1 of 3
MATERIAL SAFETY DATA SHEET
MON-ECO INDUSTRIES, INC.
5 JOANNA COURT
EAST BRUNSWICK, NJ 08816-2108
PHONE: 732-257-7942
FAX: 732-257-6525
I. GENERAL INFORMATION
DATE: March 19, 2009
SUPERCEDES: August 26, 2008
MON-ECO CODE: 22-15 LV
TRADE NAME & SYNONYMS: Eco-Hanger Grip Adhesive Lo VOC
CHEMICAL FAMILY: Solvent Based Adhesive
PROPER DOT SHIPPING NAME: Flammable Liquid, N.O.S., 3, PG III.
DOT HAZARD CLASSIFICATION: UN 1993
FOR EMERGENCY CONTACT CHEM-TEL, INC. 1-800-255-3924
II. INGREDIENTS
PRINCIPAL HAZARDOUS COMPONENTS CAS# THRESHOLD LIMIT VALUE
Toluene 17% by wt. 108-88-3 50 ppm
Acetone 14% by wt. 67-64-1 750 ppm
Methyl Acetate 12% by wt. 79-20-9 200 ppm
These chemicals are subject to the reporting requirements of Section 313 of
SARA Title III. OSHA, NTP or IARC does not class the ingredients in this product
as carcinogens. All ingredients in this product are on the TSCA Inventory.
HAZARD RATING: Health-2, Flammability-3, Reactivity-0
III. PHYSICAL DATA
BOILING POINT: 133篎
SPECIFIC GRAVITY (WATER=1): 1.08
VAPOR PRESSURE (mmHg.): 186
PERCENT VOLATILE: 44% by weight
VAPOR DENSITY (AIR=1): 2
EVAPORATION RATE( N-Butyl Acetate =1): 3.2
SOLUBILITY IN WATER: Not soluble.
APPEARANCE & ODOR: Soft gray paste, mild odor.
VOLATILE ORGANIC CONTENT: 1.56 lbs/gal or 187 grams/liter
IV. FIRE & EXPLOSION HAZARD DATA
FLASH POINT (TEST METHOD): Tag closed cup. <0篎
FLAMMABLE LIMITS: LEL:1.2%
UEL: 16.0 %
EXTINGUISHING MEDIA: Foam, dry chemical CO? water fog or spray.
SPECIAL FIRE FIGHTING PROCEDURES: Use air-supplied breathing
equipment for enclosed areas. Avoid breathing of vapor or fumes.
(continued)
22-15 LV
2 of 3
IV. FIRE & EXPLOSION HAZARD DATA (continued)
UNUSUAL FIRE & EXPLOSION HAZARDS: Heat may build up pressure in
closed containers. Cool with water spray.
V. HEALTH HAZARD DATA
Permissible Exposure Level 50 ppm
Threshold Limit Value 100 ppm
Effects Of Acute Overexposure:
Eyes: can cause severe irritation, redness, tearing, blurred vision.
Skin: Prolonged or repeated contact can cause moderate irritation, defatting,
dermatitis.
Breathing: Excessive inhalation of vapors can cause nasal and respiratory
irritation, central nervous system effects including dizziness, weakness, fatigue,
nausea, headache and possible unconsciousness, and even death.
Swallowing: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea.
Aspiration of material into the lungs can cause chemical pneumonitis, which can
be fatal.
First Aid:
If on skin: Thoroughly wash exposed area with soap and water. Remove
contaminated clothing. Launder contaminated clothing before re-use.
If in eyes: Flush with large amounts of water. Lifting upper and lower lids
occasionally. Get medical attention.
If swallowed: Do not induce vomiting. Keep person warm, quiet and get medical
attention. Aspiration of material into the lungs due to vomiting can cause
chemical pneumonits, which can be fatal.
If breathed: If affected remove individual to fresh air. If breathing is difficult,
administer oxygen. If breathing has stopped give artificial respiration. Keep
person warm, quiet and get medical attention.
Primary Route (S) of Entry:
Inhalation, skin contact.
VI. REACTIVITY DATA
STABILTY: Stable
CONDITIONS TO AVOID: None
INCOMPATABILITY:
MATERIALS TO AVOID: Strong oxidants like liquid chlorine.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
HAZARDOUS DECOMPOSITION OF PRODUCTS: Burning may cause toxic
fumes and oxides of carbon.
3 of 3
22-15 LV
VII. ENVIRONMENTAL PROTECTION PROCEDURES
SPILL RESPONSE: Scrape and wipe up - place in sealed container and remove.
WASTE DISPOSAL METHOD: Approved site. Obey local, state and federal
regulations.
VIII. SPECIAL PROTECTION PROCEDURES
EYE PROTECTION: Splash goggles or safety glasses.
SKIN PROTECTION: Neoprene gloves.
RESPIRATORY PROTECTION (SPECIFIC TYPE): NIOSH approved dual
cartridge respirator with cartridges suitable for organic solvent vapor.
VENTILATION RECOMMENDED: Local exhaust = to outdoors.
OTHER PROTECTION: Eye wash, safety shower.
IX. SPECIAL PRECAUTIONS
HYGIENIC PRACTICES IN HANDLING & STORAGE:
Flammable mixture. Do not store near heat, sparks or open flame. Use with
adequate ventilation. Avoid prolonged or repeated breathing of vapor or contact
with skin. Do not take internally in an emergency call a physician. Keep out of
reach of children.
X. SUPPLEMENTAL INFORMATION
WARNING: This product contains chemicals known to the State of California to
cause birth defects or other reproductive harm.
Do not store with strong oxidants like liquid chlorine or concentrated oxygen.
While Mon-Eco Industries, Inc. believes that the data here is factual. The data is not to be considered a warranty or
representation for which Mon-Eco Industries, Inc. assumes legal responsibility. The data is offered solely for your
consideration, investigation and verification. The user must determine if any use of this information is in accordance with
applicable federal, state and local regulations.
|