The Chromaline Corporation MATERIAL SAFETY DATA SHEET
$%&'!' () %*+( ,,!, -).!/0
() (( (
(% ( , %, (%,%'!(
() (
%(% (( )(((, %
((
(1(( (
() ( 1, %,1,1
( ( ,
((,
2 3'4 3( (
,
( ) (5
5,,% 6 ) ,,( , (
((,(
(,( ('75 (
8, (
)
,%% ()
)'
9( ((%,)(:(
(8 , %
,) ( %, ) (
, (
'
Section I - Chemical Product and Company Identification
minimal 0
Hazardous Materials
Manufacturer's Name slight 1
Identification System (HMIS )
The Chromaline Corporation moderate 2
Street Address City, State, and Zip Code serious 3
Health 1
severe 4
4832 Grand Avenue Duluth, MN 55807 Flammability 0
For product information or customer service: 218/628-2217 Reactivity 0
Personal Protection H & Q
For Chemical Emergencies contact:
CHEMTREC Emergency Telephone No.
United States - 800/424-9300
International - 703/527-3887 (collect)
Product Class Chemical Name (CAS #)
Water Based Emulsion N/AP
Trade Name Formula N/AP = Not Applicable
Chroma/Tech PL-2 N/AP
Section II - Hazardous Ingredients
9 VAPOR PRESSURE
mm Hg. 20 C
3
Ingredient PERCENT PPM mg/M LEL
Isopropanol 1 - 2% N/AP---------------------------------------------------------------------------
Section III - Physical Data
Vapor Density Heavier Lighter, Than Air
Boiling Range 100篊 (212篎)
Evaporation Rate Faster Slower, than Water Percent Volatile Weight per
by Weight 58% Gallon 9.08 lb/gal
Solubility in Water Miscible
Section IV - Fire and Explosion Hazard Data
Flash Point 105篎
Extinguishing Media - "Class B" Fire Extinguishers
Unusual fire and explosion Hazards
Under high heat, decomposition products may present a hazard.
Special Fire Fighting Procedures
For full protection, fire fighters are recommended to wear NIOSHA-MSHA approved self-contained breathing apparatus
and chemical resistant clothing.
!"
#
Section V - Health Hazard Data
Threshold Limit Value N/AP
Effects of Overexposure
Not established for product: However, irritation may occur with prolonged contact to skin.
Emergency and First Aid Procedures INGESTION: Drink water, do not induce vomiting. Consult Physician or poison
control center. Treat symptomatically. SKIN: Wash with soap and water. Remove contaminated clothing. Should
irritation persist, get medical help. EYES: Flush with water extensively for 15 minutes. Get medical help. Note to
physician: There is no antidote. Treat symptomatically. INHALATION: Remove to fresh air.
Section VI - Reactivity Data
Unstable
Stability X Stable
Conditions to Avoid: Strong light and high heat.
Incompatibility (Materials to Avoid) Light, heat, oxidizers
Hazardous Decomposition Products
If burned, will give off oxides of nitrogen, CO2, and CO.
May Occur
Hazardous Polymerization X Will Not Occur
Section VII - Spill or Leak Procedures
Steps to Be Taken In Case Material Is Released Or Spilled
Wash with copious amounts of water. Absorb diluted spill and dispose.
Waste Disposal Method
Either A) Incinerate at authorized facility or B) Landfill in authorized facility in accordance with federal, state, and local
regulations.
We make no guarantee or warranty of any kind that the use or disposal of this product is in compliance with all federal, state, or local laws. It is the
obligation of each user of the product mentioned herein to determine and comply with the requirements of all applicable statutes.
Section VIII - Special Protection Information
Respiratory Protection
Do not breathe vapors or mists. Wear O.S.H.A. (29 CFR 1910.134) protection as necessary. Contaminant level will
vary dependent on the operation.
Ventilation
Provide adequate ventilation as necessary.
Protective Gloves Recommended
Eye Protection Recommended
Other Protective Equipment - Apron and safety boots recommended.
Section IX - Special Precautions
Precautions To Be Taken In Handling And Storing
Store between 50F - 80F for maximum storage life.
Other Precautions - Do not take internally. Avoid splashing in eyes. Keep out of reach of children. Industrial Use Only.
Section X - Regulatory Information
DOT Category 49 CFR 173.120 (a) (3). Not regulated. Does not sustain combustion according to ASTM 4206 or
procedure in Appendix H.
TSCA All ingredients are listed chemicals in the TSCA registry.
California Proposition 65: The Safe Drinking Water and Toxic Enforcement Act of 1986:
This product contains chemical(s) known to the state of California to cause cancer (c) or reproductive (r) damage.
<0.0004% 1, 4 Dioxane (c) 123-91-1 listed January 1, 1988
<0.0029% Acetaldehyde (c) 75-07-0 listed April 1, 1988
<0.0139% Formaldehyde (c) 50-00-0 listed January 1, 1988
<0.0003% Toluene (r) 108-88-3 listed January 1, 1991
!"
#
|