transene -- aluminum etchant type a 12-05-00 http://www.microlab.ucla.edu/EmergencySafety/MSDS/transene%20--%...
Material Safety Data Sheet U.S. Department of Labor
May be used to comply with Occupational Safety and Health Administration
OSHA鈥檚 Hazard Communication Standard. (Non-Mandatory Form)
29 CFR 1910.1200. Standard must be Form Approved
consulted for specific requirements. OMB N0. 1218-0072
Note: Blank spaces are not permitted. If any item is not applicable, or
Identity ( As used on Label and List)
no
ALUMINUM ETCHANT TYPE A
information is available, the space must be marked to indicate
that.
Section 1
Manufacture鈥檚 Name Emergency Telephone Number
TRANSENE COMPANY INC. 800-424-9300 CHEMTREC 24 HOURS
Address (Number, Street, City, State and ZIP Code) Telephone Number for Information
10 ELECTRONICS AVENUE 508-777-7860 Fax No: 508-739-5640
Date Prepared
June 19, 1997
DANVERS INDUSTRIAL PARK
Signature of Preparer (optional)
DANVERS MA 01923
Section II - Hazardous Ingredients / Identity
Information
Hazardous Components ( Specific Chemical Identity; Common Name(s)) OSHA PEL ACGIH TLV Other Limits
Recommended %
(optional)
1.0 mg/M3
PHOSPHORIC ACID H3PO4 CAS # 7664-38-2 80
%
NITRIC ACID HN03 CAS # 7697-37-2 ACGTH TLV: 2ppm (TWA) 2 ppm 5%
4ppm (STEL)
ACETIC ACID C2H4O2 CAS # 64-19-7 10 ppm 5%
BALANCE DISTILLED WATER - NON HAZARDOUS
NONE OF THE INGREDIENTS IN THIS PRODUCTS ARE SUSPECTED CARCINOGENS.
Section III - Physical / Chemical Characteristics
100OC
Boiling Point Specific Gravity ( H2O = 1)
1.45
Vapor Pressure (mm Hg.) Melting Point ```
N/A N/A
Vapor Density (AIR = 1) Evaporation Rate
(Butyl Acetate = 1)
N/A N/A
o
Solubility in Water at 20 c Miscible
Appearance and Odor CLEAR, COLORLESS, SYRUPY LIQUID, ODORLESS
Section IV - Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LEL UEL
NON-FLAMMABLE NOT ------
----
APPLICABLE
WATER SPRAY, DRY CHEMICAL, OR FOAM. CONTACT WITH COMMON METALS
Extinguishing Media
PRODUCES HYDROGEN (H2) WHICH MAY FORM FLAMMABLE MIXTURES WITH AIR UNDER CONDITIONS OF
FIRE, TOXIC VAPORS MAY FORM, CORROSIVE LIQUID !
1 of 4 12/18/2006 11:19 AM
transene -- aluminum etchant type a 12-05-00 http://www.microlab.ucla.edu/EmergencySafety/MSDS/transene%20--%...
WEAR SELF-CONTAINED BREATHING APPARATUS DURING THE FIRE AND
Special Fire Fighting Procedures
PROTECT SKIN FROM VAPORS OR MIST.
(Reproduce locally) OSHA 174,
Sept. 1985
2 of 4 12/18/2006 11:19 AM
transene -- aluminum etchant type a 12-05-00 http://www.microlab.ucla.edu/EmergencySafety/MSDS/transene%20--%...
Section V -Reactivity Data
Stability Unstable Conditions to Avoid AVOID CONTACT WITH COMMON METALS, STRONG
BASES, OXIDIZERS
AND COMBUSTIBLE ORGANICS.
Stable
X
Incompatibility ( Materials to Avoid) STRONG BASES, OXIDIZERS, MOST METALS AND COMBUSTIBLE ORGANICS.
Hazardous Decomposition or By products VARIOUS OXIDES OF PHOSPHORUS, NITROGEN & SOME CARBON DIOXIDE(CO2 )
Hazardous May Occur Conditions to Avoid
Polymerization
May Not NOT APPLICABLE
X
Occur
Section VI - Health Hazard Data
Route(s) of Entry: Inhalation ? Skin? Ingestion?
YES YES YES
Health Hazards (Acute and Chronic) SOLUTION IS MODERATELY IRRITATING TO THE EYES, SKIN, AND MUCOUS
MEMBRANES. CONCENTRATED SOLUTIONS MODERATELY TOXIC BY INGESTION.
DIRECT CONTACT CAN CAUSE SEVERE BURNS. PERSONS WITH PRE-EXISTING SKIN DISORDERS OR DISEASE MAY BE
MORE
SUSCEPTIBLE TO THE EFFECTS OF THIS SUBSTANCE.
Carcinogenicity NTP? IARC Monographs? OSHA Regulated?
N/A N/A N/A N/A
Signs And Symptoms of Exposure EYE CONTACT: FLOOD WITH EXCESS OF WATER FOR AT LEAST 15 MINUTES. CONTACT A
PHYSICIAN
SKIN CONTACT:FLOOD WITH WATER & COVER WITH MOIST BAKING SODA. CONTACT A
PHYSICIAN
INHALATION: REMOVAL TO CLEAN AIR IS USUALLY SUFFICIENT. IF NOT BREATHING,
GIVE
ARTIFICIAL RESPIRATION. CONTACT A PHYSICIAN.
INGESTION: DO NOT INDUCE VOMITING ! GIVE WATER WITH MILK OF MAGNESIA OR
BEATEN
Medical Conditions SEE SIGNS & SYMPTOMS OF EXPOSURE
Generally Aggravated by Exposure N/A
EYE CONTACT: FLOOD WITH EXCESS OF WATER FOR AT LEAST 15 MINUTES. CONTACT A
First Aid :
PHYSICIAN
SKIN CONTACT:FLOOD WITH WATER & COVER WITH MOIST BAKING SODA. CONTACT A
PHYSICIAN
INHALATION: REMOVAL TO CLEAN AIR IS USUALLY SUFFICIENT. IF NOT BREATHING,
GIVE
ARTIFICIAL RESPIRATION. CONTACT A PHYSICIAN.
INGESTION: DO NOT INDUCE VOMITING ! GIVE WATER WITH MILK OF MAGNESIA OR
BEATEN
Section VII - Precautions For Safe Handling And Use
Steps to Be Taken in Case Material is Released or Spilled COVER CONTAMINATED AREA WITH SODA ASH, SLAKED LIME
MIXTURE
(50:50) MIX AND ADD WATER TO FORM A SLURRY. SCOOP UP SLURRY AND SAVE FOR DISPOSAL.
Waste Disposal Method ADD ABOVE SLURRY OF MIXTURE (AS IS) SLOWLY TO A LARGE VOLUME OF SODA ASH
SOLUTION WITH
AGITATION. NEUTRALIZE AND FLUSH TO SEWER WITH RUNNING WATER IN A CONCENTRATION PERMITTED BY
LOCAL, STATE
AND FEDERAL REGULATIONS.
Precautions to be taken in handling and storing PROTECT CONTAINERS AGAINST PHYSICAL DAMAGE. STORE IN COOL,
DRY,
WELL VENTILATED LOCATION, AWAY FROM AREA WHERE FIRE HAZARDS MAY BE ACUTE. KEEP AWAY FROM
OXIDIZERS
3 of 4 12/18/2006 11:19 AM
transene -- aluminum etchant type a 12-05-00 http://www.microlab.ucla.edu/EmergencySafety/MSDS/transene%20--%...
AND BASES. PROTECT UNITS FROM DIRECT SUNLIGHT. LOOSEN CONTAINER CAUTIOUSLY.
Other Precautions VENTILATION: A SYSTEM OF LOCAL EXHAUST IS RECOMMENDED TO KEEP EMPLOYEE EXPOSURES
BELOW
THE AIRBORNE EXPOSURE LIMITS. LOCAL EXHAUST VENTILATION IS GENERALLY PREFERRED BECAUSE IT CAN
CONTROL
THE EMISSIONS OF THE DUST OR VAPOR AT ITS SOURCE PREVENTING DISPERSION INTO THE GENERAL WORK AREA.
REFER TO ACGIH DOCUMENT, 鈥淚NDUSTRIAL VENTILATION, A MANUAL OF RECOMMENDED PRACTICES鈥? FOR
DETAILS.
Section VIII - Control Measures
Respiratory Protection (Specify Type) ORGANIC VAPORS/ ACID GASES (NIOSH APPROVED). HN03 IS AN OXIDIZER AND
SHOULD
NOT COME IN CONTACT WITH CARTRIDGES AND CANISTERS THAT CONTAIN OXIDIZABLE MATERIALS, SUCH AS
ACTIVATED CHARCOAL.
Ventilation Local Exhaust X Special
Mechanical (General) Other
Protective Gloves VITON WITH COTTON LINING Eye Protection FACE SHIELD OR SPLASH-PROOF
GOGGLES.
DO NOT WEAR CONTACT LENSES WHEN WORKING
WITH THIS PRODUCT.
Other Protective Clothing or Equipment LAB COAT, COVERALLS, OR APRON.
Work/Hygienic Practices HANDLE WITH CARE. WASH AFTER HANDLING.
DOT CLASS: CORROSIVE LIQUID ACIDIC INORGANIC NOS
UN 3264
4 of 4 12/18/2006 11:19 AM
|