Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: 813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: GASKET REMOVER 4 OZ.
Item No: 80645
Product Type: Cleaner
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH; TLV-TWA OSHA PEL:
WATER 50-70 Not listed Not Listed
7732-18-5
DIMETHYL GLUTARATE 10-30 Not listed Not Listed
1119-40-0
DIMETHYL SUCCINATE 1-10 Not listed Not Listed
106-65-0
DIMETHYL ADIPATE 1-10 Not listed Not Listed
627-93-0
5 mg/m3 TWA (oil mist) ACGIH 5 mg/m3 (oil mist)
MINERAL OIL 1-10
8042-47-5
NITROGEN 1-10 Not listed Not Listed
7727-37-9
3. HAZARDS IDENTIFICATION
May irritate respiratory system upon frequent or prolonged use. May irritate the eyes.
Toxicity:
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
May cause redness to eyes and irritation to nasal passages.
Signs and Symptoms of Exposure:
None known.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
Move to fresh air in case of accidental inhalation of vapours. Obtain medical attention.
Inhalation:
Wipe off material with paper towel or cloth. Wash off immediately with soap and plenty of water removing
Skin Contact:
all contaminated clothes and shoes. If skin irritation persists, call a physician.
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
>200癋 PMCC
Flash Point (癋/C):
Carbon dioxide, chemical powder
Recommended Extinguishing Media:
***Warning: This container is pressurized with nitrogen. Do not remove
Special Fire-Fighting Procedures:
rubber plug. Use water spray to cool exposed containers.
Oxides of carbon
Hazardous Products of Combustion:
Contents under pressure Heated cans may burst Do not puncture or
Unusual Fire/Explosion Hazards:
incinerate container
Not determined.
Lower Explosive Limit:
Not determined.
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until
Spill Procedures:
disposal.
1 of 3
Product Name: GASKET REMOVER 4 OZ. Item No: 80645
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 120 degrees F.
Storage:
Avoid contact with skin and eyes. Wash thoroughly after handling. Do not puncture or incinerate container.
Handling:
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Neoprene or nitrile gloves recommended.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this
product.
Not required under normal use. An approved organic vapor respirator should be worn when exposures are
Respiratory Protection:
expected to exceed the applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
White viscous lotion
Appearance:
ESTER
Odor:
Not determined.
Boiling Point:
6-7
pH:
SOLUBLE
Solubility in Water:
1.07
Specific Gravity:
6%
VOC Content(Wt.%):
Not Determined
Vapor Pressure:
>1
Vapor Density (Air=1):
<1 (butyl acetate = 1)
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR.
Hazardous Polymerization:
Strong oxidizers, acids, alkalines
Incompatabilities:
Keep away from heat, sparks and open flame
Conditions to Avoid:
Oxides of carbon
Hazardous Products of Combustion:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
NH - Not a RCRA Hazardous Waste Material
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Consumer Commodity (not more than one liter)
DOT Shipping Name:
ORM-D
Hazard Class:
None
UN/ID Number:
None
Marine Pollutant:
IATA
Consumer Commodity (Not more than 1 liter)
Proper Shipping Name:
Class 9
Class or Division:
ID 8000
UN/ID Number:
IMDG
Aerosols, Limited Quantity
Proper Shipping:
Class 2.2
Hazard Class:
UN 1950
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
2 of 3
Product Name: GASKET REMOVER 4 OZ. Item No: 80645
NONE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 1, FLAMMABILITY 1 , REACTIVITY 0.
Estimated NFPA Rating:
HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: November/20/2007
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 2
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|