGEN OR POTENTIAL CARCINOGEN:
NATIONAL TOXICOLOGY PROGRAM: NO I.A.R.C. MONOGRAPHS: NO OSHA: NO
EMERGENCY AND FIRST AID PROCEDURES
ROUTES OF ENTRY
1." INHALATION: Harmful if inhaled. Leave area of exposure. Breathe fresh air. If
discomfort persists, obtain medical attention.
2. EYES: Flush with large amounts or water for at least 15 minutes. Seek
medical attention.
3. SKIN: Wash large amounts of water. If irritation occurs and persists, obtain
medical attention.
4. INGESTION: Do not induce vomiting. Drink large amounts of milk if available or water
to dilute. Seek medical attention.
Section 7 Precautions and SpillXLeak Procedures ~
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in cool, dry area. Wear adequate
personal protection.
OTHER PRECAUTIONS: none
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Sweep up as much as possible and
placed in a labeled closed container.
WASTE DISPOSAL METHODS (Consult federal, state, and local regulations): If non reusable,
remove to an approved chemical waste disposal area. Comply with local, state, and federal
regulations for disposal. People performing this work should wear adequate personal
protective equipment and clothing.
Section 8 Special Protection informationVControl Measures
RESPIRATORY PROTECTION (Specify Type): not normally needed. In cases where large quantities
are handled, and dusts are generated, NIOSH approved respirators are recommended.
VENTILATION: LOCAL EXHAUST: adequate exhaust MECHANICAL: n/a SPECIAL: n/a OTHER: n/a
PROTECTIVE GLOVES: Rubber or chemical resistant required.
EYE PROTECTION: Safety goggles, or glasses, or face shield required.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Chemical resistant shoes and/or apron recommended.
WORK/HYGIENIC PRACTICES: Eyewash station and safety showers should be handy.
We believe the information contained herein is true; however, no warranties, expressed or
implied, are made or intended herein with respect to such information.
|