PRODUCT NAME: DRYLOK CONCRETE FLOOR PAINT ?LOW VOC HMIS CODES: H F RP
ALL COLORS AND TINT BASES 100
PRODUCT CODE: 135, 136, 137, 138, 139, 140, 141, 142, 143
SECTION I ?MANUFACTURER IDENTIFICATON
MANUFACTURE'S NAME: UNITED GILSONITE LABORATORIES EMERGENCY PHONE: (800) 424-9300
ADDRESS: 1396 JEFFERSON AVENUE
SCRANTON, PA 18509 INFORMATION PHONE: (570) 344-1202
NAME OF PREPARER: R. BARAKO
DATE REVISED: APRIL 2010
SUPERSEDES: JUNE 2006
SECTION II ?HAZARDOUS INGREDIENTS/SARA III INFORMATION
OCCUPATIONAL EXPOSURE LIMITS VAPOR PRESSURE WEIGHT
mmHg@TEMP
HAZARDOUS COMPONENTS CAS NUMBER OSHA PEL ACGIH TLV OTHER PERCENT
WATER 7732-18-5 NOT ESTAB NOT ESTAB NOT ESTAB 1.0 (68F) 50-55
15 MG/M3 10 MG/M3
ALUMINUM SILICATE 1332-58-7 NOT ESTAB N/A 10
ACRYLIC COPOLYMER NOT ESTAB NOT ESTAB NOT ESTAB NOT ESTAB N/A 15
ALKYD RESIN NOT ESTAB NOT ESTAB NOT ESTAB NOT ESTAB N/A 5
ESTER ALCOHOL 25265-77-4 NOT ESTAB NOT ESTAB NOT ESTAB 1.0 (189F) <5
No toxic chemical (s) subject to the reporting requirements of Section 313 of Title III and of CFR 372 are present
SEE SECTION IX FOR LIST OF ADDITIONAL INGREDIENTS
SECTION III ?PHYSICAL/CHEMCIAL CHARACTERISTICS
BOILING RANGE: 212 F SPECIFIC GRAVITY (H2O = 1): 1.3
VAPOR DENSITY: HEAVIER THAN AIR EVAPORATION RATE: SLOWER THAN ETHER
COATING V.O.C.: DOES NOT EXCEED MAXIMUM VOC 100 G/L ( 0.84 LB/GAL)
SOLUBILITY IN WATER: SOLUBLE
APPEARANCE AND ODOR: WHITE OR COLORS, PRODUCT SPECIFIC. TYPICAL AMINE ODOR
SECTION IV ?FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: N/A METHOD USED: N/A
FLAMMABLE LIMITS IN AIR BY VOLUME: LOWER: N/A UPPER: N/A
EXTINGUISHING MEDIA: NONE KNOWN
SPECIAL FIRE FIGHTING PROCEDURES: CONTAINERS MAY SWELL AND BURST DURING A FIRE DUE TO INTERNAL PRESSURE CAUSED BY
HEAT. THIS MAY CAUSE A SLIPPERY CONDITION ON FLOORS
UNUSUAL FIRE AND EXPLOSION HAZARDS: N/A
SECTION V ?REACTIVITY DATA
STABILITY: PRODUCT IS STABLE
CONDITIONS TO AVOID: TEMPERATURES BELOW 32 (F) FOR STORAGE. TEMPERATURES BELOW 50 (F) FOR APPLICATION
INCOMPATIBILTY (MATERIALS TO AVOID): N/A
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: N/A
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
SECTION VI ?HEALTH HAZARD DATA
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: IN IT'S WET STATE, THIS PRODUCT SHOULD NOT POSE ANY THREAT TO
HEALTH DUE TO OVEREXPOSURE
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE: DIRECT CONTACT MAY CAUSE BURNING, TEARING, REDNESS
AND SWELLING
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: CAN CAUSE SLIGHT IRRITATION
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE: MAY PRODUCE SIGNS OF INTOXICATION CHARACTERIZED BY
INCOORDINATION, DIZZINESS, HEADACHE, NAUSEA, MENTAL CONFUSION, SLURRED SPEECH DEPENDING ON THE QUANTITY OF MATERIAL
INGESTED
HEALTH HAZARDS (ACUTE AND CHRONIC ) NONE KNOWN
CARCINOGENICITY: NTP? NO IARC MONOGRAPHS? YES OSHA REGULATED? NO
IARC CONCLUDES THAT THERE IS SUFFICIENT EVIDENCE IN HUMANS AND EXPERIMENTAL ANIMALS FOR THE CARCINOGENICITY OF
CRYSTALLINE SILICA IN THE FORMS OF QUARTZ OR CRISTOBALITE. IARC (GROUP 1). TITANIUM DIOXIDE HAS BEEN CHARACTERIZED BY
IARC AS POSSIBLY CARCINOGENIC TO HUMANS (GROUP 2B) THROUGH INHALATION (NOT INGESTION). THIS CLASSIFICATION IS BASED UPON
ANIMAL INHALATION STUDIES. EPIDEMIOLOGY STUDIES DO NOT SUGGEST AN INCREASED RISK OF CANCER IN HUMANS FROM
OCCUPATIONAL EXPOSURE TO TITANIUM DIOXIDE.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: INHALATION OF THE SPRAYED MATRIAL OR THE DUST FROM
SANDING THE DRY FILM CAN AGGRAVATE RESPIRATORY CONDITIONS
EMERGENCY AND FIRST AID PROCEDURES:
EYES: FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CONSULT A PHYSICIAN IF IRRITATION PERSISTS.
SKIN: WASH AFFECTED AREA WITH SOAP AND WATER. CONSULT A PHYSICIAN IF IRRITATION PERSISTS
INGESTION: GIVE ONE OR TWO GLASSES OF WATER. IF INDIVIDUAL IS DROWSY OR UNCONSCIOUS DO NOT GIVE ANYTHING BY
MOUTH. CONSULT A PHYSICIAN, MEDICAL FACILITY OR POISON CONTROL CENTER FOR ADVISE ABOUT WHETHER TO INDUCE
VOMITING
INHALATION: REMOVE VICTIM TO FRESH AIR
SECTION VII ?PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: DIKE AREA AROUND SPILL. APPLY ABSORBENT MATERIAL, THEN
SWEEP UP AND PLACE IN PROPER CONTAINERS
WASTE DISPOSAL METHOD: DISPOSE OF IN APPROVED SITES ACCORDING TO LOCAL, STATE AND FEDERAL REGULATIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: AVOID BRATHING DUST. KEEP FROM FREEZING. STORE MATERIAL IN AREAS
WHERE TEMPERATURES RANGE FROM 50 (F) TO 90 (F)
OTHER PRECAUTIONS: N/A
SECTIONS VIII ?CONTROL MEASURES
RESPIRATORY PROTECTION: WHEN SPRAYING OR SANDING DRY FILM, USE NIOSH APPROVED RESPIRATORS WITH SOLID PARTICULATE
CARTRIDGES
VENTILATION: USE ADEQUATE VENTILATION IN VOLUME AND PATTERN TO MAINTAIN EXPOSURE LEVELS BELOW THAT LISTED IN
SECTIONS II & IX
PROTECTIVE GLOVES: USE NEOPRENE RUBBER GLOVES TO PREVENT SKIN CONTACT
EYE PROTECTION: USE CHEMICAL SPLASH GOGGLES WITH SIDE SHIELDS
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: N/A
WORK / HYGIENIC PRACTICES: WASH HANDS BEFORE EATING, SMOKING OR USING WASH ROOM. WASH COMTAMINATED CLOTHING
BEFORE REUSE.
SECTION IX ?ADDITIONAL INGREDIENTS
OCCUPATIONAL
EXPOSURE LIMITS
WEIGHT
PRODUCT INGREDIENT CAS. NO. PEL TLV OTHER PERCENT
15 MG/M3 10 MG/M3
WHITE TITANIUM DIOXIDE 13463-67-7 NOT ESTAB 15
0.1 MG/M3(1) 0.1 MG/M3 (1)
(135) CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 4.7
____________________________________________________________________________________________________________
15 MG/M3 10 MG/M3
GULL TITANIUM DIOXIDE 13463-67-7 NOT ESTAB 10
0.1 MG/M3 (1) 0.1 MG/M3 (1)
(136) CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 5.7
5 MG/M3
BLACK IRON OXIDE 1317-61-9 10 PPM (STEL) NOT ESTAB <5
5 MG/M3
YELLOW IRON OXIDE 51274-00-1 10 PPM (STEL) NOT ESTAB <5
____________________________________________________________________________________________________________
15 MG/M3 10 MG/M3
DOVER GRAY TITANIUM DIOXIDE 13463-67-7 NOT ESTAB 10
0.1 MG/M3 (1) 0.1MG/M3 (1)
(137) CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 6.62
5MG/M3
BLACK IRON OXIDE 1317-61-9 10 PPM (STEL) NOT ESTAB <5
___________________________________________________________________________________________________________
GEORGETOWN
15 MG/M3 10 MG/M3
GRAY TITANIUM DIOXIDE 13463-67-7 NOT ESTAB 5
0.1MG/M3 (1) 0.1MG/M3 (1)
(138) CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 4.5
DISPERSED COLOR NOT ESTAB NOT ESTAB NOT ESTAB NOT ESTAB <5
____________________________________________________________________________________________________________
15 MG/M3 10 MG/M3
TERRA COTTA TITANIUM DIOXIDE 13463-67-7 NOT ESTAB <5
0.1MG/M3 (1) 0.1MG/M3 (1)
(139) CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 5
5 MG/M3
RED IRON OXIDE 1332-37-2 10 PPM (STEL) NOT ESTAB <5
5 MG/M3
YELLOW IRON OXIDE 51274-00-1 10 PPM (STEL) NOT ESTAB <5
____________________________________________________________________________________________________________
5 MG/M3
PERSIAN RED RED IRON OXIDE 1332-37-2 10 PPM (STEL) NOT ESTAB 5-10
0.1 MG/M3 (1) 0.1 MG/M3 (1)
(140) CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 7.84
____________________________________________________________________________________________________________
15 MG/M3 10 MG/M3
SANDSTONE TITANIUM DIOXIDE 13463-67-7 NOT ESTAB 10
0.1MG/M3 (1) 0.1MG/M3 (1)
(141) CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 7
____________________________________________________________________________________________________________
15 MG/M3 10 MG/M3
BAMBOO BEIGE TITANIUM DIOXIDE 13463-67-7 NOT ESTAB 5-10
5 MG/M3
(142) YELLOW IRON OXIDE 51274-00-1 10 PPM (STEL) NOT ESTAB <5
0.1 MG/M3 (1) 0.1 MG/M3 (1)
CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 6.69
____________________________________________________________________________________________________________
0.1 MG/M3 (1) 0.1 MG/M3 (1)
TINT BASE CRYSTALLINE SILICA* 14808-60-7 NOT ESTAB 5.4
(143)
____________________________________________________________________________________________________________
(1) = TIME WEIGHTED AVERAGE * SEE SECTION VI
SECTION X ?DISCLAIMER
This information is furnished without warranty, representation, inducement or license of any kind, except that it is accurate to the best of UGL's knowledge, or obtained
from sources believed by UGL to be accurate, and UGL does not assume any legal responsibility for use or reliance upon same. Before using any product, read the
label.