Crown 1072 Fault-Finder Penetrant Group 1 - Aerosol
Material Safety Data Sheet
SECTION III - PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING POINT: N / AV SPECIFIC GRAVITY (H20=1, @70癋): 0.8
VAPOR DENSITY: Heavier than air SOLUBILITY IN WATER: Negligible
EVAPORATION RATE: Slower than n-Butyl Acetate APPEARANCE AND ODOR: Red liquid with aromatic hydrocarbon odor
The information presented in these forms is believed to be correct and sufficient to meet the requirements of OSHA Hazard Communication
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
standard (29 CFR 1910.1200) concerning worker's right to know. In order for the information contained in the MSDS to be most helpful
FLASH POINT: < 0?F (-18?C) METHOD USED: Estimated FLAMMABLE LIMITS - LEL: 0.7% UEL: 11.8%
we recommend that these forms be made available to all those who handle or may otherwise be exposed to the product.
EXTINGUISHING MEDIA: Carbon dioxide, dry chemical, water spray.
This MSDS covers the following Aervoe aerosol product. SPECIAL FIRE FIGHTING PROCEDURES: Use water spray to cool containers exposed to heat or fire to prevent pressure build up.
Self-contained breathing apparatus should be used if product is involved in fire.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Treat as cylinders of compressed gas. Closed containers may rupture due to pressure
build up from extreme temperature.
PRODUCT NAME:
SECTION V - REACTIVITY DATA
STABILITY: Stable CONDITIONS TO AVOID: Open flames, sparks, electrical arcs.
INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizing agents.
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: Carbon Monoxide, Carbon Dioxide.
1072 Fault-Finder Penetrant Group 1 (formally # 1075)
HAZARDOUS POLYMERIZATION: Will not occur
SECTION VI - HEALTH HAZARD DATA
INHALATION: Respiratory tract irritant. May cause dizziness, light-headedness and / or headaches.
SKIN CONTACT: Prolonged or repeated contact may cause irritation and dermatitis.
EYE CONTACT: Painful with slight to moderate irritation.
SKIN ABSORPTION: Not likely to be absorbed in toxic amounts under normal use.
SECTION I - MANUFACTURER IDENTIFICATION
INGESTION: Not likely to be harmful in small amounts but swallowing large amounts may be harmful.
MANUFACTURER'S NAME: Aervoe Industries Inc. ADDRESS: 1198 Mark Circle, Gardnerville, NV 89410 CARCINOGENICITY: The ingredients are not listed as a human carcinogen by IARC, ACGIH, NTP, or OSHA.
INFORMATION PHONE: 775-782-0100 EMERGENCY PHONE: 1-800-424-9300 TERATOGENICITY: Not established MUTAGENICITY: Not established
DATE REVISED: 03-17-03 REASON REVISED: Revised MEDICAL CONDITION GENERALLY AGGRAVATED BY EXPOSURE: Not established
EMERGENCY AND FIRST AID PROCEDURES: INHALATION - Remove from exposure, seek medical attention if signs/symptoms persist.
SKIN - Wash affected area with soap and water, remove contaminated clothing, seek medical attention if irritation persists.
EYES - Flush immediately with water for 15 minutes, seek medical attention if irritation persists.
SECTION II - HAZARDOUS INGREDIENTS / SARA III INFORMATION INGESTION - Do NOT induce vomiting, drink plenty of water, seek medical attention if irritation persists.
OCCUPATIONAL EXPOSURE LIMITS
HAZARDOUS WEIGHT LD50 SPECIES LC50 SPECIES
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
OSHA PEL ACGIH TLV OTHER
COMPONENTS PERCENT & ROUTE & ROUTE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Remove all sources of ignition. Ventilate area. Prevent from entering a
watercourse. Use an inert absorbent material and non-sparking type tools.
Aromatic Hydrocarbon N / AV N / AV N / AV N / AV
WASTE DISPOSAL METHOD: Dispose of in accordance with local, state and federal regulations. Do not incinerate closed containers.
(CAS 64742-94-5) 30 - 60 PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Do not store above 120?F (49?C). Do not store or use near heat, sparks or flame.
Hydrocarbon Propellant 1000 ppm 1000 ppm N / AV N / AV OTHER PRECAUTIONS: Do not smoke while using this product.
(CAS 68476-86-8) 15 - 40
Petroleum Distillates N / AV N / AV N / AV N / AV
(64741-44-2) 10 - 30 SECTION VIII - CONTROL MEASURES
RESPIRATORY PROTECTION: In areas with poor ventilation, use a NIOSH approved Organic Vapor Cartridge Respirator.
Polypropylene Glycol Monobutyl Ether N / AV N / AV 16810 mg / kg (Rat-Oral) N / AV
For concentrations above the TLV (as defined in Section II), use a positive air supplied respirator.
(CAS 9003-13-8) 7 - 13
VENTILATION: General ventilation to maintain exposure limits below TLV's as defined in Section II.
*N-Methyl-2-Pyrrolidone N / AV N / AV 4200 mg / kg (Rat-Oral) > 400 ppm (Rat-Inha)
PROTECTIVE GLOVES: Chemical resistant gloves such as Neoprene or Nitrile rubber.
(CAS 872-50-4) 1-5 EYE PROTECTION: Safety glasses or goggles.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Not established.
WORK / HYGIENIC PRACTICES: Avoid prolonged or repeated contact. Do not breathe vapors. Wash contaminated clothing prior to reuse.
1072MA
SECTION IX - DISCLAIMER
*Indicates toxic chemical(s) subject to the reporting requirements of section 313 of Title III and of 40 CFR 372.
THE INFORMATION CONTAINED HEREIN IS BELIEVED TO BE ACCURATE BUT IS NOT WARRANTED TO BE SO. NOTHING CONTAINED
NOTE: N / AP = Not Applicable N / AV = Not Available HEREIN CONSTITUTES A SPECIFICATION NOR IS IT INTENDED TO WARRANT SUITABILITY FOR THE INTENDED USE.
|