Sika Sarnafil Inc.
100 Dan Road
Canton, MA 02021-2842
Sarnafil T Clean
MSDSFILE: TCLEAN PRINT DATE: 11/13/2006
REVISION DATE: 1/02/2007
Material Safety Data Sheet
(Complies with 29 CFR 1910.1200 Hazard Communication Standard)
SECTION 1 Product and Company Identification
TRADE NAME: Sarnafil T Clean
SYNONYMS:
MANUFACTURER: Sika Sarnafil Inc.
ADDRESS: 100 Dan Road, Canton, MA 02021-2842
EMERGENCY NUMBERS: CHEMTREC Transportation Emergency (24 hr.) (800) 424-9300
MSDS and Product Information (M -F, 8:30am -5:00pm EST) (800) 451-2504
SECTION 2 Information on Hazardous Ingredients
CHEMICAL/COMMON NAME CAS NUMBER PERCENT
Xylene 1330-20-7 50-100%
1-Methoxy-2-Propanol 107-98-2 10-25%
SECTION 3 Hazards Identification
EYES: Irritation may occur with exposure to concentrated vapors or liquid contact.
SKIN: Prolonged skin contact may cause skin irritation.
INHALATION: Prolonged or repeated exposure to vapors above the permissible concentration may cause dizziness,
headache, nausea, vomiting, and inebriation.
INGESTION: May cause gastrointestinal irritation, nausea, vomiting, and diarrhea.
SYMPTOMS: See above inf ormation.
SECTION 4 First Aid Measures
EYES: Immediately flush eyes with plenty of water for at least 15 minutes. If irritation persists, seek medical
attention.
SKIN: Remove contaminated clothing and wash skin with soap and plenty of water.
INHALATION: Move to fresh air. If not breathing, give artificial respiration and seek medical attention immediately.
Trained personnel should only administer oxygen.
INGESTION: If swallowed, call a physician immediately. ONLY induce vomiting at the instruction of a physician.
Never give anything by mouth to an unconscious person.
Page 1 of 5
www.sikacorp.com (800) 451-2504
Sika Sarnafil Inc.
100 Dan Road
Canton, MA 02021-2842
Sarnafil T Clean
MSDSFILE: TCLEAN PRINT DATE: 11/13/2006
REVISION DATE: 1/02/2007
SECTION 5 Fire Fighting Measures
FLASH POINT ( F/ C) LEL (volume %) UEL (volume %)
86?F / 30?C 1.1 % 13.8%
Extinguishing Media: Alcohol resistant foam, dry chemical, carbon dioxide, water-spray.
Fire Fighting Procedures: Wear a self -contained breathing apparatus. Cool containers with water-spray.
Unusual Hazards: The vapor/air mixture may be explosive even in empty, unclean receptacles. Vapors are
heavier than air and spread along the ground; therefore, a high volume water jet must NOT
be used.
Combustion Products: May form carbon dioxide and carbon monoxide.
SECTION 6 Accidental Release Measures
Ensure adequate ventilation. Use personal protective equipment. In case of vapor formation, use respirator. Remove all
sources of ignition. Do NOT smoke. Do NOT flush into surface water or sanitary sewer system. Clean contaminated
surface thoroughly. Soak up with inert absorbent material (e.g., sand, silica gel, acid binder or universal binder). Shovel
into suitable container for disposal.
SECTION 7 Handling and Storage
Keep container tightly closed. Use only in well-ventilated areas. Avoid contact with the skin and the eyes. Keep away
from heat and sources of ignition. Do not smoke. Take precautionary measures against static discharges. Keep tightly
closed in a dry, cool and well-ventilated place. Incompatible with oxidizing agents. Keep away from food, drink and
animal feeding.
SECTION 8 Exposure Controls / Personal Protection
Engineering Controls: Mechanical ventilation may be necessary if working with the product in enclosed areas or at
elevated temperatures.
Personal Protective Equipment:
EYES: Tightly fitting safety goggles. Eye wash bottle with pure water.
SKIN: Long sleeved clothing, solvent-resistant gloves.
RESPIRATORY: In case of insufficient ventilation, wear suitable NIOSH-approved respirator, self-contained
breathing apparatus, or air-supplied respirators dependent on concentration.
Exposure Guidelines:
CHEMICAL OSHA ACGIH TLV
TWA = 100 ppm; 434 mg/m3
Xylene PEL = 100 ppm
TWA = 435 mg/m3 STEL = 150 ppm; 651 mg/m3
TWA = 100 ppm; 369 mg/m3
1-Methoxy-2-Propanol Not Listed
STEL = 150 ppm; 553 mg/m3
PEL = Permissible Exposure Limits TWA = Time Weighted Average (8 hr.)
TLV = Threshold Limit Value STEL = Short Term Exposure Limit (15 min.)
Page 2 of 5
www.sikacorp.com (800) 451-2504
Sika Sarnafil Inc.
100 Dan Road
Canton, MA 02021-2842
Sarnafil T Clean
MSDSFILE: TCLEAN PRINT DATE: 11/13/2006
REVISION DATE: 1/02/2007
SECTION 9 Physical and Chemical Properties
APPEARANCE: Red Liquid
ODOR: Hydrocarbon-Like Odor
BOILING POINT (@ 760 mm Hg): 120 C
SPECIFIC GRAVITY: 0.87
LIQUID DENSITY: 7.25 lbs./gal
SOLUBILITY IN WATER: Insoluble
% VOLATILE VOLUME: 100%
EVAPORATION RATE (Butyl Acetate=1): N/A
VAPOR PRESSURE (mm Hg): 8 mm Hg @ 68 F / 20 C
VAPOR DENSITY (air = 1): Heavier than air
SECTION 10 Stability and Reactivity
CONDITIONS TO AVOID:
Heating can cause thermal decomposition.
INCOMPATABILITY WITH OTHER MATERIALS:
Strong oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS:
Fire may produce carbon monoxide and carbon dioxide.
HAZARDOUS POLYMERIZATION:
Will not occur.
SECTION 11 Toxicological Information
CARCINOGENICITY: NTP : No. OSHA : No. IARC : Xylenes: Group 3 (Unclassifiable as to
Human Carcinogenicity)
SECTION 12: Ecological Information
Ecological information is not available.
SECTION 13 Disposal Considerations
Dispose in accordance with applicable Federal, State, and Local regulations. Residues and spilled material are
hazardous waste due to flammability. Law generally requires incineration at an EPA -permitted hazardous waste
management facility.
Page 3 of 5
www.sikacorp.com (800) 451-2504
Sika Sarnafil Inc.
100 Dan Road
Canton, MA 02021-2842
Sarnafil T Clean
MSDSFILE: TCLEAN PRINT DATE: 11/13/2006
REVISION DATE: 1/02/2007
SECTION 14 Transportation Information
D.O.T. Primary Hazard Label: Flammable Liquids, n.o.s. (Xylenes, 1-Methoxy-
2-Propanol)
D.O.T. Hazard Class: 3
D.O.T. Identification Number (UN/NA): UN 1993
D.O.T. Packing Group: III
SECTION 15 Regulatory Information
U.S. Federal Regulations
SARA Title III, Section 302:
This product is not regulated under SARA Title III, Section 302 Extremely Hazardous Substances (40 CFR Part
355).
SARA Title III, Section 311/312:
Chronic (X) Acute (X) Fire ( X ) Pressure ( ) Reactivity ( )
SARA Title III, Section 313:
This product contains toxic chemicals subject to the reporting requirements of SARA Title III, Section
313 (40 CFR 372) of the Emergency Planning and Community Right-To-Know Act of 1986.
State Regulations
CALIFORNIA SAFE DRINKING ACT (PROP 65 for Carcinogen and Teratogen):
This product contains chemicals currently on the California List of Known Carcinogens and Reproductive
Toxins.
Chemical Name CAS No. Toxin Type
None.
SECTION 16 Other Information
HMIS NFPA
HEALTH: 2 N/A
FLAMMABILITY: 3 3
REACTIVITY: 0 0
PERSONAL PROTECTION: B N/A
Page 4 of 5
www.sikacorp.com (800) 451-2504
Sika Sarnafil Inc.
100 Dan Road
Canton, MA 02021-2842
Sarnafil T Clean
MSDSFILE: TCLEAN PRINT DATE: 11/13/2006
REVISION DATE: 1/02/2007
Sika Sarnafil Inc. Disclaimer of Expressed and Implied Warranties
The information in this Material Safety Data Sheet is offered in good faith as accurate at the date of issuance. No
warranty of merchantability, fitness for any particular purpose, or any other warranty is expressed or is to be implied
regarding the accuracy or completeness of this information, the safety of this product, or the hazards related to its use.
This information and product are furnished on the condition that the person receiving it shall make their own determination
as to the suitability of the product for their particular purpose and on the condition that they assume the risk of use thereof.
Compliance with all applicable Federal, State, and Local laws and regulations remains the responsibility of the user.
Page 5 of 5
www.sikacorp.com (800) 451-2504
|