MATERIAL SAFETY DATA SHEET
H M I S HAZARD RATINGS: Health 1 Flammability 0 Reactivity 0 Personal Protection B
SECTION I -- PRODUCT INFORMATION
MANUFACTURE鈥橲 NAME U.S. POLYCHEMICAL CORP MANUFACTURER鈥橲 CODE IDENTIFICATIONS: AC 600 COMPOSITE RESIN
www.uspoly.com
WEB SITE REMOVER
STREET ADDRESS 584 CHESTNUT RIDGE ROAD CITY, STATE AND ZIP CODE CHESTNUT RIDGE, NY 10977
800-424-9300
CHEMTREC TELEPHONE NO. PRODUCT CLASS AQUEOUS CLEANER
845-356-5530
INFORMATION TELEPHONE NO.
POLYCHEM ACRASTRIP 600 CRR
TRADE NAME
800-431-2072
TOLL FREE NUMBER
845-356-6656 PATENT NUMBER 5, 972, 865
FAX NUMBER
PREPARATION DATE APRIL 17, 2002 REVISION DATE JANUARY, 2005 DATE ISSUED MAY 4, 2006
SECTION II -- HAZARDOUS INGREDIENTS
OCCUPATIONAL EXPOSURE LIMITS
INGREDIENT CAS NO. % NIOSH/
OSHA ACGIH OTHER
PEL/TWA PEL/CEILING TLV/TWA TLV/STEL --
PPM PPM PPM PPM PPM
PROPYLENE GLYCOL METHYL ETHER ACETATE 108-65-6 -- N.E. N.E. N.E. N.E. --
ALIPHATIC CARBOXYLIC ACID ESTERS, MIXTURE 1119-40-0, -- N.E. N.E. N.E. N.E. --
627-93-0,
106-65-0
DPM 34590-94-8 -- 100 150 100 150 --
* SEE SECTION IX
N.E. = NOT ESTABLISHED
The Acrastrip Formulation Is Accepted In Partnership With The
Design for the Environment ( 鈥淒fE鈥? ) Division Of The EPA
SECTION III -- PHYSICAL DATA
BOILING RANGE APPROXIMATELY: 212掳F VAPOR DENSITY: ( ) HEAVIER ( ) LIGHTER THAN AIR ( ) NOT APPLICABLE
EVAPORATION RATE : ( ) FASTER ( ) SLOWER THAN ETHER ( ) NOT APPLICABLE
PERCENT VOLATILE BY VOLUME: CONCENTRATE: 62 VOC: CONCENTRATE: 620 g/l ; HAPS , % NONE
IN 33% USE SOLUTION: 21 IN 33% USE SOLUTION: 207 g/l
SPECIFIC GRAVITY @ 20 潞C 1.028 WEIGHT PER GALLON 8.6 LBS
SOLUBILITY IN WATER: SOLUBLE pH CONCENTRATE: 6.5-7.5 APPEARANCE AND ODOR: CLEAR SOLUTION, MILD ODOR
SECTION IV -- FIRE AND EXPLOSION HAZARD DATA
FLASH POINT : NONE 掳F T.C.C
FLAMMABILITY CLASSIFICATION : OSHA / DOT: UNCLASSIFIED LEL: NOT DETERMINED
( X ) FOAM ( X ) ALCOHOL FOAM ( X ) CO2 (X ) DRY CHEMICAL (X ) WATER FOG ( ) OTHER
EXTINGUISHING MEDIA
UNUSUAL FIRE AND EXPLOSION HAZARDS NONE KNOWN
SPECIAL FIRE FIGHTING PROCEDURES: NONE KNOWN.
COOL CONTAINERS WITH WATER SPRAY TO PREVENT RUPTURE.
POLYCHEM AC 600 COMPOSITE RESIN REMOVER
SECTION V -- HEALTH AND HAZARD DATA
EFFECT OF OVER EXPOSURE PROLONGED OR REPEATED CONTACT CAN CAUSE IRRITATION
OF SKIN, EYES AND RESPIRATORY TRACT.
MEDICAL CONDITIONS PRONE SKIN CONTACT MAY AGGRAVATE AN EXISTING DERMATITIS.
TO AGGRAVATION BY
EXPOSURE:
( ) ( ) ( )
PRIMARY ROUTE(S) OF ENTRY DERMAL INHALATION INGESTION
OSHA/ACGIH SKIN HAZARD
EMERGENCY AND FIRST AID PROCEDURES
INGESTION: GIVE TWO GLASSES OF MILK AT ONCE. DO NOT INDUCE VOMITING. GET IMMEDIATE MEDICAL ATTENTION.
SKIN: REMOVE CONTAMINATED CLOTHING. LAUNDER CLOTHES PRIOR TO REUSE. WASH SKIN WITH PLENTY OF WATER.
EYES: FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. OBTAIN MEDICAL ATTENTION.
INHALATION: MOVE TO FRESH AIR
SECTION VI -- REACTIVITY DATA
( ) UNSTABLE ( )
STABILITY STABLE CONDITIONS TO AVOID --
INCOMPATIBILITY (MATERIALS TO AVOID) AVOID CONTACT WITH STRONG OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION PRODUCTS BURNING OF PRODUCT MAY PRODUCE OXIDES OF CARBON .
( ) MAY OCCUR ( )
HAZARDOUS POLYMERIZATION WILL NOT OCCUR
SECTION VII -- SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE COLLECT ON ABSORBENT MATERIAL. RINSE AREA WITH PLENTY OF WATER.
MATERIAL IS RELEASED OR SPILLED:
WASTE DISPOSAL
THE WASTE MUST BE DISPOSED IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS .
SECTION VIII -- SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC VAPORS., IN CONFINED AREAS. WITHOUT
ADEQUATE VENTILATION.
VENTILATION ADEQUATE TO MAINTAIN FUME LEVELS BELOW THE TLV..
PROTECTIVE GLOVES VITON/NEOPRENE GLOVES OTHER PROTECTIVE EQUIPMENT: LONG SLEEVE SHIRT & PANT
EYE WASH STATION, SHOWER
EYE PROTECTION GOGGLES WITH SIDE SHIELD
SECTION IX -- SPECIAL PRECAUTIONS & REGULATORY INFORMATION
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: STORE IN COOL DRY PLACE.
WASH HANDS AFTER HANDLING THIS MATERIAL. AVOID PROLONGED CONTACT WITH SKIN AND EYES.
EMPTY CONTAINERS MAY CONTAIN RESIDUAL MATERIAL.
TRANSPORT INFORMATION: SHIPPING NAME & 鈥淐ONTAINS鈥? FOR N.O.S. LISTINGS: CLEANING COMPOUND
UN ID NUMBER -- CLASS: -- PACKING GROUP: --
SARA TITLE III HAZARD INFORMATION: --
TOXIC SUBSTANCE CONTROL ACT (TSCA) : ALL COMPONENTS OF THIS PRODUCT ARE ON THE TSCA INVENTORY OR
ARE EXEMPT FROM TSCA INVENTORY REQUIREMENT.
CEPA-DOMESTIC SUBSTANCES LIST (DSL ): THE COMPONENTS OF THIS PRODUCT ARE ON THE DSL OR ARE EXEMPT FROM
REPORTING UNDER THE NEW SUBSTANCES NOTIFICATION REGULATIONS.
EUROPEAN INVENTORY OF EXISTING
COMMERCIAL CHEMICAL SUBSTANCES (EINECS) ALL COMPONENTS IN THIS PRODUCT ARE IN COMPLIANCE WITH EINECS.
THIS INFORMATION IS OFFERED IN COMPLIANCE WITH OSHA AND USA EPA NOTIFICATION / DISCLOSURE REQUIREMENTS BASED ON AVAILABLE DATA. WE BELIEVE THE INFORMATION IS ACCURATE. SUBMISSION OF
THIS INFORMATION DOES NOT CONSTITUTE ANY WARRANTY, EITHER STATED OR IMPLIED. USER ASSUMES ALL LIABILITY FOR PROPERLY USING THIS INFORMATION.
|