MATERIAL SAFETY DATA SHEET MSDS DATE: 4/8/09
SECTION 5: FIRE-FIGHTING MEASURES
Per OSHA-recommended ANSI Z400.1-2004 standard format & in accordance with
European standard format Product is non-combustible
Flash point: Autoignition Temperature:
SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
F: 200癋 F: Not Established
C: 93.3癈 C: Not Established
Product Name: Piranha?4
Product Description: Lemon Scented NMP Solvent Gel Paint Remover
Flammable Limits in Air:
Product Code: 5740
(% BY VOLUME)
Manufacturer: Fiberlock Technologies, Inc.
UPPER: Not applicable
LOWER: Not applicable
150 Dascomb Road Extinguishing Media:
Andover MA, 01810
Use extinguishing media appropriate for surrounding fire
Water Spray OK
Tel: (800) 342-3755
Fax: (978) 475-6205
Carbon Dioxide OK
Emergency Phone: 24 Hour Contact: CHEM-TEL: (800) 255-3924
INTERNATIONAL 24 HOUR EMERGENCY Phone: 813-248-0585
Dry Chemical OK
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS Halon NO
Hazardous: Other N/A
Chemical Name CAS# Percent OSHA PEL ACGIH TLV SPECIAL FIRE FIGHTING PROCEDURES: Keep personnel removed and upwind
of fire. Wear self-contained breathing apparatus. Wear full protective equipment.
1 - N - Methyl-2- 872-50-4 45 - 50 Not Established Not Established
Cool tank container with water spray.
UNUSUAL FIRE AND EXPLOSION HAZARDS: This product may burn, but will not
2 - Dimethyl Adipate 627-93-0 40 - 45 Not Established Not Established ignite readily.
This product contains N - Methyl-2- Pyrrolidone which is subject to reporting
requirements of Section 313 of Title III of the Superfund Amendments and
SECTION 6: ACCIDENTAL RELEASE MEASURES
Reauthorization Act of 1986 and 40 CFR Part 372. The following statement is made in
order to comply with the California Safe Drinking Water and Toxic Enforcement Act of Accidental Release Measures:
1986: This product contains N - METHYL-2- PYRROLIDONE which is known to the state
Review section IV- unusual fire and explosion hazards. Small spills: Wipe or scrape up
of California to cause reproductive harm.
any material. Wash area thoroughly with detergent and water; ventilate adequately with
good fresh air movement at floor level. Large spills: Wear proper protective equipment.
Stop spill at source, dike area of spill to keep from spreading and keep out of ground
SECTION 3: HAZARDS IDENTIFICATION
water and streams. Transfer material to metal containers. Absorb remainder with sand,
clay, earth, floor absorbent, or other material and shovel into containers. Then wash area
Potential Health Hazards:
thoroughly with water and detergent. Ventilate adequately with good fresh air movement
Inhalation health risks and symptoms of exposure: If mists or vapors are generated
at floor level. Do not restart pilot lights or operate electrical devices or other sources of
at high concentrations, may cause pallor, nausea, anesthetic or narcotic effects, blurred
sparks, flames or heat until all vapors (odors) are gone.
vision and irritation of the upper respiratory passages.
Personal Precautions: Do not get in eyes. Do not take internally. Avoid skin contact.
Skin and eye contact health risks and symptoms of exposure: Skin: This material
Prevent prolonged or repeated breathing of vapor or spray mists. Keep unnecessary
may cause mild skin irritation. Prolonged or repeated contact may cause redness,
people away. Floor may be slippery, use care to avoid falling. Remove all sources if
cracking and blistering of skin. Eye contact can cause irritation. Direct contact with the
ignition. Ventilate the area. Remove with inert absorbent.
liquid or exposure to vapors or mists may cause stinging, tearing, redness and blurred
Skin absorption health risks and symptoms of exposure: Due to low evaporation
SECTION 7: HANDLING AND STORAGE
rate, components can be absorbed through skin causing numbness and blurred vision.
Ingestion health risks and symptoms of exposure: Ingestion can cause severe Handling and Storage:
Precautions to be taken in handling and storing: Store in cool place, out of hot sun and
Health hazards (chronic): N-Methyl-2-Pyrrolidone: a component of this product was below 100癋. All containers are subject to damage in storage and transit. Damaged
reported to be fetotoxic and to increase the incidence of skeletal abnormalities when containers may start leaking immediately or at a later time. Do not store where vapors
administered dermally to rats at a dose of 750 mg/kg during gestation (fund. and appl. may come in contact with flames, sparks or heat.
tox 2: 73-6, 1982).
Other Precautions: Avoid contact with material. Do not eat, drink or smoke when handling
Carcinogenicity: NTP: No IARC Monographs: No OSHA Regulated: No this material.
Medical conditions generally aggravated by exposure: NONE Maximum Storage Temperature: 100癋 (38癈), minimum 35癋 (2癈).
Keep closure tight and containers upright to prevent leakage.
Precautionary labeling: KEEP FROM FREEZING".
SECTION 4: FIRST AID MEASURES Product is non-combustible.
Eyes: Flood with plenty of water with eye lids held open for at least 15 minutes and get
medical attention promptly .
Skin: Wash thoroughly with soap and water. Thoroughly launder contaminated clothing
before reuse. If irritation and redness persists, see physician.
Ingestion: Keep person warm and quiet get medical attention. Immediately give two
glasses of water if conscious.
Inhalation: If illness occurs, remove patient to fresh air. If breathing is difficult, give
oxygen. If breathing has stopped, start artificial respiration. Call physician immediately.
Page 1: MSDS for Fiberlock Technologies Piranha?4 Lemon Scented NMP Solvent Gel Paint Remover No. 5740
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION SECTION 15: REGULATORY INFORMATION
Precautions: U.S. Federal Regulations:
Use only with adequate ventilation. TSCA (TOXIC SUBSTANCE CONTROL ACT): The intentional ingredients of this product are
Work Hygienic Practices: Avoid contact with skin. Do not get in eyes. Do not take listed.
internally. Avoid breathing vapors or spray mists. SARA TITLE III (SECTION 312): Immediate/Health
Ventilation: Use local exhaust to control vapors. SARA TITLE III (SECTION 313): This product contains N - Methyl-2- Pyrrolidone which is subject
Respiratory Protection: Approved organic vapor respirator, If vapors or mists are to reporting requirements of section 313 of Title 313 of Title III of The Superfund Amendments and
generated. Reauthorization Act of 1986 and 40 CFR part 372.
Eye Protection: Chemical goggles or safety glasses with side shield. CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT (PROPOSITION 65):
The following statement is made in order to comply with the California Safe Drinking Water and
Skin Protection: For repeated or prolonged exposure, neoprene gloves are
Toxic Enforcement Act of 1986. This product contains a chemical(s) known to the state of California
to cause cancer, birth defects, or other reproductive harm.
Other Protective Equipment: N/A
Pennsylvania Substance List: N - Methyl-2- Pyrrolidone (872-50-4)
New Jersey Right to Know Hazardous Substance List: N - Methyl-2- Pyrrolidone (872-50-4)
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Solubility in Water:
Viscous liquid Total
SECTION 16: OTHER INFORMATION
Sweet odor Light Blue
Judgement of potential hazards of this product is based on information available about
individual components listed under section II - Ingredients. Direct testing of mixture has not
Boiling Point: Viscosity @ 77癋:
been done. Flash point has been tested. Information given herein is believed to be accurate
Evaporation Rate: Vapor Density
Slower Heavier and is given in good faith; however, no warranty either expressed or implied is made. It is
(Butyl Acetate=1) (AIR = 1) @ 68癋: strongly suggested that users confirm in advance of need that the information is current and
applicable to their situations.
Vapor Pressure: Specific Gravity (H2O =
<1 mm Hg @ 1.04
1) @ 68癋:
68 F To comply with New Jersey DOH Right-To-Know labeling law (NJAC 8:59 ?5.1 & 5.2)
pH Percent Volatile
CAS. No.: CHEMICAL INGREDIENTS
SECTION 10: STABILITY AND REACTIVITY 872-50-4 N-Methyl-2-Pyrrolidone
627-93-0 Dimethyl Adipate
Incompatibility: (Material to Avoid): Strong oxidizing agents (E.G. Nitric acid,
permanganates, Etc.) Strong Alkalies (E.G. NAOH Ammonia, Etc.), Strong acids
HMIS HAZARD RATING
(E.G. HCL, Sulfuric, Etc.)
Hazardous Decomposition or By-Products: Not Established Health 1 Flammability 1 Physical Hazard 0 Personal
Hazardous Polymerization: Will not occur.
HAZARD INDEX: 0=Minimal, 1=Slight, 2=Moderate, 3=Serious, 4=Severe
SECTION 11: TOXICOLOGICAL INFORMATION PERSONAL PROTECTION CODE:
Toxicological Information: C = Safety Glasses, Gloves, Synthetic Apron
Health hazards (chronic): N-Methyl-2-Pyrrolidone: a component of this product
was reported to be fetotoxic and to increase the incidence of skeletal abnormalities
This company cannot anticipate all conditions of handling and use of this product.
when administered dermally to rats at a dose of 750 mg/kg during gestation (fund.
Therefore, this company accepts no responsibility for results obtained by the
and appl. tox 2: 73-6, 1982).
application of this information, or the safety and suitability of our products either alone or
in combination with other products. It is the responsibility of the user to
SECTION 12: ECOLOGICAL INFORMATION provide a safe workplace, using the health and safety information contained herein as a
guide. This company will accept no liability for damages or loss incurred from the
improper handling and use of this product.
No Data Available
SECTION 13: DISPOSAL CONSIDERATIONS
Waste Disposal Method:
Dispose of in accordance with local, state and federal regulations. This product is
not considered a hazardous waste under current RCRA regulations.
SECTION 14: TRANSPORT INFORMATION
U.S. Department of Transportation
Hazard Class: "Non Regulated"
Page 2: MSDS for Fiberlock Technologies Piranha?4 Lemon Scented NMP Solvent Gel Paint Remover No. 5740