Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
International Emergency: +01-813-248-0585
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: VR-1A VINYL & LEATHER REPAIR KIT
Item No: 80902
Product Type: Sealant
2. COMPOSITION/INFORMATION ON INGREDIENTS
Component Weight% ACGIH; TLV-TWA OSHA PEL
1000 ppm; 2400 mg/m3
ACETONE 40-50 500 ppm
67-64-1
200 ppm; 590 mg/m3
TETRAHYDROFURAN 20-30 50 ppm
109-99-9
VINYL COPOLYMER 15-25 Not listed Not listed
9003-22-9
BENZOATE ESTERS <10 Not listed Not listed
MIXTURE
5 mg/m3, TWA
SILICON DIOXIDE, AMORPHOUS <5 Not listed
112945-52-5
3. HAZARDS IDENTIFICATION
This material is irritating to skin, eyes and mucous membranes. Note: This product does not contain
Toxicity:
microcyrstalline silica.
Eye and skin contact, ingestion, inhalation
Primary Routes of Entry:
Skin: Exposure may cause mild skin irritation. Prolonged or repeated exposure may dry the skin.
Signs and Symptoms of Exposure:
Symptoms may include redness, burning, drying, cracking and skin burns. Preexisting skin disorders may
be aggravated by exposure. Skin absorption is possible, but harmful effects are not expected from this
route under normal conditions of handling and use. Excessive overexposure may cause giddiness,
dizziness, headache, nausea and in extreme cases, unconsciousness and respiratory depression. Inhaling
may cause mild irritation to the nose, throat and respiratory tract and may result in central nervous system
(CNS) depression.
Component Weight% NTP ACGIH Carcinogens IARC
ACETONE 40-50 Not known A4 - Not Classifiable
67-64-1 as a Human
Carcinogen
TETRAHYDROFURAN 20-30 male rat-some A3 Confirmed animal
109-99-9 evidence; female rat- carcinogen with
no evidence; male unknown relevance to
mice-no evidence; humans
female mice-clear
evidence
VINYL COPOLYMER 15-25 Group 3 Supplement 7, 1987;
9003-22-9 Monograph 19, 1979
SILICON DIOXIDE, AMORPHOUS <5 Amorphous Silica, Group 3:
112945-52-5 Vol. 68: 1997
Preexisting pulmonary and dermatological disorders.
Medical Conditions Recognized as
Being Aggravated by Exposure:
4. FIRST AID MEASURES
Do not induce vomiting. Slowly dilute with 1-2 glasses of water or milk and seek medical attention. Never
Ingestion:
give anything by mouth to an unconscious person.
Move to fresh air in case of accidental inhalation of vapours. Oxygen or artificial respiration if needed.
Inhalation:
Obtain medical attention.
Wash off with soap and water. If skin irritation persists, call a physician.
Skin Contact:
1 of 3
Product Name: VR-1A VINYL & LEATHER REPAIR KIT Item No: 80902
4. FIRST AID MEASURES
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
0癋 TCC
Flash Point 癋(C?:
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
Firefighters should wear self-contained breathing apparatus. Water spray
Special Fire-Fighting Procedures:
may be ineffective on flames but should be used to keep fire-exposed
containers cool.
Hydrogen chloride, Irritating vapors, Oxides of carbon, Oxides of
Hazardous Products of Combustion:
phosphorus
Vapors may travel from container toward sources of ignition and flashback.
Unusual Fire/Explosion Hazards:
Acetone: 2.6; tetrahydrofuran: 2
Lower Explosive Limit:
Acetone: 12.8; tetrahydrofuran: 11.8
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Eliminate all sources of ignition. Maintain good ventilation. Take up with an inert absorbent. Store in a
Spill Procedures:
closed waste container until disposal.
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 100癋 (38癈).
Storage:
Avoid breathing vapors, if exposed to high vapor concentration, leave area at once. Avoid contact with skin
Handling:
and eyes. Do not use near heat, sparks or open flame. Keep container closed when not in use. Use only in
a well ventilated area. Wash thoroughly after handling.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses.
Eyes:
Neoprene or nitrile gloves recommended.
Skin:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
Ventilation:
limits (or to the lowest feasible levels when limits have not been established) during the use of this product.
An approved organic vapor respirator should be worn when exposures are expected to exceed the
Respiratory Protection:
applicable limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Clear liquid
Appearance:
Pungent
Odor:
135癋
Boiling Point:
Does not apply
pH:
Slight
Solubility in Water:
0.94
Specific Gravity:
25%
VOC(Wt.%):
Not Determined
Vapor Pressure:
>1
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
Will not occur.
Hazardous Polymerization:
Strong oxidizers, Acids, Reducing agents
Incompatabilities:
Keep away from heat, sparks and open flame. - No smoking.
Conditions to Avoid:
Hydrogen chloride, Irritating vapors, Oxides of carbon, Oxides of
Hazardous Products of Combustion:
phosphorus
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
2 of 3
Product Name: VR-1A VINYL & LEATHER REPAIR KIT Item No: 80902
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations..
D001 as per 40CFR 261.21
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Ground Transport (DOT)
Consumer Commodity (not more than one liter)
DOT Shipping Name:
ORM-D
Hazard Class:
None
UN/ID Number:
IATA
Consumer Commodity (Not more than 1 liter)
Proper Shipping Name:
Class 9
Class or Division:
ID 8000
UN/ID Number:
IMDG
Adhesives containing flammable liquid, Limited Quantity
Proper Shipping:
Class 3, PG II
Hazard Class:
UN 1133
UN Number:
None
Marine Pollutant:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
None
California Proposition 65: No California Prop 65 chemicals are known to be present at or above the No Significant Risk Level
TSCA Inventory Status: All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 2, FLAMMABILITY 3 , REACTIVITY 1.
Estimated NFPA Rating:
HEALTH 2, FLAMMABILITY 3, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Manager-Environmental, Health & Safety
Prepared By: Revision Date: November 17, 2009
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 06106 2
Company: Revision
Number:
1-87-Permatex (877) 376-2839
Telephone No.:
3 of 3
|